Page 2 - MACHINE DATA LOG/OVERVIEW; OVERVIEW
MACHINE DATA LOG/OVERVIEW 86317500 CHARIOT SCRUBBER 11/15/08 2 OVERVIEW The Chariot Scrubber is a battery powered, stand-on, hard floor scrubber intended for commercial use. The appliance applies a cleaning solution onto a hard floor, scrubs the floor with brushes or pads, and then vacuums the soile...
Page 3 - TABLE OF CONTENTS; HOW TO USE THIS MANUAL
TABLE OF CONTENTS 86317500 CHARIOT SCRUBBER 11/15/08 3 Machine Data Log/Overview. ............................... 2 Table Of Contents ................................................ 3 HOW TO USE THIS MANUAL How To Use This Manual. .................................... 1-1 SAFETY Important Safety Ins...
Page 4 - REF –
HOW TO USE THIS MANUAL 86317500 CHARIOT SCRUBBER 11/15/08 1-1 This manual contains the following sections: - HOW TO USE THIS MANUAL - SAFETY - OPERATIONS - MAINTENANCE - PARTS LIST The HOW TO USE THIS MANUAL section will tell you how to find important information for ordering correct repair parts. P...
Page 5 - IMPORTANT SAFETY INSTRUCTIONS; When using an battery powered appliance, basic precaution; READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE.; SAVE THESE INSTRUCTIONS
86317500 CHARIOT SCRUBBER 11/15/08 2-1 IMPORTANT SAFETY INSTRUCTIONS When using an battery powered appliance, basic precaution must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. To reduce the risk of fire, electric shock, or injury: Use only indoors. D...
Page 6 - HAZARD INTENSITY LEVEL; FOR
HAZARD INTENSITY LEVEL 86317500 CHARIOT SCRUBBER 11/15/08 2-2 The following symbols are used throughout this guide as indicated in their descriptions: HAZARD INTENSITY LEVEL There are three levels of hazard intensity identified by signal words - WARNING and CAUTION and FOR SAFETY. The level of hazar...
Page 7 - SAFETY LABEL LOCATION
SAFETY LABEL LOCATION 86317500 CHARIOT SCRUBBER 11/15/08 2-3 NOTE: These drawings indicate the location of safety labels on the machine. If at any time the labels become illegible, promptly replace them. PRV NO. 80885 86252520 BATTERYCAUTION PRV NO. 500955 86244300 WARNING LABEL
Page 8 - TECHNICAL SPECIFICATIONS; ITEM DIMENSION/CAPACITY
TECHNICAL SPECIFICATIONS 86317500 CHARIOT SCRUBBER 11/15/08 3-1 ITEM DIMENSION/CAPACITY Nominal power 1800 W Rated Voltage 36 Volts DC Rated Amperage 50 amps Batteries 3 X12 Volt 195-215 AH @ 20 hr. rate Battery Compartment Dimensions 21 in. x 16 in. x 17 in. tall (533mm x 406mm x 432mm) Scrub Brush...
Page 9 - WIDTH
TECHNICAL SPECIFICATIONS 86317500 CHARIOT SCRUBBER 11/15/08 3-2 WIDTH LENGTH HEIGHT ITEM MEASURE Height 50.6 inches (1285 mm) Length 52.5 inches (1330 mm) Width without squeegee 26.5 inches (670 mm) Width of squeegee - Disk Machine 32.7 inches (830 mm) Width of squeegee - Cylindrical Machine 37 inch...
Page 10 - HOW THIS MACHINE WORKS
HOW THIS MACHINE WORKS 86317500 CHARIOT SCRUBBER 11/15/08 3-3 The Chariot® is a battery powered, self-propelled, hard floor scrubber intended for commercial use. The appliance applies a cleaning solution onto a hard floor, scrubs the floor with brushes, and then vacuums the soiled water back into th...
Page 11 - COMPONENTS; Solution Drain Hose
COMPONENTS 86317500 CHARIOT SCUBBER 11/15/08 3-4 1. Control Panel-Drive 2. Control Panel-Scrub 3. Control Housing 4. Pedal Platform 5. Rear Cover 6. Tank 7. Recovery Dome 8. Recovery Drain Hose 9. Scrub Deck Aqua-Mizer™ 10. Scrub Deck Skirts/Side Squeegees 11. Solution Cover 12. Solution Drain Hose ...
