Windsor PRSD2 - Manual - manualsarea.com

Page 2 - MACHINE DATA LOG/OVERVIEW; YOUR DEALER

MACHINE DATA LOG/OVERVIEW PRSIF2/PRSDIF2 98902 12/28/01 2 For the name and address of your dealer contact: Windsor Industries YOUR DEALER Name: __________________________________________________________________________________________________ Address: ________________________________________________...

Page 3 - TABLE OF CONTENTS; HOW TO USE THIS MANUAL

TABLE OF CONTENTS PRSIF2/ PRSDIF2 98902 06/28/03 3 Machine Data Log/Overview. ......................... 2Table of Contents ........................................... 3 HOW TO USE THIS MANUAL How to use this Manual. ................................ 1-1 SAFETY Important Safety Instructions .............

Page 4 - THIS PAGE LEFT BLANK INTENTIONALLY

PRSIF2/PRSDIF2 98902 12/28/01 4 THIS PAGE LEFT BLANK INTENTIONALLY

Page 6 - IMPORTANT SAFETY INSTRUCTIONS; When using an electrical appliance, basic precaution; READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE.; SAVE THESE INSTRUCTIONS

PRSIF2/PRSDIF2 98902 12/28/01 2-1 IMPORTANT SAFETY INSTRUCTIONS When using an electrical appliance, basic precaution must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. To reduce the risk of fire, electric shock, or injury: Use only indoors. Do not use ...

Page 7 - HAZARD INTENSITY LEVEL; WARNING; CAUTION; WARNING; Use manufacturer approved replacement parts.; WARNING; CAUTION

HAZARD INTENSITY LEVEL PRSIF2/PRSDIF2 98902 12/28/01 2-2 The following symbols are used throughout this guide as indicated in their descriptions: HAZARD INTENSITY LEVEL There are three levels of hazard intensity identified by signal words - WARNING and CAUTION and FOR SAFETY. The level of hazard int...

Page 8 - GROUNDING INSTRUCTIONS; GROUNDING INSTRUCTIONS:

GROUNDING INSTRUCTIONS PRSIF2/PRSDIF2 98902 12/28/01 2-3 THIS PRODUCT IS FOR COMMERCIAL USEONLY. ELECTRICAL: The amp, hertz, and voltage are listed on thedata label found on each machine. Usingvoltages above or below those indicated on thedata label will cause serious damage to themotors. EXTENSION ...

Page 9 - MACHINE OPERATIONS; SET UP AND OPERATION; SHUT DOWN AND STORAGE

MACHINE OPERATIONS PRSIF2/PRSDIF2 98902 12/28/01 3-1 SET UP AND OPERATION 1. Upon removing your new mini-extractor from thebox, loosen the latch at back end of the machinethat secures the recovery tank to the solutiontank. Remove the recovery tank from thesolution tank. 2. Pour clean, hot water to t...

Page 10 - MAINTENANCE; perform the following repairs.

MAINTENANCE PRSIF2/PRSDIF2 98902 12/28/01 4-1 DAILY MAINTENANCE : Follow same procedure for Shut Down and Storage. PERIODIC MAINTENANCE : 1. Twice a month, flush a white vinegar solution(one quart vinegar to two gallons water) or anti-browning solution (mixed as directed) throughthe extractor. This ...

Page 11 - TROUBLESHOOTING/WIRING DIAGRAM; TROUBLESHOOTING; WIRING DIAGRAM

TROUBLESHOOTING/WIRING DIAGRAM PRSIF2/ PRSDIF2 98902 02/08/03 4-2 TROUBLESHOOTING PROBLEM . CAUSE SOLUTION Little or no solution flow Clogged spray jet on cleaningtool Remove and clean jets Faulty pump Check and replace pump. (Call Windsor Tech. Services first) Incorrectly attached solutionhose Ensu...

