Char-Broil 473721007 - Manuals

Char-Broil 473721007 – Manual in PDF format online.

Manuals:

Manual

Manual Char-Broil 473721007

Summary

Page 2 - Natural Gas and Propane Installation Code,; WARNING; Model Number; DANGER

2 • 473721007 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CAUTION For residential use only. Do not use for comm...

Page 3 - TABLE OF CONTENTS; To insure your satisfaction; Do not attempt to repair or alter the

TABLE OF CONTENTS For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installatio...

Page 4 - USE AND CARE

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. • If you see, smell or hear gas escaping, immediately get...

Page 5 - If “growing” bubbles appear do not use or move the LP; Connecting Regulator to the LP Cylinder; LP Cylinder Exchange; Continued on next page.

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...

Page 6 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

Page 7 - Unless briquets are supplied with your grill.); must; CAUTION

For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVER use in...

Page 8 - Troubleshooting Section

CAUTION If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury. Burner Flame Check • Remove...

Page 9 - Cleaning the Burner Assembly; Turn gas off at control knobs and LP cylinder.; “Leak Test”; Storing Your Grill; Cleaning the Burner

Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas off at control knobs and LP cylinder. 2. vaporiser b 3. 4. 5. 6. 7. 8. VERY IMPORTANT: Burner tubes must reengage valve openings. See illustration ...

Page 10 - Food Safety; For more information call: USDA Meat and Poultry Hotline at; How To Tell If Meat Is Grilled Thoroughly

Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four basic steps: Clean: Wash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry. Separate: Separate raw m...

Page 11 - Tools required for assembly:; Phillips screwdriver; Estimated assembly time:; Key Qty; AA

473721007 • 11 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Gas Grill Silouette and Design®, H2O Smoker®, Lava Flame®, MasterFl...

Page 13 - F o; on right

473721007 • 13 2 ASSEMBLY – Model No. 473721007 1 Attach upper front panel to legs using four #10-24 X1/2" machine screws . Secure firebox supports to legs using four #10-24 X 2" machine screws and four #10-24 flange nuts F o r nt Leg assembly, Right 80012673 #10-24 X 1/2" Machine Screw ...

Page 21 - Failure to install grease clip and cup

17 18 473721007 • 21 Insert ends of Swing Away pivot wire into holes in sides of grill lid. Insert ends of Swing Away leg wire into holes in sides of firebox. NOTE: Pivot and leg wires, running side-to-side, should be under wires running front-to-back. If pivot and leg wires are on top, Swing Away i...

Page 23 - LP CYLINDER IS SOLD SEPARATELY.; Fill and leak check; Make sure cylinder valve is facing front of grill.; Slide tank; Always keep LP cylinders in

20 LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder has been filled and leak checked, place cylinder into notches in tank support bracket. Make sure cylinder valve is facing front of grill. Slide tank...

Page 24 - Troubleshooting

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire ...

Page 25 - continued

Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor. Burner(s) will not match light. Low flame, drop in gas flow. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)). Unable to fill LP cylinder. Possible Cause PIEZO PUSH-BUTTON AND ROTARY...

Page 26 - LIMITED WARRANTY

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the rig...

Page 27 - Please register your grill online at:

Please register your grill online at: (If you register online, you do not need to send in this registration card.) WWW.GRILLREGISTRATION.COM Chimenea / Envíelo a: La parrilla estaba ensamblada 473721007 • 27

Page 28 - STOP; Should you encounter a problem with our product; Do not return this product to the store.; WE CAN HELP; GRILL SERVICE CENTER; Grilling Safety Checklist

Char-Broil, LLC Printed in China • Columbus, GA 31902 • STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling...