Amtrol TD-41Z - Manual
Amtrol TD-41Z – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Important Steps and Decisions Required Before Installation; FORCED HOT WATER, CLOSED HYDRONIC HEATING SYSTEMS; A. General Installation Requirements; ALL SYSTEMS; TABLE OF CONTENTS
- Page 3 – YOUR HOME’S PLUMBING SYSTEM.; GENERAL SAFETY INFORMATION
- Page 4 – THIS PRODUCT MUST BE INSTALLED AND; Select Circulator versus Zone Valve; IMPORTANT STEPS AND DECISIONS REQUIRED BEFORE INSTALLATION; damage to surrounding property.
- Page 5 – COMPONENTS CHECKLIST; A. Separate circulator; REQUIRED IF; expansion tank and the boiler; REQUIRED COMPONENTS AND
- Page 6 – Avoid high flow domestic water; Clearance From Combustible Surfaces; INSTALLATION INSTRUCTIONS FOR; TYPICAL INSTALLATION
- Page 7 – PIPING SHOULD BE ACCOMPLISHED WITH UNIONS.; Step 1 - Locate the BOILER MATETM near boiler.; EXTERNAL TANKLESS HEATERS; Step 3 - Connect domestic hot water piping Figure 5.; VACUUM BREAKER IS NOT INSTALLED.; FIGURE 3
- Page 8 – Step 7 - Refill the boiler system; SEPARATE CIRCULATOR
- Page 9 – Step 2; TEMPERATURE ADJUSTMENT; If set too high, the resulting hot water can
- Page 11 – FOR FORCED HOT WATER, CLOSED HYDRONIC HEATING SYSTEMS
- Page 12 – BE ELECTRICALLY GROUNDED.; ITEM
- Page 13 – Insufficient or runs out of; TROUBLE SHOOTING CHECKLIST
BOILER MATE
TM
TOP-DOWN
INDIRECT-FIRED WATER HEATERS WITH
TOP-MOUNTED COIL
The heat transfer medium should be water. If any product other than water is used, it must be a
non-toxic fluid suitable for human ingestion as determined by the FDA
Your AMTROL BOILER MATE™ has been carefully assembled and factory tested. To enjoy the full service your BOILER
MATE™ can provide, you should read and follow all of the instructions in this manual. When all installation steps have
been completed, make sure you also follow the enclosed post-installation and start-up checklists before using your
AMTROL product. You should also read carefully the sections describing proper product maintenance, and follow the
required procedures as you use your BOILER MATE™. Return this booklet to its original envelope, and keep it with the
BOILER MATE™.
This manual may become out-of-date by later amendments. Check our web site,
www.amtrol.com or ask your AMTROL supplier for any updates relating to your product.
Our goal is to ensure you are fully satisfied with your new BOILER MATE
™
. If any questions or concerns arise, call
Technical Service at 401-535-1216.
THIS IS THE SAFETY ALERT SYMBOL. IT IS USED TO ALERT YOU TO POTENTIAL PERSONAL
INJURY AND OTHER HAZARDS. OBEY ALL SAFETY MESSAGES THAT FOLLOW THIS
SYMBOL TO REDUCE THE RISK OF POSSIBLE INJURY AS WELL AS PROPERTY DAMAGE.
West Warwick, Rhode Island 02893
INSTALLATION, OPERATION
& MAINTENANCE
INSTRUCTIONS
MODELS:
TD-7Z
TD-41Z
TD-7ZDW
TD-41ZDW
WARNING: REVIEW ALL GENERAL SAFETY INFORMATION ON PAGE 3 PRIOR TO INSTALLATION.
Part #: 9040-628 REV B (7/04)
-1-
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
-2- 1. GENERAL SAFETY INFORMATION ...................................................................................... 3 2. PRE-INSTALLATION CHECKLIST ........................................................................................ 4 Important Steps and Decisions Required Before Installati...
-3- IMPORTANT GENERAL SAFETY INFORMATION - ADDITIONAL SPECIFIC SAFETY ALERTSAPPEAR IN THE FOLLOWING INSTRUCTIONS EXPLOSION HAZARD: DO NOT INSTALL TO A HIGH PRESSURE STEAM BOILER (greater than 15psig). AN EXPLOSION COULD OCCUR. EXPLOSION HAZARD. THE PRESSURE OF THE HEAT TRANSFER MEDIUM MUST BE LIMITE...
-4- j THIS PRODUCT MUST BE INSTALLED AND MAINTAINED BY A LICENSED PROFESSIONAL. IN ADDITIONTO THE INSTRUCTIONS IN THIS MANUAL, FOLLOW ALLAPPLICABLE LOCAL AND STATE CODES OR IN THEABSENCE OF SUCH CODES, THE CURRENT EDITIONS OFTHE NATIONAL PLUMBING CODE AND THE NATIONALELECTRIC CODE. j DRIP PAN AND DR...