Page 12 - DRIVE CONTROLS
DRIVE CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-5 1 2 3 4 5 6 8 9 7
Page 13 - SWITCH
DRIVE CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-6 1. Key Switch 2. Emergency Stop/Brake Switch 3. Directional Control / Drive Reset Switch 4. Throttle Pedal 5. Horn Button 6. Steering Wheel 7. Speed Control 8. Battery Discharge Indicator 9. Hour Meter 1. KEY SWITCH Controls the power for machine...
Page 14 - SLOW; BUTTON; The horn is activated by pressing the horn button.; WHEEL
DRIVE CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-7 SLOW FAST 5. HORN BUTTON The horn is activated by pressing the horn button. 6. STEERING WHEEL The steering wheel turns the front wheel causing the machine to change direction. 7. SPEED CONTROL Controls the maximum speed of the machine. There are ...
Page 15 - BATTERY CHARGE LEVEL INDICATOR
DRIVE CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-8 8. BATTERY CHARGE LEVEL INDICATOR Indicates the charge level of the batteries. The meter display is divided into 10 vertical bars. Bars illuminated on the far right indicate full charge. Bars flashing near the left side indicate the batteries sho...
Page 16 - SCRUB CONTROLS; MODE
SCRUB CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-9 A1 A2 A3 B C 1 1. FUNCTION MODE SWITCH The first two positions are for transport only. See drive controls section. A1 – Daytime cleaning/light cleaning This mode is used for light cleaning. In this mode the machine will propel at a maximum of med...
Page 17 - A3 – Heavy scrub level cleaning
SCRUB CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-10 A3 – Heavy scrub level cleaning This mode is used for heavy level cleaning. In this mode the machine will propel at a maximum of slow speed. The scrub deck will lower to a heavy down pressure. The water will flow at a high rate. The vacuum will ...
Page 18 - SCRUB CONTROLS-SQUEEGEE; Squeegee Deflection Adjustment Knobs
SCRUB CONTROLS-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 3-11 1 2 1. Squeegee Deflection Adjustment Knobs 2. Squeegee Pitch Adjustment Rod
Page 19 - SQUEEGEE PITCH ADJUSTMENT ROD
SCRUB CONTROLS-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 3-12 1. SQUEEGEE DEFLECTION ADJUSTMENT KNOBS (DISK SCRUBBER) Adjusts the deflection along the entire length of the squeegee. To increase squeegee blade deflection, turn the two knobs at the ends of the squeegee counterclockwise. To decrease ...
Page 21 - MACHINE OPERATION; FILLING SOLUTION TANK
MACHINE OPERATION 86317500 CHARIOT SCRUBBER 11/15/08 3-14 FILLING SOLUTION TANK FOR SAFETY: Before leaving or servicing machine; stop on level surface, turn off machine and remove key. 1. Turn the machine power off. 2. Remove solution cover. 3. Fill the solution tank with clean water, leaving enough...
Page 22 - Turn machine power on.
MACHINE OPERATION 86317500 CHARIOT SCRUBBER 11/15/08 3-15 TO BEGIN SCRUBBING When operating the machine around people, pay close attention for unexpected movement. Use extra caution around children. Flammable liquids and/or reactive metals can cause explosions or fire! Do not pick up. 1. Stand on th...
Page 23 - TO STOP SCRUBBING; Allow the throttle pedal to return to neutral.; DOUBLE SCRUB
MACHINE OPERATION 86317500 CHARIOT SCRUBBER 11/15/08 3-16 TO STOP SCRUBBING 1. Rotate the function knob to either transport position. The brush motors will stop and the scrub deck will rise to the park position. After 10 seconds the squeegee will raise, and 10 seconds later the vacuum motor will tur...
Page 24 - SOLUTION TANK
MACHINE OPERATION 86317500 CHARIOT SCRUBBER 11/15/08 3-17 TANK DOME RECOVERY DRAIN HOSE SOLUTION DRAIN HOSE RECOVERY EMPTYING AND CLEANING TANKS 1. Park the machine next to a floor drain. Drain hoses are at the front of the machine. 2. Turn the machine power off. RECOVERY TANK 1. Remove the recovery...
