Blodgett KTT-E Series - Manuals

Page 2 - IMPORTANT NOTES FOR INSTALLATION AND OPERATION; This manual should be retained for future reference.

2 IMPORTANT NOTES FOR INSTALLATION AND OPERATION It is recommended that this manual be read thoroughly and that all instructions be followedcarefully. This is the safety alert symbol. It is used to alert you to potentialpersonal injury hazards. Obey all safety messages that follow thissymbol to avoi...

Page 4 - SERVICE CONNECTIONS; ELECTRICAL CHARACTERISTICS

4 SERVICE CONNECTIONS F E SAFETY RELIEF VALVE 4 [102] 10 [254] 12.5 [318] H J 1.25 [32] L K G 14.50 [368] A ID B C D 4X WELD NUTS 5/16-18UNC 18 [457] 2.25 [57] DIMENSIONS ARE IN INCHES [MM] ELECTRICAL CONNECTION TO BE AS SPECIFIED ON DATA PLATE 6 gallons CAPACITY 10 gallons 12 gallons MODEL KTT-10E ...

Page 5 - INSTALLATION INSTRUCTIONS; The kettle must be installed in accordance with:

5 1.0 INSTALLATION INSTRUCTIONS Immediately after unpacking, check for possible shipping damage. If the kettle is found to bedamaged, save the packaging materials and contact the carrier within 15 days of delivery. 1. The kettle must be installed in accordance with: 2. State and/or local codes. 3. I...

Page 6 - Ground appliance to terminal provided inside console housing.; WARNING

6 1.0 INSTALLATION INSTRUCTIONS (Continued) 1. A waterproof electrical connection for power supply to console housing must be provided. 2. Ground appliance to terminal provided inside console housing. 3. Turn power ON and check for proper operation. FIGURE 1 WARNING DISCONNECT ELECTRICAL POWER SUPPL...

Page 7 - the desired setting from 1 to 10.

7 2.0 INTRODUCTION DESCRIPTION Models KTT-6E (6 gallon capacity) and KTT-10E (10 gallon capacity) and KTT-12E (12 galloncapacity) electrically powered, self-contained, countertop, tilting kettles. Each model has ajacket of double-wall construction forming a sealed reservoir around the lower two-thir...

Page 8 - OPERATION INSTRUCTIONS; NOTE

8 3.0 OPERATION INSTRUCTIONS 1. Ensure that the external electrical shut-off to the kettle is on. 2. Check pressure gauge for correct cold kettle reading. Reading should be in the green vacuum zone. If reading is not in the vacuum zone, follow VENTING INSTRUCTION prior tousing the kettle. 3. Place p...

Page 9 - Add water to kettle for cleaning purposes.; TILTING INSTRUCTIONS; Pull out the tilt knob near top right of console.

9 3.0 OPERATION INSTRUCTIONS (Continued) 7. When cooking is finished set thermostat knob and power switch to the OFF position. 8. Pour finished product from kettle using tilt handle. Be careful to avoid splashing. 9. Add water to kettle for cleaning purposes. 10. Wash kettle thoroughly. See CLEANING...

Page 10 - CLEANING INSTRUCTIONS; Add water and mild detergent to the kettle immediately after use.; NOT RECOMMENDED

10 4.0 CLEANING INSTRUCTIONS The kettle interior and exterior should be thoroughly washed after each use in preparation of adifferent food. 1. Add water and mild detergent to the kettle immediately after use. 2. Scrub kettle interior with nylon brush. 3. Loosen food which is stuck to kettle by allow...

Page 11 - GENERAL MAINTENANCE; At exterior rear of kettle jacket remove nut from Air Vent.; VENTING INSTRUCTION; With an empty kettle, place power switch to the ON position.

11 5.0 TROUBLESHOOTING 5.1 GENERAL MAINTENANCE No general maintenance is required other than adhering to the Cleaning Procedure Instructions. 5.2 LOW WATER LEVEL Proper water level must be maintained within the jacket for the kettle to operate. Depletion ofwater may occur from excessive opening of, ...

Page 13 - Clear yellow liquid. Odourless. Avoid temperatures above 450

13 S HAZARDS IDENTIFICATION EMERGENCY OVERVIEW POTENTIAL HEALTH EFFECTS (See Section 11 for toxicological data.) EYE: May cause slight transient (temporary) eye irritation. Corneal injury is unlikely. Mists may cause eye irritation. SKIN CONTACT: Prolonged contact is essentially nonirritating to ski...

Page 17 - TOXICOLOGICAL INFORMATION; (See Section 3 for Potential Health Effects. For; ECOLOGICAL INFORMATION; (For detailed Ecological data, write or call the address or; DISPOSAL CONSIDERATIONS; (See Section 15 for Regulatory Information)

17 11. TOXICOLOGICAL INFORMATION (See Section 3 for Potential Health Effects. For detailed toxicological data, write or call the address or non-emergency number shown inSection 1). SKIN: The LD50 for skin absorption in rabbits is >10,000 mg/kg. SKIN: The LD50 for skin absorption in rabbits is >...

Page 18 - (Not meant to be all-inclusive – selected regulations

18 FOR UNUSED & UNCONTAMINATED PRODUCT, the preferred options include sending to alicensed, permitted: recycler, reclaimer, incinerator or other thermal destruction device. As a service to its customers, Dow can provide names of information resources to help identifywaste management companies an...

Page 20 - CANADIAN REGULATIONS; This product is not a “Controlled Product” under WHMIS.; OTHER INFORMATION; MSDS STATUS: Revised to 16 section format.

20 CANADIAN REGULATIONS WHMIS INFORMATION: The Canadian Workplace Hazardous Materials Information System(WHMIS) Classification for this product is: This product is not a “Controlled Product” under WHMIS. CANADIAN ENVIRONMENTAL PROTECTION ACT (CEPA) This product contains one or more substances which ...