Vermont Casting DVT38S2IN - Manual

Vermont Casting DVT38S2IN

Vermont Casting DVT38S2IN – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
Page: / 48

Table of Contents:

  • Page 2 – ChateauTM Direct Vent Gas Fireplace; Table of Contents; Installation & Operating Instructions; Replacement Parts
  • Page 3 – In the Commonwealth of Massachusetts:; Proposition 65 Warning:; PLEASE REVIEW THE FOLLOWING CAREFULLY; “OFF”; Certified To; Vented Gas Fireplace; We recommend that you install the Battery
  • Page 4 – Locating Your Fireplace; Locate gas fireplace.; Fireplace Dimensions; Fireplace specifications and framing dimensions for DVT38S2.; Finished Wall 24; Standard Framing; Noncombustible insula-
  • Page 5 – Clearance to Combustibles; Combustible mantel minimum installation.; Mantel Chart; Combustible mantel leg minimum installation.
  • Page 6 – Cold climate installation recommendation:; Hearth; DVT38s2nailing flanges; Final Finishing
  • Page 7 – Gas Inlet and Manifold Pressures; Minimum Inlet Pressure; High Elevations; Typical gas supply installation.; Always; when using black iron pipe so the gas; Electrical Junction Box
  • Page 8 – Control System; Disconnect gas supply fitting and remove 13 screws; Connect gas supply to valve.
  • Page 9 – DVT38S2 wiring diagram.; Special Feature for Cold Climates
  • Page 10 – Remote Control Transmitter; Introduction; Transmitter; MODE; Key Settings
  • Page 11 – Manual Function
  • Page 12 – To Change the Set Temperature; already
  • Page 13 – Thermostatic Updating Feature
  • Page 14 – General Venting; Location of Vent Termination
  • Page 15 – General Venting Information - Termination Location; Canadian Installations
  • Page 16 – Termination Clearances; of Caps; Termination clearances.; General Information Assembling Vent Pipes; Canadian Installations:; The joints of the inner pipe (flue pipe) must be
  • Page 17 – Horizontal Termination; Horizontal vent termination window.; Sidewall Applications
  • Page 18 – Apply high temperature sealant or UL approved; Minimum vertical run / maximum horizontal run.; Noncombustible Walls:; Hole opening must be 11; Sidewall Installation
  • Page 19 – Vent Opening; Vent Opening for Noncombustible Wall; Locate vent opening on wall.; Adjustable zero clearance sleeve.; If using the; Vertical height requirement.
  • Page 20 – Horizontal length requirement.; Sidewall Installation with; mm) hole through the exterior wall and frame as shown.
  • Page 21 – thru wall trim; joints as described on Page 16.; Installation Procedure; If the fireplace is installed flush with the wall, a high; Installing the 38S2VDK Door; install brackets
  • Page 22 – Applications; Vista door top hole locations.; Flue Restrictor Plate Guide; Typical Applications; restrictor plate; Restrictor plate location.; Restrictor Plate Installation
  • Page 23 – Flue restrictor plate use in straight up installation.; Turn the burner housing upside down. Remove; Turn shutter plate over to cover opening.; ” flue restrictor; Restrictor plate use with horizontal offset.
  • Page 24 – Support straps for horizontal runs.; Typical offset application.
  • Page 25 – Attic Installation; Installing firestop spacer.; Elbow Strap; Attach straps to a structural framing member.
  • Page 26 – Chimney Components; Model Number
  • Page 27 – Tilt the glass frame at the top away from the unit.; Operating Instructions; Glass Information; Remove Phillips screws, tilt frame forward and lift off; refractory; Ceramic refractory panels.; nuts holding each fettle to the burner assembly.
  • Page 28 – Log, Lava Rock and Ember Placement; DVT38Sw log identification.
  • Page 29 – fettle to the burner are secure.; Place the volcanic rock in front of
  • Page 30 – NOTE; : Position this log through the
  • Page 32 – Flame Characteristics
  • Page 33 – Trim Installation; The right and left trim pieces have a 45° notch on the; Trim frame in place.
  • Page 34 – Lighting & Operating Instructions
  • Page 35 – Troubleshooting; American Flame Gas Control System; Verify the gas supply is turned on.; A proper ground is essential to spark igniter; Pilot will not light/stay lit
  • Page 36 – Troubleshooting American Flame Gas Control System; Main flame will not light
  • Page 37 – American Flame Gas Control System Error Codes; Description of Fault:
  • Page 38 – Fuel Conversion Instructions; Allow unit to cool if it has been operating.; Conversion Procedure; Carefully remove brick panels.; Use 3/8” socket to remove hex nuts holding burner; Slide the burner housing assembly to the left and; Replace Pilot Orifice; It; Valve Conversion
  • Page 39 – AF pilot orifice; Remove pilot orifice.; Remove black plastic cap and adjust rotary knob to
  • Page 40 – Table 1 DVT38S2 Injector Orifice Size Matrix; Conversion to LP; Table 2 Valve Minimum Rate Screw
  • Page 41 – Maintenance; Burner and Burner Compartment; Cleaning the Control System; If repair is necessary, it should
  • Page 44 – Fuel Conversion Kits
  • Page 45 – Accessories
  • Page 47 – PLATED PARTS AND ACCESSORIES:; LIMITED LIFETIME WARRANTY
  • Page 48 – Efficiency Ratings; Model; CFM Corporation
Loading the manual