Page 12 - RECOVERY TANK PARTS

RECOVERY TANK PARTS PRSIF2/PRSDIF2 98902 06/28/03 5-1 3 4 PARTS INSIDE PORTAL CAP 14 13 2 1 8 6 5 7 12 9 11 5 10

Page 13 - RECOVERY TANK PARTS LIST

RECOVERY TANK PARTS LIST PRSIF2/PRSDIF2 98902 08/19/04 5-2 REF PART NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 05160 1 ASM, ACCESS COVER 2 70546 6 SCR, 8 X ¾ PFHT/S BLK ZINC 3 34391 1 FLOAT ASM SPOTTER WGHT 4 78484 1 TUBE ASM, SPOTTER 5 70683 4 SCR, 10-32 X 3/8 PPHMS SS NP 6 50-501913 1 BRKT, REC/...

Page 14 - SOLUTION TANK PARTS

SOLUTION TANK PARTS PRSIF2/PRSDIF2 98902 02/01/03 5-3 * *

Page 15 - SOLUTION TANK PARTS LIST

SOLUTION TANK PARTS LIST PRSIF2/PRSDIF2 98902 02/01/03 5-4 REF PART NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 75367 1 TANK, SPOTTER SOL DK GRY 2 40066 3 HOSEBARB, 1/8NPT X 3/8 90D PLASTIC 3 270-11A 1 NIPPLE, 1/8 FPT QD MALE BRASS 4 56032 1 NIPPLE, 1/8 CLOSE 5 20042 5 CLAMP, 3/8 HOSE (D-SLOT) 6 39...

Page 16 - REF

LABELS & PARTS LIST PRSIF2/PRSDIF2 98902 12/28/01 5-5 REF PART NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 500009 1 LABEL, W ARNING 2 500528 2 LABEL, PRESTO MAIN 3 500529 2 LABEL, W INDSOR LOGO 6 X 1.75 4 50776 1 LABEL, FOR SAFETY 5 500480 1 LABEL, ON/OFF VAC/PUMP

Page 17 - PRESTO HAND TOOL & PARTS LIST

PRESTO HAND TOOL & PARTS LIST PRSIF2/ PRSDIF2 98902 12/12/02 5-6 REF PART NO. DESCRIPTION SERIAL NO. FROM NOTES: 1 41422 HOUSING, HANDTOOL SPOTTER 2 20053 CLAMP, DHT VALVE 3 39593 HOSE ASM, HOSE/CUFF CONNECTOR 4 270-11 NIPPLE, 1/8 FPT QD FEM BRASS 5 44074 JET, ASM W/O RING 6 70268 SCR, 8-32 X1/4...

Page 18 - PRESTO CART & PARTS LIST

PRESTO CART & PARTS LIST PRSIF2/ PRSDIF2 98902 12/28/01 5-7 REF PART NO. DESCRIPTION SERIAL NO. FROM NOTES: 1 78310 TUBE, CART HANDLE 2 70010 SCREW, 1/4-20 X 1.5 TAP PLTD. 3 57196 NUT, 1/2 STAR LOCK PUSH-ON 4 57104 NUT, 10-32 HEX W/ STAR WASHER 5 89048 WHEEL 6 57047 NUT, 1/4-20 LOCK 7 27637 BASE...

Page 19 - PRESTO DELUXE HAND TOOL ASSEMBLY

PRESTO DELUXE HAND TOOL ASSEMBLY PRSIF2/ PRSDIF2 98902 06/28/03 5-8 REF PART NO. DESCRIPTION SERIAL NO. FROM NOTES: 1 04007 ADAPTOR, 1/8 MPT X 1/8 FPT BR 2 12509 BRUSH, DDH 3 22026 COUPLER, 1.5 VAC HOSE 4 27677 CUFF, SWIVEL DDH HOSE EXIT 5 27678 CUFF, SWIVEL DDH 6 27685 CONNECTOR, 1/4T COMP X 1/8 MP...

Page 20 - SUGGESTED SPARE PARTS

SUGGESTED SPARE PARTS PRSIF2/ PRSDIF2 98902 06/28/03 5-9 PART NO. DESCRIPTION SERIAL NO. FROM NOTES: 44074 JET ASM W/O-RING 44060 JET, 8002 MINI-QUICK REPLACEMENT 330-13 SWITCH, DPST ROCKER 20A 53802 VAC ASM, 230V SPOTTER 250-78A PUMP, 220/240 50HZ FLOJET

Page 21 - NOTES