Bradley SS-2/IR/STD - Manual

Bradley SS-2/IR/STD

Bradley SS-2/IR/STD – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
Page: / 19

Table of Contents:

  • Page 2 – Bradley Corporation •; Pre-Installation Information; Barrier-free and ADA compliant - standard height mounting
  • Page 3 – Express® Lavatory System SS-Series; Standard Height Mounting
  • Page 4 – Standard Height
  • Page 5 – lines will cause the valves to malfunction.; Figure 1a; Installation Instructions
  • Page 6 – Figure 1b
  • Page 7 – installer) at the locations shown in Figures 1a or 1b on pages 5-6.; Figure 2
  • Page 8 – Step 2: Mounting frame to wall; Note: Scuff panel does not need to be removed.; IMPORTANT: Anchoring the frame to a wall that is; behind the frame to ensure that it will not bend when anchored.; Figure 4; Figure 3
  • Page 9 – Step 3: Installing bowl assembly; Note: Refer to Figure 5 below when installing the bowl assembly.; Figure 5
  • Page 10 – Step 4: Connecting supply and drain; drain pipe stubbed out of the wall.; Figure 7
  • Page 11 – Step 5: Connecting electrical and supply tubing; Turn on the water supply to the Express® and check for leaks.; Figure 8
  • Page 12 – Cleaning and Maintenance Instructions; Terreon® and panel maintenance; Wipe the surface with a damp cloth and wipe dry.; Panel cleaning; If vandals create markings on the panel, Bradley recommends using
  • Page 13 – Soap Dispenser Maintenance; Step 1: Fill soap dispensers; Figure 9a
  • Page 14 – Step 2: Change soap type; Pour out all of the soap from the dispenser.; Step 3: Cleaning Instructions; cleaners can mar the surface.; Pour out any remaining soap in the tank.; Clean internal components:; To clean the internal components of the soap dispenser, pump
  • Page 15 – Assembly of Components; Paneling; VernathermTM Thermostatic Mixing Valve
  • Page 16 – Other Replacement Parts; Sensor assembly and solenoid valve; To access solenoids and sensors:; Remove the eight Phillips-head screws located in the bottom of
  • Page 17 – Check Valve Troubleshooting; If water just dribbles or does not flow from sprayhead:; Inspect the stop/check valves for proper installation.; If water sprayhead delivers all hot or cold water:; • A red marking indicates the hot inlet.; Solenoid Valve Troubleshooting; An individual operating station fails to shut off and drips.; Reconnect the wiring per diagram on page 14.; An individual operating station fails to turn on.; the problem valve and reconnect to the adjacent valve.
  • Page 19 – THEN; VernathermTM Mixing Valve Maintenance and Service; Maintenance Instructions; Disassemble the VernathermTM Valve as shown,; Service Suggestions; NOTE: A red marking indicates the hot side of the valve.; IF
Loading the manual

IMPORTANT

Read this entire installation manual
to ensure proper installation, then
file these instructions with the
owner or maintenance department.

Flush all the water supply lines
before making connections.

Wall anchors used must have a
minimum pull-out rating of 1,000
lbs.

Product warranties may be found
under "Product Information" on our
web site at www.bradleycorp.com.

SS-2/IR/STD
SS-2/IR/JUV

Express® Lavatory
System SS-Series

(Standard* and Juvenile Height)

*Express® Lavatory Systems
are ADA compliant.

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . .2
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Installation Instructions . . . . . . . . . . . . . . . . 5-11
Cleaning and Maintenance Instructions . . . . . .12
Soap Dispenser Maintenance . . . . . . . . . . .13-14
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . .14
Assembly of Components . . . . . . . . . . . . . .15-16
Check Valve Troubleshooting . . . . . . . . . . . . . .17
Solenoid Valve Troubleshooting . . . . . . . . .17-18
Vernatherm™ Valve Maintenance & Service . .19

P.O. Box 309, Menomonee Falls, WI 53052-0309
TEL. 1-800-BRADLEY

FAX 262-251-5817

http://www.bradleycorp.com

Installation
Instructions

For Service Only

215-1243 Rev. D; EN 03-813
© 2004 Bradley Corporation
Page 1 of 19

5/11/04

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Bradley Corporation •; Pre-Installation Information; Barrier-free and ADA compliant - standard height mounting

2 Express® Lavatory System SS-SeriesSS-2/IR/STD, SS-2/IR/JUV Installation Instructions - For Service Only 5/11/04 Bradley Corporation • 215-1243 Rev. D; EN 03-813 Pre-Installation Information Barrier-free and ADA compliant - standard height mounting The SS-2/IR/STD Express® Lavatory System must have...

Page 3 - Express® Lavatory System SS-Series; Standard Height Mounting

3 Express® Lavatory System SS-Series Installation Instructions - For Service Only SS-2/IR/STD, SS-2/IR/JUV Bradley Corporation • 215-1243 Rev. D; EN 03-813 5/11/04 8" (203) 22" (559) 34" (864 6" (152) 50" (1270) 8-1/2" (216) 21" (533) 10" (254) Radius 8" (203) Rad...

Page 4 - Standard Height

4 Express® Lavatory System SS-SeriesSS-2/IR/STD, SS-2/IR/JUV Installation Instructions - For Service Only 5/11/04 Bradley Corporation • 215-1243 Rev. D; EN 03-813 38" (965) 34" (864) 29" (737) 11" (279) 9" (229) 6" (152) 4" (102) 30" (762) 25" (635) 11" (279) ...

Other Bradley Models

All Bradley Other