Installation Instructions and

Homeowner’s Manual

WARNING!

IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION
MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL
INJURY OR LOSS OF LIFE.

FOR YOUR SAFETY

DO NOT STORE OR USE
GASOLINE OR OTHER
FLAMMABLE VAPORS AND
LIQUIDS IN THE VICINITY OF
THIS OR ANY OTHER
APPLIANCE.

PLEASE READ THIS MANUAL
BEFORE INSTALLING AND
USING APPLIANCE

Installation and service must
be performed by a qualified
installer, service agency or
the gas supplier.

WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.
• Do not touch any electric switch;
• Do not use any phone in your

building.

• Immediately call your gas supplier

from your neighbor’s phone. Follow
the gas suppliers instructions.

• If you cannot reach your gas

supplier call the fire department.

INSTALLER/CONSUMER

SAFETY INFORMATION

Chateau

™

Direct Vent Gas
Fireplace

Model: DVT38S2IN

� � � � � � � � �

�������

����������

20011957 9/07 Rev. 1

INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.

�����
�������������
����

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - ChateauTM Direct Vent Gas Fireplace; Table of Contents; Installation & Operating Instructions; Replacement Parts

2 Chateau™ Direct Vent Gas Fireplace 20011957 Please read the installation & operating instructions before using this appliance. Thank you and congratulations on your purchase of a CFM Corporation fireplace. IMPORTANT: Read all instructions and warnings carefully before starting installation. Fai...

Page 3 - In the Commonwealth of Massachusetts:; Proposition 65 Warning:; PLEASE REVIEW THE FOLLOWING CAREFULLY; “OFF”; Certified To; Vented Gas Fireplace; We recommend that you install the Battery

3 Chateau™ Direct Vent Gas Fireplace 20011957 This gas fireplace should be installed by a qualified installer, preferably NFI or WETT (Canada) certified, in accordance with local building codes and with current CSA-B149.1 Installation codes for Gas Burning Appliances and Equipment. For USA Installation...

Page 4 - Locating Your Fireplace; Locate gas fireplace.; Fireplace Dimensions; Fireplace specifications and framing dimensions for DVT38S2.; Finished Wall 24; Standard Framing; Noncombustible insula-

4 Chateau™ Direct Vent Gas Fireplace 20011957 Y D A B C E Y X LU584 Locating unit DVT38S2 3/17/04 djt Locating Your Fireplace LU584-1 Fig. 2 Locate gas fireplace. A) Flat on wall B) **Island C) *Room divider D) *Flat on wall corner E) Chase installation Y) 6” minimum Note (Fig. 2): ** Island (B) and ...

Other Vermont Casting Models

All Vermont Casting Other