Page 2 - IMPORTANT; Warranty Registration; Figure 1; Introduction
2 CO29, CO75 Congratulations on your purchase of a U-Line refrigeration product. A pioneer in the field for more than 40 years, U-Line Corporation is the world’s number one manufacturer of built-in, under-counter, specialty refrigeration and ice making products. U-Line dedicates 100% of its research...
Page 3 - Table of Contents
CO29, CO75 3 Introduction ...............................................................................................................................2 Warranty Registration .......................................................................................................2Please Record Your ...
Page 4 - This page intentionally left blank
4 CO29, CO75 This page intentionally left blank ULIN_016357_30089.fm Page 4 Monday, March 27, 2006 10:25 AM
Page 5 - Safety Precautions
CO29, CO75 5 IMPORTANT IMPORTANT PLEASE READ all instructions completely before attempting to install, operate, or service your unit.• Proper installation procedures must be followed if this unit is being initially installed, or is moved to a new location after being in service. An INSTALLATION GUID...
Page 6 - Figure 2; Initial Startup; • U-Line recommends the unit be allowed to run; Product Features; OFF
6 CO29, CO75 Origins Ice Maker/RefrigeratorModels CO29, CO75 • Both Origins models feature a manual defrost ice maker with a daily production capacity of 18 lbs (8.2 kg) and storage for 13 lbs (5.9 kg). • Model CO29 provides 2.1 cu ft (59 L) of refrigeration capacity; Model CO75 provides a 4.2 cu ft...
Page 7 - Temperature Control; Checking Product Temperature; Figure 4; Adjusting Temperature; Figure 5; Ice Maker; Figure 6
CO29, CO75 7 Temperature Control Checking Product Temperature Figure 4 To check the actual product temperature, in refrigerator section only, insert an accurate thermometer into a plastic (non-breakable) bottle that is partially filled with water. Tighten the bottle cap securely (Figure 4) . Place t...
Page 8 - • If the ambient temperature is expected to drop
8 CO29, CO75 The ice bucket can be removed for emptying and cleaning. To remove the ice bucket, raise the bin arm and remove the bucket from the ice compartment. Use the ice bucket for ice storage only. Normal Operating Sounds All models incorporate rigid foam insulated cabinets to provide high ther...
Page 9 - Product Disposal; DANGER; General Cleaning; Black or White Models:; Cleaning and Maintenance
CO29, CO75 9 Product Disposal If the unit is being removed from service for disposal, check and obey all Federal, State and/or Local regulations regarding the disposal and recycling of refrigeration appliances, and follow these steps completely: 1. Disconnect power to the unit and unplug the power c...
Page 10 - • Do not use any solvent-based or abrasive; Maintenance; Defrosting; WARNING; Figure 7
10 CO29, CO75 • Do not use any solvent-based or abrasive cleaners. These types of cleaners may transmit taste to the interior products and damage or discolor the interior. Maintenance Proper maintenance of your U-Line product will ensure efficiency, top performance and long life. The maintenance int...
Page 11 - Condenser Cleaning; Interval - Every Three Months; Figure 8
CO29, CO75 11 Condenser Cleaning Interval - Every Three Months To maintain operational efficiency, keep the front grille free of dust and lint, and clean the condenser every three months. Depending on environmental conditions, more or less frequent cleaning may be necessary. WARNING Disconnect elect...
Page 12 - Ice Maker Maintenance; Inlet Screen; CAUTION
12 CO29, CO75 Figure 13 6. Place the two hook-hinges (Figure 13, 1) located on the rear bottom side of the grille onto the front lip of the unit base. Tilt the grille up into position and align the grille mounting hole with the grille screw hole on the cabinet. 7. Insert the screw (Figure 11, 2) . D...
Page 13 - Leveling; DOES NOT; Door Alignment Check and Adjustment
CO29, CO75 13 IMPORTANT IMPORTANT Use only genuine U-Line replacement parts. U-Line ice maker parts are not the same as standard FSP Whirlpool parts. Using non U-Line parts can reduce ice rate, cause water to overflow from ice maker mold, damage the unit, and may void the warranty. Leveling It is im...
Page 14 - Door Reversal
14 CO29, CO75 Door Reversal CO29: Depending upon the location of the unit, it may be desirable to change the side on which the door is mounted. NOTE: On built-in installations, changing the door mounting to the left side may interfere with ice bucket removal. To reverse the door mounting, perform th...
Page 17 - Glass Shelf Removal/Installation
CO29, CO75 17 8. Relocate plastic spacer/bushing on bottom of door to the opposite side (Figure 35) . Clean out bushing hole in door bottom if necessary. Figure 36 9. Place door on lower hinge pin. Align flat edge of top hinge with outer edge of unit and fasten upper hinge to unit (four screws). Par...
Page 18 - Service
18 CO29, CO75 Before Calling for Service If your U-Line product appears to be malfunctioning, read through the OPERATION section of this guide to ensure that the function of all controls are clearly understood. If the malfunction persists, the TROUBLESHOOTING GUIDE in this guide will assist you in q...
Page 19 - Troubleshooting Guide; Troubleshooting - What to check when problems occur:
CO29, CO75 19 Troubleshooting Guide DANGER ELECTROCUTION HAZARDNever attempt to repair or perform maintenance on the unit until the main electrical power has been disconnected. Troubleshooting - What to check when problems occur: PROBLEM POSSIBLE CAUSE REMEDY Unit not cold enough Door gasket not sea...
Page 23 - U-Line Corporation Limited Warranty
CO29, CO75 23 U-Line Corporation Limited Warranty U-Line Corporation warrants each U-Line product to be free from defects in materials and workmanship for a period of one year from the date of purchase; and warrants the sealed system (consisting of the compressor, the condenser, the evaporator, the ...
Page 24 - For General Inquiries:
For General Inquiries: P.O. Box 245040Milwaukee, Wisconsin 53224-9540 U.S.A.Phone (800) 779-2547 FAX (414) 354-5696www.U-Line.com For Service and Parts Assistance: Phone (800) 779-2547 (414) 354-0300 FAX (414) 354-5696Email: [email protected]: [email protected]...
