Page 2 - Dutchwest; PLEASE NOTE; Table of Contents; Proposition 65 Warning:
2 Dutchwest 7001219 PLEASE NOTE Please read this entire manual berfore you install and use your new room heater. Failure to fol-low instructions may result in property damage, bodily injury or loss of life. Save these instruc-tions for future use. Patents: U.S. - D288357, 4502395, 4646712;Canada - 1...
Page 3 - Specifications; Average Area heated (ft
3 Dutchwest 7001219 Specifications Dutchwest, Model 2463 Range of heat output ................ 6,600 - 27,300 Btu’s/HrMaximum heat output .......................... 35,000 Btu’s/Hr 1 Average Area heated (ft 2 ) ........ 700 - 1400 2 (65-130 m 2 ) Maximum burn time .......................................
Page 4 - Installation; Failure to follow these installation instruc-; Chimney Types
4 Dutchwest 7001219 Installation SAFETY NOTICE: IF YOUR DUTCHWEST CON-VECTION HEATER IS NOT PROPERLY INSTALLED, OPERATED AND MAINTAINED, A HOUSE FIRE MAY RESULT. FOR SAFETY, FOLLOW ALL INSTALLA-TION, OPERATION AND MAINTENANCE DIREC-TIONS. CONTACT LOCAL BUILDING OFFICIALS ABOUT RESTRICTIONS AND INSTA...
Page 5 - BS4543 Factory-made insulated; chimney connector
5 Dutchwest 7001219 Prefabricated Chimneys A prefabricated metal chimney must be one tested and listed for use with solid-fuel burning appliances. The applicable standard is BS4543 Factory-made insulated chimneys, Part 1: 1990 Methods of test for factory chimneys with stainless steel flue linings for...
Page 6 - Double-Wall Connector; Securing the Connector
6 Dutchwest 7001219 Do not use galvanized chimney connector; it cannot withstand the high temperatures that can be reached by smoke and exhaust gases and it may release toxic fumes under high heat. Double-Wall Connector Information on assembling and installing double-wall connectors is provided by t...
Page 7 - Double-check connector clearance from the ceiling.
7 Dutchwest 7001219 Securing the Connector to a Masonry Chimney The Model 2463 may be connected to either a free-standing masonry chimney or a masonry fireplace chimney. Freestanding Installations If the chimney connector must pass through a combus-tible wall to reach the chimney, follow the recommen...
Page 8 - Fireplace Installations -; Do not vent your stove into a factory-built
8 Dutchwest 7001219 Fireplace Installations - Through the Fireplace The Model 2463 heater may be installed either without legs* as a fireplace insert, or with standard legs at-tached - depending on the safety regulations that apply to your situation, the height of the fireplace opening and your own pr...
Page 9 - Floor Protection; Freestanding Installations; Fireplace Installations; You may not install a heater on a combustible; The floor protector; Floor Protection for Fireplace
9 Dutchwest 7001219 Floor Protection Freestanding Installations A constructional hearth should be provided of solid, noncombustible material at least 125 mm thick (which may include the thickness of any solid, noncombustible floor under a hearth) and at least 33” (838 mm) deep by 40” (1016 mm) wide. ...
Page 10 - Fireplace Installation Clearances; Keep the Stove a Safe Distance; clearance; Safe Ways to Reduce Clearances
10 Dutchwest 7001219 Fireplace Installation Clearances A fireplace installation requires special clearance be-tween the: • Side of the stove and the right and left walls • Side of the stove and the decorative side trim on the fireplace face • Top of the stove and the mantel In addition, both Fireplace...
Page 11 - Clearance Chart Reference Diagrams; exit diagram; Unprotected Surfaces; Parallel Installations
11 Dutchwest 7001219 Clearance Chart Reference Diagrams Refer to the diagrams below when using the Stove and Chimney Connector Clearance Chart which follows. For ex-ample, the letter “A” gives the minimum side clearance for installations in which the stove is not equipped with a rear heat shield and...
Page 12 - Stove and Chimney Connector Clearance Charts; Chimney Connector Clearance
12 Dutchwest 7001219 Stove Installed Stove in Stove Installed Stove in Parallel to Wall Corner Paralle to Wall Corner Side Rear Corners Side Rear Corners No heat shields (A) 22” (B) 24” (C) 18” (D) 12” (E) 14” (F) 10” (559 mm) (610 mm) (457 mm) (305 mm) (356 mm) (254 mm) Rear exit, rear h.s. (G) 22”...
Page 13 - Dutchwest Convection Heaters equipped with rear heat shields; Chimney Connector; Heater Installed with
13 Dutchwest 7001219 Distance from Center of Flue Collar to Wall in Top-Exit Installations Dutchwest Convection Heaters equipped with rear heat shields NOTE: These are not clearance distances. These measurements indicate where the centerline of the flue collar will be for various installations. Measu...
Page 14 - Wall Heat Shield Dimensions; DutchWest Convection Heaters, Model 2463
14 Dutchwest 7001219 Wall Heat Shield Dimensions DutchWest Convection Heaters, Model 2463 ST428 rear wall protection 7/00 60” (1524mm) Top Exit Wall Shield Spaced 1” (25 mm) from Floor 48” (1219 mm) Rear Exit ST428 Fig. 16 Rear wall protection. ST429sidewall protection7/00 48” (1219 mm) 60” (1524 mm...
Page 15 - Unpack the Parts; Assembly; Attach the Legs and Heat Shield
15 Dutchwest 7001219 Your convection heater requires some assembly. Follow the directions carefully and refer to the parts diagram at the back of this manual. Unpack the Parts Remove all loose parts from the firebox and the ash pan. Check to make sure all the parts are included and intact. You should...
Page 16 - Heater Controls and Features; Primary Air; control lever; Underfire Air; control valve on the front; Operation
16 Dutchwest 7001219 Heater Controls and Features Air Controls The Dutchwest Convection Heater has two air controls that regulate the amount of air drawn into the stove. Generally, more air entering the stove allows the fire to burn hotter and faster, while less air decreases heat output while prolon...
Page 17 - Damper Function; Damper; OPEN; must; Load Doors; Side Loading Door; Successful Wood Burning
17 Dutchwest 7001219 Damper Function The Damper is operated by moving the handle on the upper left side of the stove. (Fig. 23) It has two positions: OPEN , to start the fire and load fuel, and CLOSED , for greatest efficiency and heat. When the damper is closed, exhaust gases pass through an insu-lat...
Page 18 - Use the Air Control Settings; The thermometer should be used only as a; How to Build and Maintain a Wood Fire
18 Dutchwest 7001219 Use the Air Control Settings that Work Best for You No single combination of control settings will fit every situation. Each installation will differ depending on the quality of the fuel, the amount of heat desired, and how long you wish the fire to burn. Control settings also dep...
Page 19 - Lighting the Fire; DO NOT OVERFIRE THIS HEATER.; Reloading and Reviving the Fire; Wear heavy stove gloves when removing ashes.
19 Dutchwest 7001219 Break-in Fires If your stove is new or has new cast iron replacement parts, “season” the new cast iron with a few break-in fires. Follow Steps 1-3 below. Then let the fire burn out. Do not close the damper. Maintain a small, but not smoky, fire by adjusting the primary air control....
Page 20 - Safe Ash Handling; Never use a vacuum cleaner to remove
20 Dutchwest 7001219 Safe Ash Handling Ash may contain hot coals and must be treated with extreme care. Ashes should be placed outdoors in a metal container with a tight-fitting lid. The closed con-tainer of ashes should be placed on a noncombustible floor or on the ground, well away from all combusti...
Page 21 - Never use liquid cleaning; If you wish to clean the glass; Maintenance
21 Dutchwest 7001219 Keep Your Stove Looking New and Working Its Best Care of the Cast Iron Surface An occasional dusting with a dry rag will keep the painted cast iron of your Dutchwest Convection Heater looking new. If the paint needs retouching, allow the stove to cool completely. Wire-brush area...
Page 22 - Repair Missing Cement in Seams; damper rod
22 Dutchwest 7001219 3. Apply a thin bead of stove cement in the newly- cleaned groove. 4. Lay the gasket into the groove. Wait until you are a couple inches from the end before you cut it. 5. Test the gasket by closing the door on a slip of paper as described above. Adjust the gasket in any areas w...
Page 23 - Cleaning the Chimney System
23 Dutchwest 7001219 Cleaning the Chimney System The chimney system is composed of the chimney and the pipe that connects the stove to the chimney. Inspect the chimney and chimney connector at least twice monthly, and clean if necessary. When you first begin using the stove, check daily for creosote ...
Page 24 - The Chimney Connector; • Disassemble the chimney connector and take it
24 Dutchwest 7001219 The Chimney Connector TWO WEEKS: • Inspect the chimney connector and chimney. Clean if necessary. TWO MONTHS:• Inspect the chimney and chimney connector. Pay particular attention to the horizontal runs of chim-ney connector, and the elbows. Clean the system if necessary. Yearly ...
Page 25 - Masonry Chimney; Draft Management
25 Dutchwest 7001219 Your stove is only one part of a system that includes the chimney, the operator, the fuel, and the home. The other parts of the system will affect how well the stove works. When there is a good match between all the parts, the sys-tem works well. Wood stove operation depends on ...
Page 27 - Dutchwest Convection Heater
27 Dutchwest 7001219 34 23 24 29 32 6 5 2 7 22 4 21 8 9 53 10 16 17 33 43 18 39 47 13 14 19 37 38 42 35 1 11 30 12 13 36 50 41 3 31 20 40 1219 Dutchwest 2463 parts 3/05 48 45 26 27 28 44 49 51 58 59 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, p...
Page 31 - Warranty; Limited 3 Year Warranty; Limited 1 Year Warranty; Please Record this Information
31 Dutchwest 7001219 Warranty Limited 3 Year Warranty CFM Specialty Home Products warrants that this woodburning stove will be free of defects in material and workmanship for a period of three years from the date you receive it, except that the catalyst, thermostat assembly, handles, glass door pane...
Page 32 - CFM Specialty Home Products
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com CFM Specialty Home Products
