York D1NA018 - Manual
York D1NA018 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – TABLE OF CONTENTS
- Page 3 – INSTALLATION
- Page 5 – NOTE: There may be a local gas utility requirement specifying; GAS CONNECTION; TABLE 2 - NATURAL GAS APPLICATION DATA; TABLE 4 - NATURAL GAS PIPE SIZING CHART
- Page 6 – FLUE VENT HOOD; V E N T O U T L E T S C R E E N; TABLE 6 - PHYSICAL DATA; WARNING: FLUE HOOD SURFACES; CAUTION
- Page 9 – SEQUENCE OF OPERATION; OPERATING INSTRUCTIONS
- Page 10 – MANIFOLD GAS PRESSURE ADJUSTMENT; NOTE: The correct manifold pressure for natural gas furnaces; BURNER INSTRUCTIONS; FIG. 8 - IGNITOR AND FLAME SENSOR ASSEMBLY
- Page 11 – NOTE: To find the BTU input, multiply the number of cubic feet of; SECURE OWNER'S APPROVAL
- Page 12 – NORMAL MAINTENANCE; WARNING: Prior to any of the following maintenance proce-; CLEANING FLUE PASSAGES AND HEATING ELEMENTS; MAINTENANCE
- Page 13 – Checking Supply Air CFM; Remove the two 1⁄4 inch dot plugs in the duct panel.
- Page 16 – TROUBLESHOOTING; INSET
- Page 17 – OPTIONAL CCH
- Page 19 – TYPICAL WIRING DIAGRAM NOTES (See pages 16 and 17)
- Page 20 – NOTES
GENERAL
YORK Model D1NA and D2NA units are cooling/heating air con-
ditioners designed for outdoor installation. Only gas piping, elec-
tric power and duct connections are required at the point of
installation.
The gas-fired heaters have hot surface to pilot ignition. The tu-
bular heat exchangers are aluminized steel.
This appliance is not to be used for temporary heating of build-
ings or structures under construction.
INSPECTION
As soon as a unit is received, it should be inspected for possi-
ble damage during transit. If damage is evident, the extent of
the damage should be noted on the carrier's freight bill. A sepa-
rate request for inspection by the carrier's agent should be
made in writing. Refer to Form 50.15-NM for additional infor-
mation.
REPLACEMENT PARTS
•
Refer to Replacement Parts, Form 530.46-RP1Y, RP2Y,
RP3Y, RP4Y and RP5Y for Key Replacement Parts.
All forms referenced in this instruction may be ordered from:
Standard Register
Norman, OK 73069
Toll Free: Tel. 877-318-9675/Fax. 877-379-7920
APPROVALS
Design certified by CGA and AGA listed as follows:
1. For use as a forced air furnace with cooling unit.
2. For outdoor installation only.
3. For installation directly on combustible flooring or, in U.S.,
on wood flooring or Class A; B; C roof covering material.
4. For installation on combustible material.
5. For use with natural gas and/or propane (LP) gas.
CHAMPION
®
SERIES
SINGLE PACKAGE AIR CONDITIONERS
GAS/ELECTRIC, AIR-COOLED
Supersedes: 035-18265-000-A-0801
035-18265-001-A-0202
INSTALLATION INSTRUCTION
Installer should pay particular attention to the words: NOTE, CAUTION and WARNING. Notes are intended to clarify or make
the installation easier. Cautions are given to prevent equipment damage. Warnings are given to alert installer that personal injury
and/or equipment damage may result if installation procedure is not handled properly.
®
CAUTION
T H E E N C LO SE D IN S TA LLA TIO N IN S TR U C TIO N S A N D A N Y A P PLIC A B LE
LO C AL, ST AT E, A N D N AT IO N A L C O D E S IN C LU D IN G , B U T N O T LIM IT ED
TO , BU ILD IN G , ELE C TR IC A L, AN D M E C H AN IC A L C O D E S .
T H IS P R O D U C T M U S T B E IN S T A L L E D IN S T R IC T C O M P LIA N C E W IT H
WARNING
O P E R A T IO N O F T H E P R O D U C T C O U L D C A U S E P E R S O N A L IN J U R Y
O R P R O P E R T Y D A M A G E .
IN C O R R E C T IN S TA LLAT IO N M AY C R E A TE A C O N D IT IO N W H E R E TH E
—
Do not store or use gasoline or other
f l a m m a b l e v a p o r s a n d l i q u i d s i n t h e
vicinity of this or any other appliance.
—
WHAT TO DO IF YOU SMELL GAS
·
Do not try to light any appliance.
·
Extinguish any open flames.
·
Do not touch any electrical switch; do
not use any phone in your building.
·
Immediately call your gas supplier from
a n e i g h b o r ' s p h o n e . F o l l o w t h e g a s
supplier's instructions.
·
If you cannot reach your gas supplier,
call the fire department.
WARNING: If the information in this manual is
not followed exactly, a fire or explosion may
result causing property damage, personal
injury or loss of life.
MODELS D1NA018 THRU 048
AND MODEL D2NA060
1-1/2 THRU 5 TON
(10 SEER)
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
035-18265-001-A-0202 2 Unitary Products Group TABLE OF CONTENTS TROUBLESHOOTING Troubleshooting Chart ..................................................... 15 TABLES No. Description Page 1 Units Application Data ................................. 3 2 Natural Gas Application Data ........................
Not suitable for use with conventional venting systems. LIMITATIONS These units must be installed in accordance with the followingnational and local safety codes. 1. National Electrical Code ANSI/NFPS No. 70 or Canadian Electrical Code Part 1, C22.1 (latest editions). 2. National Fuel Gas Code Z223....
Scroll compressors operate in one direction only. If a threephase scroll compressor is experiencing: • Low amperage draw • Similar discharge and suction pressures • Increased noise level then the compressor is operating in reverse. To correct thiscondition, switch any two (2) line voltage leads at t...