Page 26 - MAINTENANCE; SERVICE SCHEDULE
MAINTENANCE 86317500 CHARIOT SCRUBBER 11/15/08 4-1 SERVICE SCHEDULE MAINTENANCE BEFORE EACH WORK PERIOD AFTER EACH WORK PERIOD 50 HRS 100 HRS 200 HRS Check water level of batteries after charging; add distilled water if necessary. (Wet cell only) * Check that dome and cover seal tightly. * Visually ...
Page 27 - MAINTENANCE-BATTERIES
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-2 1 2 3 4 5 6 1. Rear Cover Retainer Knob 2. Rear Cover 3. Battery Connector-Machine 4. Batteries 5. Battery Tray 6. Battery Tray Latch
Page 29 - CHECKING BATTERY SPECIFIC GRAVITY; SPECIFIC GRAVITY; BATTERY CONDITION; CHARGED; CHARGING BATTERIES
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-4 CHECKING BATTERY SPECIFIC GRAVITY Use a hydrometer to check the battery specific gravity. CHECKING GRAVITY A. Hydrometer B. Battery NOTE: Do not take readings immediately after adding distilled water, if the water and acid are not thorough...
Page 30 - CHANGING BATTERIES; Attach suitable battery lifting
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-5 5. Replace the battery caps, and leave them in place while charging. 6. Unplug the battery connector from the machine. FOR SAFETY: When charging, connect the charger to the batteries before connecting the charger to the AC wall outlet. Nev...
Page 31 - MAINTENANCE-SQUEEGEE
MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 4-6 1 2 3 4 5 6 1. Squeegee 2. Squeegee Deflection Adjustment Knobs 3. Squeegee Level Indicator 4. Squeegee Pitch Adjustment Rod 5. Squeegee Pitch Adjustment Lock Nut 6. Squeegee Retainer Knob
Page 32 - SQUEEGEE BLADES; Pull squeegee assembly from the lifting carrier.; SQUEEGEE DEFLECTION
MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 4-7 SQUEEGEE BLADES The front squeegee blade allows solution to pass through channels in the blade into the squeegee assembly while maintaining vacuum to provide lift. The front blade has four wear surfaces and can be rotated for extended life....
Page 33 - TO ADJUST SQUEEGEE PITCH; CORRECT
MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 4-8 TO ADJUST SQUEEGEE PITCH 1. Choose a smooth, level surface. Turn “ON” the key switch. Lower the squeegee and drive forward at least 2 feet (60cm.). 2. With the squeegee down, stop the machine. Do not allow machine to roll back. FOR SAFETY: ...
Page 34 - MAINTENANCE-SCRUB BRUSHES; SCRUB BRUSHES; is a nylon fiber impregnated with; Mild Grit; is a less aggressive silicone carbide grit; Polypropylene; is a general-purpose scrub brush; FINISHED FLOORS; bristles are used in a variety of applications; White Pads; (Polishing) are used for dry polishing to; Red Pads
MAINTENANCE-SCRUB BRUSHES 86317500 CHARIOT SCRUBBER 11/15/08 4-9 SCRUB BRUSHES There are four different types of brushes available to cover applications from cleaning heavily soiled floors to polishing. A pad driver is also available to take advantage of the many cleaning pads on the market. Please ...
Page 35 - MAINTENANCE-SCRUB DECK
MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBER 11/15/08 4-10 1 2 3 4 6 5 1. Scrub deck Aqua-Mizer™ 2. Aqua-Mizer™ retainer knob 3. Scrub deck skirt 4. Scrub deck skirt stop 5. Scrub brush motor 6. Scrub deck lift actuator
Page 37 - To adjust the actuator:
MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBER 11/15/08 4-12 ACTUATOR SCRUB DECK REMOVAL/REPLACEMENT FOR SAFETY: Before leaving or servicing machine, stop on a level surface. Turn off machine. 1. Remove the two screws that secure actuator spring plate and pull actuator barrel from stud on actuator...
Page 38 - BREAKERS; 8 Amp. Protects the left scrub
MAINTENANCE-CIRCUIT PROTECTION 86317500 CHARIOT SCRUBBER 11/15/08 4-13 1 1. CIRCUIT BREAKERS Circuit breakers interrupt the flow of power in the event of an electrical overload. When a circuit breaker is tripped, reset it by pressing the exposed button. If a circuit breaker continues to trip, the ca...
