Weber Gas Grill - Manual

B-1 Assembly Instructions (1) (2) Assemble frameYou will need: left frame, right frame, two 1/2 inchbolts, two nylon washers and a 7/16 inch or adjustablewrench.Note - Work on carpeted area (on grass or one of theboxes) to protect the finish during frame assembly.Lay the leg frame pieces as shown so...

C-1 Installing Features Install the right trim piece with tool holdersYou will need: Right trim piece with tool holdersPush the Right trim piece into the frame as shown(1),making sure that the tabs on the underside of the trimpiece are snapped into the slots in the frame.(2) Install the left end tri...

D-1 1) Open the lid.2) Make sure all burner control knobs are turned OFF. (Push control knob down and turn clockwiseto ensure that it is in the OFF position.) WARNING: The burner control knobs must be in the OFF position before turning on the liquidpropane cylinder tank valve. If they are not in the...

D-4 Refilling the LiquidPropane Cylinder We recommend that you refill the LP cylinder before itis completely empty. Removal of the LP cylinder 1) Close cylinder valve (turn clockwise).2) Unscrew regulator coupling by turning counterclockwise, by hand only. 3) Loosen cylinder lock wing nut and turn c...

D-6 Safe handling tips forLiquid Propane GasCylinders ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas atregular temperatures and pressures. Under moderatepressure, inside a cylinder, LP gas is a liquid. As thepressure is released, the liquid readily ...

D-7 Annual Maintenance After a period of nonuse, we recommend that youperform the following maintenance procedures for yoursafety. WARNING: Check the hose before each use of the barbecue for nicks, cracking, abrasions orcuts. If the hose is found to be damaged in anyway, do not use the barbecue. Rep...

D-8 General Maintenance Weber Spider Stopper™ Guards Your Weber Gas Barbecue, as well as any outdoor gasappliance, is a target for spiders and other insects.They can nest in the venturi section (Venturi(1), airshutter(2), venturi fin(3) ) of the burner tubes. Thisblocks the normal gas flow, and can ...

D-9 (2) (1) Replacing Main Burners 1) Your Weber Gas Barbecue must be OFF and cool.2) Turn gas OFF at source.3) To remove control panel: take off the burner control knobs. Remove the screws holding thecontrol panel in place. Lift off the control panel. 4) Unlatch the Spider Stopper™ Guards and remov...

D-10 Crossover® Ignition System Operations If the Crossover Ignition System fails to ignite the Leftburner, light the Left burner with a match. If the Leftburner lights with a match, then check the CrossoverIgnition System. ■ Check that both the white(1) and black(2) ignition wires are attached prop...

Troubleshooting Problem Check Cure Burners burn with a yellow ororange flame, in conjunction withthe smell of gas. Inspect Weber Spider StopperGuards for possible instructions.(Blockage of holes.) Clean Weber Spider StopperGuards. (See Section “AnnualMaintenance”) Burners do not light. -or- Burnersh...