Vermont Casting VL21LP - Manual
Vermont Casting VL21LP – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – gen) from the room in which it is installed. Provisions; General Information
- Page 3 – Installation Requirements; Pressure Test Points; Proposition 65 Warning:; Fireplace; Minimum fireplace dimensions.; High Elevations
- Page 6 – Ventilaton options for confined spaces.; Confined Space
- Page 7 – Installation Instructions; Fireplace Top View
- Page 8 – Some of the early units may not have the holes; Locate damper locking bracket.
- Page 9 – DO NOT TEST FOR LEAKS WITH AN OPEN FLAME.; Without Hood
- Page 10 – Clearances; WITHOUT HOOD; Positioning the Logs
- Page 12 – FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Euro SIT; Lighting instructions
- Page 14 – Typical flame patterns.; Gas Valve Knob; Typical view of pilot burner flame.; LO; Correct SIT valve pilot flame.
- Page 15 – Troubleshooting
- Page 16 – replacement parts
- Page 18 – Accessories; Accessory; Hood
- Page 19 – (exclusive of CFM Corporation supplied; B. Cement or ceramic fiber log components:; LIMITED 2/20 YEAR WARRANTY; For Majestic Fireplaces Decorative Gas Appliances
- Page 20 – CFM Corporation
Installation and Operation Instructions for
Vent-Free Gas Log Sets*
Models: VL18, VL21 and VL24 (Natural Gas)
VL18LP, VL21LP and VL24LP (Propane)
C E R T I F I E D
DESIGN
C ERTIFIE D
20002538 1/07 Rev. 8
*These logsets are not for exterior use.
W A R N I N G
If the information in this manual is not followed exactly, a fire or explosion may result, causing property
damage, injury, or loss of life.
W A R N I N G
CARBON MONOXIDE POISONING MAY LEAD TO DEATH
When used without fresh air, vent-free log sets may give off carbon monoxide, an odorless, poisonous gas.
Some people - pregnant women, people with heart or lung disease, anemia, or persons under the influence of alcohol, and
persons at high altitudes are more affected by carbon monoxide than others.
Early signs of carbon monoxide poisoning resemble the flu - headache, dizziness, and/or nausea. If you have these signs, the
heater may not be installed or working properly.
GET FRESH AIR AT ONCE!
Have the heater serviced before using it again.
ATTENTION
Installation and service must be performed by
a qualified agency, individual, firm, corpora-
tion, or company, experienced in the installa-
tion, repair, and servicing of this type of gas
appliance. Do not modify, alter or tamper with
any part of this heater, control, or logs.
—
Do not store or use gasoline or other flamma-
ble vapors and liquids in the vicinity of this or
any other appliance.
—
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not
use any phone in your building.
•
Immediately call your gas supplier from a
neighbor’s phone. Follow the gas suppli-
er’s instructions.
•
If you cannot reach your gas supplier, call
the fire department.
This appliance may be installed in an after-
market, permanently located, manufactured
(mobile) home, where not prohibited by local
codes.
This appliance is only for use with the type
of gas indicated on the rating plate. This ap-
pliance is not convertible for use with other
gases.
INSTALLER PLEASE NOTE:
DO NOT begin installation of this gas logset
until all instructions have been read and
understood.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Tested and listed to
ANSI Z21.11.2b-2004, Unvented Heaters, and
Z21.60b-2004; CGA 2.26b-2004
Decorative Gas Appliances for
Installation inSolid-Fuel Burning Fireplaces.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 20002538 The Logsets have been designed and tested to operate safely when installed according to the installation instructions con-tained in this manual. Read all instructions before starting the installation. In the Commonwealth of Massachusetts, all gas fitting and installation of this heater sha...
3 20002538 Installation Requirements The fireplace must meet the minimum dimensions listed below. (Fig. 1) Do not install the logset if the fireplace does not meet these minimums. Pressure Test Points Copreci Valve: 1/8” N.P.T. plugged tapping is provided on the outlet side of the gas control for a te...
6 20002538 W A R N I N G This heater shall not be installed in a confined space or unusually tight construction unless provisions are made for adequate combustion and ventilation air. W A R N I N G If the area in which the heater may be operated is smaller than that defined as an unconfined space, or i...
