Slant/Fin V-33 - Manual
Slant/Fin V-33 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – ICTORY; Figure 1. Left End View
- Page 3 – In no case may the boiler be installed on carpeting.
- Page 4 – * Also see Z223.1 Par t 7 and see Par t 11 for use of mentioned tables.
- Page 5 – : AL 29-4C is a registered trademark of Allegheny Ludlum Corp.
- Page 6 – NATURAL DRAFT CHIMNEY AND TYPE “B” VENTING
- Page 7 – use galvanized risers and connectors in cool boiler rooms.
- Page 11 – Length
- Page 13 – Boiler rated input in; Gas Valve
- Page 15 – Top View of Boiler
- Page 17 – Sequence of Operations
- Page 18 – PUMP OR VALVE ZONING OF WATER BOILERS; Pump Zoning system using R845 Relay.; pump load must not exceed 7.4 amp rating of
- Page 19 – Check and correct in accordance with wiring diagrams; GENERAL TROUBLESHOOTING GUIDE FOR SERVICEPEOPLE
HOT WATER MODELS V-33 THROUGH V-180
INSTALLATION AND OPERATING INSTRUCTIONS
GAS-FIRED CAST-IRON BOILERS FOR NATURAL AND L.P. PROPANE GASES
CONTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PAGE
Ratings and Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . .2
Installation Requirements:
Boiler Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Boiler Foundation . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Minimum Clearance . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Venting Requirements . . . . . . . . . . . . . . . . . . . . . . . . . .3
Chimney and Type “B” Venting . . . . . . . . . . . . . . . . . . .4
Horizontal Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Ver tical Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Regular Inspection . . . . . . . . . . . . . . . . . . . . . . . . . .6
Gas Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Electrical Controls and Wiring . . . . . . . . . . . . . . . . .11
Boiler Room Air Supply and Ventilation . . . . . . . . . . . .11
Water Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Operating Instructions:
Filling and Venting Water Systems . . . . . . . . . . . . . . . .12
Initial Star t, Safety and Lighting Instructions . . . . . . . .12
IID System with Honeywell VR8204 or VR8304 . . .12
Burner Adjustment, Checking Gas Input . . . . . . . . . . .13
Care and Maintenance:
General Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . .14
Water Level Check . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Annual Inspection and Cleaning . . . . . . . . . . . . . . .14
Safety Check for Control Systems . . . . . . . . . . . . . . . .15
Protection from Freezing . . . . . . . . . . . . . . . . . . . . .15
Water Treatment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Appendix A and B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Sequence of Operations . . . . . . . . . . . . . . . . . . . . . . . . . .17
Wiring Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Pump or Valve Zoning of Water Boilers . . . . . . . . . . . . . .18
General Troubleshooting Guide . . . . . . . . . . . . . . . . . . . . .19
Piping a Heating-Cooling System . . . . . . . . . . . . . . . . . . .20
Replacement Par ts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
IMPORTANT
READ ALL OF THE FOLLOWING
WARNINGS AND STATEMENTS
BEFORE READING THE
INSTALLATION INSTRUCTIONS
WARNING
LIQUEFIED PETROLEUM (L.P.)
PROPANE FIRED GAS BOILERS
Installation location ONLY as permitted in paragraph
entitled "LIQUEFIED PETROLEUM (L.P.) PROPANE
GAS FIRED BOILER LOCATION" on page 3 of this
instruction book.
The above warning does not apply to
NATURAL gas
fired boilers.
The installation must conform to the requirements of
the authority having jurisdiction or, in the absence of
such requirements, to the National Fuel Gas Code,
ANSI Z223.1-latest edition. The installation must also
conform to the additional requirements in this Slant/Fin
Instruction Book.
In addition where required by the authority having juris-
diction, the installation must conform to American Soci-
ety of Mechanical Engineers Safety Code for
Controls and Safety Devices for Automatically Fired
Boilers. No. CSD-1.
WARNING
This boiler, gas piping and accessories must be
installed, connected, serviced and repaired by a
trained, experienced service technician, familiar with all
precautions required for gas fired equipment and
licensed or otherwise qualified, in compliance with the
authority having jurisdiction.
This manual must be left with owner and should be
hung on or adjacent to the boiler for reference.
Printed in U.S.A. 301
Publication No.V-40
Par t No. 44-0596
Rev. M
Victory
™
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 V ICTORY Dimensions (inches) Figure 1. Left End View Figure 2. Front View Figure 3. Right End View NOTE: Height Dimension increases to 30-3/16" and depth dimension increases to 22-1/4" when combustible floor kit is used. Base Assembly Victory Boiler V-33 Natural #48 49 50 50 50 51 51 52 52...
V ICTORY 3 INSTALLATION REQUIREMENTSThe installation must conform to the requirements of the authority having jurisdiction or, in the absence of such requirements, to the National Fuel Gas Code, ANSI Z223.1- latest edition. This installation must also conform to the additional require- ments in this...
4 V ICTORY Reference Table No. * Appliance Connector Requirements* (ANSI Z223.1) Victory Boilers Type “B” See table 11-1 for minimum and maximum of vent 11-1 (V-90, V-120, V-150 and V-180) height and lateral length restriction. Single appliance Victory Boiler Single-wall See table 11-2 for minimum a...
