Vermont Casting 36CDVTRN - Manual

Table of Contents:

• Page 2 – CDV Series Direct Vent Gas Fireplace; PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS; Table of Contents; Logs
• Page 3 – OFF; PLEASE REVIEW THE FOLLOWING CAREFULLY; Locating Your Fireplace; Installation & Operating Instructions; Proposition 65 Warning:
• Page 4 – Fireplace Dimensions - Rear Vent; Fireplace specifications and framing dimensions.; Framing Dimensions
• Page 5 – Fireplace Dimensions - Top Vent
• Page 6 – Hearth; Mantel; Combustible mantel leg minimum installation.; Mantel Chart; Mantel Shelf or; Combustible mantel minimum installation.
• Page 7 – DO NOT; Final Finishing; Vented Gas Fireplace Heaters; Framing and Finishing; must; Gas Specifications; flange location; Flange Location for Desired; standoff location; Standoff Location for Desired Drywall Depth at Header; Hood Installation; CAUTION: Hood MUST be permanently installed.
• Page 8 – Installation; INSTA VENT FREE; Typical gas supply installation.; Remote switch; Remote switch wiring diagram.; 20V Electrical Hook Up
• Page 9 – electric cover plate and secure.; Electric receptacle.; General Venting; There must not be any obstruction
• Page 10 – General Venting Information - Termination Location; Canadian Installations
• Page 11 – Termination Clearances; Canadian Installations:; Flex Vent Pipes; Termination clearances.; Apply high temperature sealant to 4” and 7” pipes.
• Page 12 – How to Use the Vent Graph; Horizontal dimension from the outside face of the; ertical dimension from the fl; DV Graphic; Rear Wall Venting Applications; Twist Lock Pipes; 6CDVR Venting
• Page 13 – Top View; Rear vent applications.; Rear Wall Installation; Combustible Walls; Cut a 9; Noncombustible Walls; Hole opening must; Vent Opening; Vent Opening for Combustible Wall; Locate vent opening on wall.; Install interior firestop as shown in Figure 14.; Side View Vent Termination; Slide fireplace into position.
• Page 14 – Rear Wall Vent Installations -; Locate the center of the hole 29; Grasp the vent pipe close to the collar and bend to
• Page 15 – Secure collar in place, slide termination into collar.; Rear Wall Vent Application; Locate the hole 27; The centerline of the termination must be 27; Vertical Sidewall Applications
• Page 16 – Maximum vent run with elbows.; Maximum number of elbows.; Vertical Sidewall Installation; Opening for Noncombustible Wall; Maximum horizontal vent run.; •IMPORTANT•; Minimum clearance between vent
• Page 17 – Measure horizontal length including 2” overlap.; Always start vertical run with 7TCDV90 on 36CDVR; Apply high temperature sealant.
• Page 18 – Below Grade Installations; Ensure sidewall venting clearances are observed.; Snorkel; Snorkel installation, recessed foundation.; Below grade installation; Below grade installation.; Up to two 45° elbows may be used within the
• Page 19 – Typical vertical; Typical vertical roof applications.; above and mark position.
• Page 20 – Minimum termination to roof clearance.; 6CDVT Vertical Venting
• Page 21 – Support straps for horizontal runs.; According to the chart the maximum
• Page 22 – Maximum number of elbow degrees.; Noncombustible Walls:; Vertical Sidewall Installations; cal height (X) required from the base of the flue collars; Vertical height requirement.
• Page 23 – Apply high temperature sealant to collars or termina-; pipe coming through the wall.
• Page 24 – Top Vent; This Gas Fireplace has been approved for:; through the roof
• Page 25 – Typical offset application.; Typical ceiling/roof support; Typical Roof Support; Roof and ceiling supports.
• Page 27 – Vent Components; Venting Components; Elbow; Vent components; Must order a 7TCDV90 elbow
• Page 28 – the window frame assembly by pulling down on the; Operating Instructions; Glass Information; Louvre removal; Remove top louvre; remove glass frame; Window frame assembly removal.
• Page 29 – Flame adjustment knob for SIT valve.; bottom; Log Front; 6CDV burner flame appearance.
• Page 30 – FOR YOUR SAFETY READ BEFORE LIGHTING; Follow the gas supplier’s instructions.; To Turn Off Gas to Fireplace; Lighting and Operating Instructions; Lighting Instructions; Euro SIT
• Page 31 – For Fireplaces equipped with SIT822 Gas Valve (EN or EP)
• Page 32 – SYMPTOM; NOTE; SIT NOVA 820 MILLIVOLT VALVE
• Page 33 – SIT top Convertible Pilot; Fuel Conversion Instructions; Nova SIT820 Gas Valve.
• Page 34 – Burner and Burner Compartment; Cleaning the Standing; If repair is necessary, it should; Maintenance
• Page 35 – CDV; b. Log Middle Assy
• Page 36 – Clamp Frame Window; Fuel Conversion Kits
• Page 37 – Specifications; Optional Accessories Available; Fan Kits; fan install; FK12 fan placement.; Wiring Instructions; Model
• Page 39 – IF WARRANTY SERVICE IS NEEDED...; ) Contact your supplier. Make sure you have your warranty,; LIMITED LIFETIME WARRANTY; PRODUCT COVERED BY THIS WARRANTY
• Page 40 – CFM Corporation; Efficiency Ratings