Page 41 - To repair or replace pump:; Reverse steps to install.; PUMP MOUNTING PLATE; See graphic representation on previous page.; SOLENOID VALVE
MAINTENANCE-SOLUTION STRAINER & PUMP 86317500 CHARIOT SCRUBBER 11/15/08 4-16 1. SOLUTION STRAINER-COARSE Located in bottom of tank. The coarse strainer protects the finer strainer from large debris. If the fine strainer is clean and the pump and solenoid valve are not working, then check the coa...
Page 43 - RECOVERY TANK FLOAT SHUT-OFF; TO REPAIR OR REPLACE VACUUM MOTOR; Remove rear cover from machine.; Vacuum Motor Carbon Brushes
MAINTENANCE-VACUUM & FLOAT SHUT-OFF 86317500 CHARIOT SCRUBBER 11/15/08 4-18 RECOVERY TANK FLOAT SHUT-OFF When water is no longer being vacuumed from the floor and the vacuum fan is operating, the ball float has engaged. The vacuum motor will not vacuum water with recovery tank full. The recovery...
Page 45 - ELECTRIC PARKING BRAKE ENGAGEMENT; Electric Brake Engagement; Push lever firmly in direction of arrow
MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBER 11/15/08 4-20 ELECTRIC PARKING BRAKE ENGAGEMENT FOR SAFETY: Before leaving or servicing machine, stop on a level surface, turn off machine and remove key. Electric Brake Engagement This machine is equipped with an electric parking brake. ...
Page 46 - BRAKE REMOVAL; Remove 4 mounting screws and remove brake.
MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBER 11/15/08 4-21 DRIVE MOTOR CARBON BRUSH REPLACEMENT Do not use a pressure washer to clean around the motors. Use tap pressure only. FOR SAFETY: Before leaving or servicing machine, stop on a level surface, turn off machine and remove key. ...
Page 47 - MAINTENANCE-BAG REPLACEMENT; Remove Dome and set aside.
MAINTENANCE-BAG REPLACEMENT 86317500 CHARIOT SCRUBBER 11/15/08 4-22 REMOVING OR REPLACING BAG 1. Disconnect batteries and make sure parking brake is not overridden. 2. Remove Dome and set aside. 3. Drain all solution from both sides of the bag and rinse well. 4. Remove float cage, loosen screw on el...
Page 48 - PUSHING MACHINE; The machine
MAINTENANCE-BAG TRANSPORTING 86317500 CHARIOT SCRUBBER 11/15/08 4-23 TIE DOWN POINTS PUSHING MACHINE The machine may be pushed for short distances at speeds not to exceed 5 mph. Be careful to avoid damaging machine. The machine may be pushed by hand from the rear. NOTE: To avoid damage caused by reg...
Page 49 - MAINTENANCE-TROUBLESHOOTING
MAINTENANCE-TROUBLESHOOTING 86317500 CHARIOT SCRUBBER 11/15/08 4-24 PROBLEM CAUSE SOLUTION Battery disconnected Check all battery cable connections Emergency shut-off activated Reset Battery cables corroded Clean connections No power to machine Faulty key switch Replace switch Low battery charge Cha...
Page 50 - MACHINE TROUBLESHOOTING
MACHINE TROUBLESHOOTING 86307500 CHARIOT SCRUBBER 11/15/08 4-25 PROBLEM CAUSE SOLUTION Faulty vacuum circuit or switch Check wires & connections Vacuum motor does not run, or runs slowly Worn vacuum motor brushes Replace brushes, check commutator Faulty circuit or actuator Check wires, connector...
Page 51 - MACHINE TROUBLESHOOTING- CONTROLLER FAULT CODES; ERROR
MACHINE TROUBLESHOOTING- CONTROLLER FAULT CODES 86317500 CHARIOT SCRUBBER 11/15/08 4-26 ERROR CODE DELUXE PROBLEM SOLUTION LOW BATTERY VOLTAGE THE BATTERY NEEDS CHARGING OR THERE IS A BAD CONNECTION TO THE BATTERY TRACTION MOTOR DISCONNECTED THE TRACTION MOTOR HAS A BAD CONNECTION, CHECK CONNECTIONS...
