Weber Grill - Manual

7 General Instructions Your Weber Performer Grill is a portable outdoorcooking appliance. You can grill, barbecue, roast andbake with results that are difficult to duplicate withindoor kitchen appliances. The Performer Grill is portable so you can easily changeits location in your yard or on your pa...

8 Tools needed Phillips screwdriver 7/16 inch or adjustable wrench Pliers Packages Your Weber Performer Grill comes in a large box(shipper) which includes a top box, and bottom carton. There is a hardware pack of small parts and hardwarethat will be found in the bottom carton. Note - The hardware si...

10 The following items will be found in the hardwarepack. Sixteen nylon washers(actual size) Four aluminum washers(actual size) Eight 1/4-20 x 1 3/4 inch bolts(actual size) Four 1/4-20 acorn nuts(actual size) Four 1/4-20 x 1/2 inch bolts(actual size) Two #8-18 x 5/8 Phillips head screws(actual size)...

11 Step 2 Remove protective packaging Protective cardboard inserts must be removed from thebowl before assembly. Figure 2. DO NOTFORCEFULLY REMOVE THE INSERTS. a) Remove cardboard insert from ash catcher ring. Be careful when removing the cardboard not to bendthe ash catcher ring. b) Tear cardboard ...

12 Figure 4 Step 4 Continue frame assembly You will need: frame assembly, front panel, four 1/2inch bolts, four nylon washers, 7/16 inch wrench. Place front panel along inside edge of frame assemblywith Weber logo on the side closest to the wheelframe and facing out. Slip washers on bolts, insertbol...

13 Figure 6 Step 6 Install CharBin lid handle You will need: CharBin lid handle, two 5/8 inch screwsand a Phillips screwdriver. Remove twist tie and protective plastic coveringfrom CharBin lid. Lift open lid. Insert screws throughholes from inside of lid into handle. Tighten screws.Figure 6. Figure ...

16 OPERATING INSTRUCTIONS Lighting WARNING: Open lid lid before lighting. Ash catchermust be in place when lighting and any time duringuse. If using a liquid fire starter, check the ashcatcher for any accumulation of starter fluid beforelighting charcoal. If fluid is present DO NOT LIGHT.Wipe out an...

17 Cooking Methods Direct Method For foods requiring fewer than 30 minutes of cookingtime, cook directly over the coals, absorbing the fullheat. 1. Place filled Char-Baskets with flat sides together in center of charcoal grate. 2. Ignite charcoal. 3. Coals are ready when they have a light coating of...

19 1. #8-18 x 5/8 inch screw (3) 2. Nylon lid handle (top) 3. Nylon lid handle (bottom) 4. Thermometer 5. Nylon damper handle 6. Lid assembly 7. 22 inch hinged cooking grate 8. Char-Basket Fuel Holders (2)9. Charcoal grate 10. Hex drive 11. Damper blades 12. Lid holder support strap 13. Lid holder l...

A F INAL W ORD OF T HANKS hank you for choosing a Weber Barbecue. Our family here at Weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared ...