Vermont Casting 3030 - Manual
Vermont Casting 3030 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Vermont Castings UVS27 Vent-Free Gas Heater; Installation and Operating Instructions; Table Of Contents
- Page 3 – Installation & Operating Instructions; F temperature rating.
- Page 4 – Shell Dimensions; Fig. 1 UVS27 freestanding shell dimensions.; Freestanding Stove; Fig. 2 UVS27 Hearthmount specifications.; Hearthmount
- Page 5 – Hearth Requirements; Clearance Requirements; Minimum Clearances to; Mantel
- Page 6 – Gas Specifications; Input; Unvented Heaters
- Page 7 – Unusually Tight Construction is; You must determine that these fresh
- Page 8 – * Do not include Direct Vent appliances as these; W A R N I N G; A) Open up or provide at least two ventilating grilles; Fig. 8 Vent options to provide additional air.
- Page 9 – Assembly Procedures; WARNING; Fig. 5 Secure left side to the back panel.; Shell / Firebox Assembly; Attach the Back Panel to the Left Side Plate by; Unpack the Firebox
- Page 10 – Install Optional Fan Kit; Fig. Secure right side to the back panel.
- Page 11 – Fig. 12 Attach snapstat to inner shroud.; Fig. 11 Correct position of fan skirt installation.; Install ON/OFF Switch; Run wires down back of stove, under bottom of rear; Fig. 16 Attach switch wires to valve; Fig. 15 Attach switch assembly to rear shroud.; Fig. 10 Place upper flange behind lower edge of shroud.
- Page 12 – Glass & Catalyst Installation; Thermostat Wire / Gauge; Hold the burner at the right hand side and lift to clear; Optional Thermostat/Remote Wiring
- Page 13 – Fig. 20 Be sure injector orifices remain at 90; Connect the Gas Supply Line; NEVER test with an open flame.
- Page 14 – Install Log Set; Remove the logs from their packaging, and inspect; CAUTION; Install the left log by placing it on the sheet metal
- Page 15 – Complete the Installation; Install the screen frame by sliding the hooks over the; Tilt the top plate to engage its rear rib in front of the; Fig. 27 Install the Top Plate and Grille.
- Page 16 – Operation; Your First Fire; Flame & Temperature Adjustment; LO; Flame Characteristics
- Page 17 – FOR YOUR SAFETY READ BEFORE LIGHTING; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Euro SIT
- Page 18 – Troubleshooting
- Page 19 – Troubleshooting cont’d.; CONDITION
- Page 20 – pletely before cleaning.; Maintenance; Porcelain enamel surfaces should be cleaned with; Fig. 34 Remove the screen or glass panel.
- Page 21 – Use the phillips screwdriver to remove the two sheet; Clean the Combustor Module; Clean the outer surface of the filter with the brush; Replace The Combustor Module; Set combustor on top of flat surface of firebox.; Fig. 36 Remove the catalytic combustor module.
- Page 22 – UVS27R, UVS27M Vent Free Gas Heaters; Description; Gas Log Assembly - UVS27
- Page 25 – Optional Accessories Available; Fan Kits
- Page 26 – IF WARRANTY SERVICE IS NEEDED...; ) Contact your supplier. Make sure you have; LIMITED LIFETIME WARRANTY
Tested and listed to
ANSI Z21.11.2a-2001, Unvented Heaters
This is an unvented gas-fired heater.
It uses air (Oxygen) from the room
in which it is installed. Provisions for
adequate combustion and
ventilation air must be provided.
Refer to Page 7.
UVS27R, UVS27M
Vent Free Gas Heaters
Models 3030, 3031,
3032, 3033
20005004 10/04 Rev. 4
INSTALLER / CONSUMER
SAFETY INFORMATION
WARNING: If the information in this
manual is not followed exactly, a fire
or explosion may result causing
property damage, personal injury or
loss of life.
Please read this manual before
installing and using appliance.
Homeowner’s Installation
and Operating Manual
INSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FOR HOMEOWNER
DESIGN
C E R
T I F I E D
—
Do not store or use gasoline or
other flammable vapors and
liquids in the vicinity of this or
any other appliance.
—
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appli-
ance.
•
Do not touch any electrical
switch; do not use any phone
in your building.
•
Immediately call your gas
suppler from a neighbor’s
phone. Follow the gas
suppler’s instructions.
•
If you cannot reach your gas
supplier, call the fire depart-
ment.
Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
CFM Specialty Home Products
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 Vermont Castings UVS27 Vent-Free Gas Heater 20005004 Installation and Operating Instructions Shell Dimensions ............................................................................................................... 4Clearance Requirements .......................................................
3 Vermont Castings UVS27 Vent-Free Gas Heater 20005004 Installation & Operating Instructions In order to ensure safe and effective installation, this unitmust be installed only by a qualified agency, individual, firm,corporation or company that is experienced in the installa-tion, repair and ser...
4 Vermont Castings UVS27 Vent-Free Gas Heater 20005004 Shell Dimensions Drawing Not to Scale Fig. 1 UVS27 freestanding shell dimensions. CL CL 9" (229mm) 26 ³⁄₄ " (680mm) 25" (635mm) 3" (76mm) Valve Inlet 14 ¹⁄₂ " (368mm) Valve Inlet 15 ⁵⁄₈ " (379mm) Freestanding Stove 5004 C...
