Bakers Pride CO-11E - Manuals

Page 2 - INDEX; INSTALLATION INSTRUCTIONS

INDEX INSTALLATION INSTRUCTIONS SECTION ITEM PAGE 1 Receiving 2 2 Location & Minimum Clearances 2 3A Set-Up & Mounting for COC-E1 3 3B Set-up & Mounting for CO11-E 3 4 Electrical Connections 4 5 Initial Start Up 5 6 System Check & Rotary Controls 5 7 Steam Injection (Optional) 6 OPER...

Page 3 - MINIMUM CLEARANCES; Dow Corning RTV 732 Multipurpose Sealant or; SKETCH “A” - TOP VIEW; SKETCH “B” - FRONT VIEW; Install the shelf supports and the wire shelves.

MINIMUM CLEARANCES COC-E1 CO11-E1 Inches mm Inches mm Right 1 25 1 25 Left 1 25 2 50 Rear 1 25 1 25 Suitable for installation on combustible floors when installed on factory supplied legs or casters. 3A. SET-UP / MOUNTING FOR COC-E1 Counter-top installation must conform to one of the following metho...

Page 4 - ELECTRICAL CONNECTIONS; Only use copper conductors rated at 90°C.

4 2. CO11-2E: INSTALLATION / MOUNTING 6” LEGS a. After unpacking the unit, remove legs and any other material from inside the oven.b. Tilt the bottom oven onto its left side and attach the two mounting plates to the right underside using ½” bolts and washers and tighten firmly. Screw the 6” legs int...

Page 5 - FIELD CONNECTIONS; Remove access panel from the right side of the oven.; SYSTEM CHECK: ROTARY CONTROL; Turn selector switch to “0” position.

2. FIELD CONNECTIONS a. Remove access panel from the right side of the oven. b. Feed power cable (supplied by the customer) through the access hole in the rear of the oven and pull the cable to the front of the oven under the access panel where it may be attached to the cable support bracket. c. Fol...

Page 6 - STEAM INJECTION OPTION; OPERATING INSTRUCTIONS; GENERAL INSTRUCTIONS

7. STEAM INJECTION OPTION The solenoid valve for steam injection is mounted behind the service panel on the right hand side of the unit on COC-E and on the back of the unit on CO11-E. It is pre-wired at the factory. The electronic timer is pre-set at the factory. A ¼” copper tubing with a compressio...

Page 7 - Do not steam injection at temperatures below 275°F (135°C); PROGRAMMING MENUS: MiniChef or FAST Option

3. COOK & HOLD ROTARY CONTROL a. Close the oven door(s). b. Turn selector switch to “High” or “Low” position. The green indicator light near the selector switch will be illuminated. c. Turn the thermostat knob to the desired cooking temperature. d. Upon reaching the set temperature, the amber in...

Page 8 - submerge; CLEANING

8 OVEN INTERIOR: Clean The Racks And Rack Support Guides: Open the doors and remove all wire racks and rack support guides. Take them to the sink and thoroughly clean in warm water with mild detergent or soap. Use a nylon scouring pad or stiff nylon brush. DO NOT USE STEEL WOOL. Clean The Stainless ...

Page 9 - SERVICING; The power supply to the unit must be disconnected prior to service.; SKETCH “C” - CLEANING THE BLOWER WHEEL; ON

4. SERVICING 1. The power supply to the unit must be disconnected prior to service. 2. Most of the service to this unit can be performed from the front and/or the control panel side. 3. For proper service, access to the control panel side of the unit is required. 4. It is necessary to have access to...

Page 12 - Full Size Electric Convection Oven; BAKERS; Figure A

CO11-E Full Size Electric Convection Oven 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Figure A Exterior / Interior / Elements / Controls / Door E S B R AK E S B R AK R P I E D R ...

Page 13 - Item Part # Description Item Part # Description

CO11-E Full Size Electric Convection Oven 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Exterior / Interior / Elements / Controls / Door Item Part # Description Item Part # Descrip...

Page 14 - Full Size Electric Convection Oven; Figure B; Door Chain / Legs & Open Rack Stand; Door Chain Assy; Page 4 of 4; Item

CO11-E Full Size Electric Convection Oven Figure B Door Chain / Legs & Open Rack Stand Item Part # Description 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Steam Option (Not S...

Page 15 - Half Size Electric Convection Oven; Page 2 of 4

COC-E Half Size Electric Convection Oven 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Figure A Exterior / Interior / Elements / Controls / Door 1 1 3 3 4 4 5 5 6 6 Coo l Coo l ow ...

Page 16 - Item Part # Description Item Part # Description; Optional Steam Injection

COC-E Half Size Electric Convection Oven 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Exterior / Interior / Elements / Controls / Door Item Part # Description Item Part # Descript...

Page 17 - Half Size Electric Convection Oven; Door Latch / Electrical Components

34 COC-E Half Size Electric Convection Oven Figure B Door Latch / Electrical Components Item Part # Description Item Part # Description 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRID...

Page 19 - BAKERS PRIDE LIMITED WARRANTY

19 WHAT IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated a...