Chicago Electric 92481 - Manuals

Page 2 - READ AND UNDERSTAND ALL INSTRUCTIONS; UNPACKING; IMPORTANT SAFETY INSTRUCTIONS; Item Description

PRODUCT SPECIFICATIONS SAVE THIS MANUAL You will need this manual for the safety warnings and precautions, assembly, operating,inspection, maintenance and cleaning procedures, parts list and assembly diagram.Keep your invoice with this manual. Write the invoice number on the inside of the frontcover...

Page 3 - WORK AREA

3. Keep bystanders, children, and visitors away while operating the SumpPump. Distractions can cause you to lose control. ELECTRICAL SAFETY 1. Grounded tools must be plugged into a GFCI (Ground Fault CircuitInterrupter) outlet properly installed and grounded in accordance with allcodes and ordinance...

Page 5 - SERVICE; GROUNDING; outlet installed by a qualified electrician.

SERVICE 1. Sump Pump service must be performed only by qualified repair personnel.Service or maintenance performed by unqualified personnel could result in a riskof injury. 2. When servicing the Sump Pump, use only identical replacement parts.Follow instructions in the “Inspection, Maintenance, And ...

Page 6 - PAGE 6; SYMBOLOGY; FIGURE B; SPECIFIC SAFETY RULES

SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 6 V ~ A no xxxx/min. No Load Revolutions per Minute (RPM) Amperes Volts Alternating Current Underwriters Laboratories, Inc. Canadian Standards Association Double Insulated SYMBOLOGY FIGURE B FIGURE A 3-PRONG PLUG 120 VOLT, GROUNDED,...

Page 7 - PAGE 7; does get wet, do not unplug the Power Cord. Disconnect; FIGURE C

SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 7 wear nonskid rubber boots when water is on the floor and you must unplug theSump Pump. Never allow the Motor to get wet. Make sure the electrical powersource is a separately fused, grounded, 3-wire type GFCI outlet of 15 AMPcapaci...

Page 8 - SAVE THESE INSTRUCTIONS

SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 8 10. In cold weather, when the Sump Pump is not in use, protect the interior ofthe Pump from freezing by draining the liquid and pumping a permanenttype automobile antifreeze containing a rust inhibitor through the system.A 50% mix...

Page 9 - PAGE 9; FIGURE D

SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 9 6. Set the Sump Pump in place, using the accessory Rope (41). Do not raise orlower the Sump Pump by its Power Cord or by its Discharge Hose.(See Figure D.) 4. Connect the Discharge Hose to the Connector Plug (39) of theSump Pump, ...

Page 10 - TROUBLESHOOTING; to help identify reasons for operating problems. It is; B. Water level in pit may be too low. Add more water to pit.; GPM; Flow Chart

SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 10 9. The Sump Pump will now start and run continuously until electrical power to thePump is shut off. 10. When shutting off power to the Sump Pump, always shut off the electricalpower to the GFCI outlet first. Then, disconnect the ...

Page 12 - PLEASE READ THE FOLLOWING CAREFULLY; FIGURE F

SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 12 with water is recommended. Be sure to flush the system with a neutralizing liquidprior to reuse of the unit. 7. Every two years: Change the oil in the Sump Pump. The Pump holdsapproximately 4-3/4 ounces of oil. Always use a quali...

Page 13 - PARTS LIST

PARTS LIST SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 13 NOTE: Some parts are listed and shown for illustration purposes only, and are not available individually as replacement parts. Part # Description Qty. Part # Description Qty. 1 Power Cord/Plug 1 22 Flange 1 2 Screw 2 2...

Page 14 - ASSEMBLY DIAGRAM

ASSEMBLY DIAGRAM SKU 92481 For technical questions, please call 1-800-444-3353. PAGE 14 NOTE: Some parts are listed and shown for illustration purposes only, and are not available individually as replacement parts. 41: ROPE NOT SHOWN.