Page 53 - PARTS
Page 54 - BUMPER
BUMPER 86317500 CHARIOT SCRUBBER 11/15/08 5-1 1 2 3 4 5 6 7 8 9 10 1 4
Page 56 - CONTROL PANEL
CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-3 2 3 4 6 7 8 10 12 13 14 15 16 17 18 19A 20 21 23 25 26 9 CONTROLLER SUPPLED WITH 11 27 22 5 HARNESS SUPPLED WITH 1 28 19B 30 29 10 24
Page 58 - CONTROL PANEL HOUSING
CONTROL PANEL HOUSING 86317500 CHARIOT SCRUBBER 11/15/08 5-5 5 10 9 8 2 3 3 6 1 11 4 7
Page 59 - REF
CONTROL PANEL HOUSING 86317500 CHARIOT SCRUBBER 11/15/08 5-6 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86005810 57245 4 NUT, 1/4-20 HEX NYLOCK SS 2 86290540 - 6 SCR, 10-32 X 1/2 TORX SS BLK NP 3 86277480 70850 6 SCR, 5/16-18 X1/2 PTHMS SS 4 86317890 - 1 BRKT, LEFT CONSOLE MOUNT 5...
Page 60 - DECAL
DECAL 86317500 CHARIOT SCRUBBER 11/15/08 5-7 1 2 3 5 4 6
Page 66 - PEDAL PLATFORM
PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-13 1 2 3 4 5 7 8 9 10 12 13 14 15 16 18 19 21 22 25 26 27 28 24 23 17 6 11 20 11 15 22
Page 71 - REAR COVER
REAR COVER 86317500 CHARIOT SCRUBBER 11/15/08 5-18 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276780 70728 3 SCR, 5/16-18 X 3/4 HHCS SS 2 86279130 87083 5 WASHER, 5/16 SPLIT LOCK PLTD 3 86010670 87029 5 WASHER, 5/16 FLAT SS 4 86031780 270082 1 COVER, REAR, DELUXE 5 86005860 5727...
Page 76 - SCRUB DECK – DISK
SCRUB DECK – DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-23 18 17 14 15 16 12 13 11 10 8 9 7 6 5 4 3 2 1 8 8 19 19 20 20 FROM PUMP
Page 78 - SCRUB DECK-CYLINDRICAL
SCRUB DECK-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-25
Page 80 - SCRUB DECK MOUNTING-CYLINDRICAL
SCRUB DECK MOUNTING-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-27 1 2 3 4 5 6 7 8 9
Page 83 - SCRUB DECK LIFT-DISK; REF PART
SCRUB DECK LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-30 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276920 70755 2 SCR, 3/8-16 X 1 HHCS SS NP 2 86008810 80697 2 BALL JOINT ASY, 3/8-24 RH 3 86273850 70022 2 SCR, 1/4-20 X 2 HHCS 4 86010780 87162 2 WASHER, 1/4 SPILT LOCK PLTD 5...
Page 85 - SCRUB DECK ACTUATOR-CYLINDRICAL
SCRUB DECK ACTUATOR-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-32 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86317340 - 3 SPACER, .498 X.313 X.500 2 86317330 - 3 PULLEY, 2 IN. 3 86316550 - 1 ACTUATOR, 36VDC, 4.5" STROKE 4 86315290 - 1 SPACER 5 86315260 - 1 BRKT ASSY, ACT...
Page 86 - SCRUB DECK SKIRTS-DISK
SCRUB DECK SKIRTS-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-33 7 7 20 19 18 22 17 16 15 14 13 9 10 11 12 5 21 5 8 6 5 4 3 2 1 24 23
Page 88 - SCRUB DECK AQUA-MIZERTM
SCRUB DECK AQUA-MIZER™ 86317500 CHARIOT SCRUBBER 11/15/08 5-35 2 8 7 6 3 4 9 9 10 12 3 1 16 15 14 13 17 18 11B 11A 5A5B
Page 92 - SOLUTION-CYLINDRICAL
SOLUTION-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-39 36 35 34 SOLENOID TO 7 23 5 22 24 5 28 21 25 6 28 1 18 5 20 5 16 15 14 3 17 2 TANK TO 10 5 8 33 19 11 12 30 32 29 26 31 27 4 9 13 37 38
Page 96 - SQUEEGEE-CYLINDRICAL
SQUEEGEE-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-43
Page 100 - SQUEEGEE LIFT-CYLINDRICAL
SQUEEGEE LIFT-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-47
Page 102 - SQUEEGEE SWING
SQUEEGEE SWING 86317500 CHARIOT SCRUBBER 11/15/08 5-49 1 24 23 22 21 20 3 6 19 18 16 15 14 13 17 11 6 9 10 8 6 7 7 6 5 4 25 2 1 6 12
Page 104 - STEERING
STEERING 86317500 CHARIOT SCRUBBER 11/15/08 5-51 28 14 22 20 19 19 15 24 13 11 9 6 1 4 5 3 2 27 26 25 16 30 23 21 18 12 10 8 17 29 7
Page 106 - TANK
Page 108 - VACUUM
VACUUM 86317500 CHARIOT SCRUBBER 11/15/08 5-55 1 2 3 4 5 6 7 8 9 7 11 10
Page 109 - QTY
VACUUM 86317500 CHARIOT SCRUBBER 11/15/08 5-56 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86314790 - 3 ISOLATOR, RUBBER, 1/4-20 UNC M 2 86314780 - 1 PLATE, VAC MOTOR 3 86012210 - 1 VAC MOTOR, 36VDC 2ST TD 4 86279630 87212 1 WASHER, .344IDX1.130ODX.09T PLT 5 86010630 87013 3 WASHER...
