White Rodgers ACM1600 - Manual

Page 2 - INTRODUCTION; WARNING; CAUTION; Tin Snip

2 INTRODUCTION The White-Rodgers Air Cleaner Compartment comes com-plete with a 5 ” media furnace air filter. This filter must be changed every three months to maintain efficiency of the filterand furnace system. For maximum efficiency, the compart-ment can be upgraded to a White-Rodgers Electronic ...

Page 3 - HOW THE AIR FILTER WORKS; Air Filter Compartment- mounts to existing duct work and; CONSTRUCTION OF THE AIR FILTER COMPARTMENT; Figure 1

3 AIR FILTER COMPARTMENT 5" FILTER DOOR DIRTY AIR IN 5" FILTER FILTERED AIR OUT HOW THE AIR FILTER WORKS Dirty air flows through your return air ducts and enters thecompartment where particles (hair, lint, etc.) are removedby the filter. See figure 1. Filtered air re-enters to the supply duc...

Page 4 - Figure 4; LOCATING THE AIR FILTER; Select a location that meets the following:; PREINSTALLATION

4 D C B E A 6 7/8 AIR FLOW NOT TO EXCEED 20 FURNACE OPENING FURNACE AIR CLEANER DUCTWORK AIR FLOW THIS CABINET CAN ACCEPTELECTRONIC AIR CLEANER OPTION (SEE PAGE 7) AIR CLEANEROPENING TRANSITION SECTION (IF NEEDED) Figure 3 Figure 4 LOCATING THE AIR FILTER Your air filter must be mounted in the retur...

Page 5 - Typical use of duct offset to match air filter opening.; TYPICAL MOUNTING POSITIONS

5 AIR FLOW AIR FL OW Figure 10 LESS THAN7 INCHES FIGURE 9 OFFSET AT LEAST9 INCHES AIR FLOW Figure 7 AIR FLOW Figure 6 AIR FLOW Figure 5 HIGHBOY FURNACE(Figure 8) Installation beneath furnace.Filter mounts horizontally,where return air enters frombelow. Raise furnace and in-stall beneath base. COUNTE...

Page 6 - filter. Set in a safe location until the; Transition Fittings; INSTALLATION; With the air filter compartment installed, re-install 5

6 REMOVE OLD FILTER AND DISCARD (Figure 11) NOTE: This filter may be mounted in the furnace compart-ment. CLEAN BLOWER COMPARTMENT NOTE: The air filter cannot remove dirt from blower andducts. INSTALLATION The following is a typical installation of the air filter on a“Highboy” furnace (Figure 7). 1....

Page 7 - MAINTENANCE; Remove 5; PARTS LIST FOR; REPAIR and UPGRADE PARTS; Wood Block; Description; ELECTRONIC AIR CLEANER KIT

7 1 1 3 2 CONDUIT FLOOR DUCT AIR CLEANER MAINTENANCE For maximum efficiency, your air filter should be in-spected once a month and changed if dirt loading isheavy. When changing is required, the following proce-dure should be used: ▲ ! CAUTION The fiber filter used in this compartment for aircleanin...

Page 8 - NOTICE TO CONSUMERS; Electronic Air Cleaner

NOTICE TO CONSUMERS White-Rodgers Electronic Air Cleaner Dear Consumer; White-Rodgers would like to thank you for purchasing a White-Rodgers Electronic AirCleaner or product containing a White-Rodgers Electronic Air Cleaner. Although White-Rodgers does not extend a warranty directly to consumers, Wh...

White Rodgers ACM1600 - Manual

Table of Contents:

Summary

Other White Rodgers Models