Page 118 - WIRING-CONTROL PANEL
WIRING-CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-65 65-WHT67-GRN 63-BRN 37-WHT 61-WHT 32-GRY 19-PUR 66-YEL 31-BLK 38-YEL 62-WHT K2 K1 72-BRN 73-BLU 64-BLU 7 C 1 PIN 6 K1-PIN 6 K2PIN 8 K1-PIN 4 K2PIN 9 K1-PIN 1 K2PIN 4 K1-PIN 8 K2PIN 10 K1-PIN 10 K2PIN 12 K1-PIN 12 K2PIN 13 K1-PIN 13 K2PIN 1...
Page 128 - DIAGRAM A
WIRING-MAIN HARNESS 86317500 CHARIOT SCRUBBER 11/15/08 5-75 1 DIAGRAM B DIAGRAM C DIAGRAM D BRUSH RIGHT MOTOR MOTOR BRUSH LEFT SQUEEGEE LIFT ACTUATOR VAC MOTOR ACTUATOR SCRUB LIFT SOLENOID VALVE DRIVE MOTOR PUMP BRAKE A B C HORN 13 ORG 14 BLK 19 WHT 20 BLK 6 BRN 6 BRN 15 Y L W 16 B L K 11 RED 10 BLK...
Page 131 - WIRING-PEDAL PLATFORM; DESCRIPTION
WIRING-PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-78 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86315100 - 1 HARNESS, PEDAL
Page 133 - HOSE DIAGRAM-CYLINDRICAL
HOSE DIAGRAM-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-80 63 90 8920 QUICK DISCONNECT SOLENOID VALVE 863 15 5 10 TANK SHUT-OFF PRV 39 541 86 281 950 (32) PR V 3 9734 862 823 60 (28") VALVE D RAI N HOSE STRAINER (FINE) STARINER (COARSE) 86 281 940 (40") P RV 39540 P UMP
Page 134 - SUGGESTED SPARE PARTS
SUGGESTED SPARE PARTS 86317500 CHARIOT SCRUBBER 11/15/08 5-81 PART NO. PRV NO. DESCRIPTION SERIAL NO. FROM NOTES 86316160 - BREAKER, 18A, 250VAC, 32VDC 86008900 80845 BOOT, 7/16 CIRCUIT BREAKER 86004440 39717 CAP DRAIN HOSE 86199840 090-12A FLOAT, SHUT OFF 86317770 - GASKET, DOME EDGE 86305960 - HOS...
Page 135 - OPTIONS
Page 136 - BATTERY CART - OPTION
BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-1 3 3 15 16 3 3 8 3 3 3 3 3 5 5 5 9 24 8 6 30 29 28 27 26 25 2 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
Page 143 - WARNING LIGHTS - OPTION
WARNING LIGHTS - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-8 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86270990 57090 4 NUT, 10-32 HEX NYLOCK SS 2 86010650 87018 4 WASHER, #10 X 6/16 OD 3 86276820 70740 4 SCR, 10-32 X 1/2 PTHMS BLK 4 86071490 140871 1 BRKT, UPPER WARNING LIGHT ...
Page 144 - SERIAL NUMBERS
SERIAL NUMBERS 86317500 CHARIOT SCRUBBER 11/15/08 6-9 REF. NO. MODEL: SERIAL # 1 N/A
