Schumacher SE 3612 - Manual
Schumacher SE 3612 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – NEVER; PERSONAL PRECAUTIONS AND SAFETY; ADAPTER PLUG NOT ALLOWED IN CANADA; CHARGER LOCATION PRECAUTIONS
- Page 3 – OPERATING INSTRUCTIONS: CHARGING BATTERY IN VEHICLE; WARNING: A spark near battery may cause battery explosion.; OPERATING INSTRUCTIONS: CHARGING BATTERY OUT OF VEHICLE; NEGATIVE GROUNDED POST
- Page 4 – OUTPUT SELECTOR CONTROLS; HOLD
- Page 5 – BATTERY CHARGING; NOTE: These battery chargers are not automatic and can; CHARGER MUST BE ASSEMBLED BEFORE USING.
- Page 6 – ASSEMBLY INSTRUCTIONS; Wheel Charger assembly instructions:; LOCALIZACION DE AVERIAS
1
Sch487
OWNER'S MANUAL
WORKING IN VICINITY OF A LEAD-ACID BATTERY IS DANGEROUS. BATTERIES
GENERATE EXPLOSIVE GASES DURING NORMAL BATTERY OPERATION. FOR THIS
REASON, IT IS OF UTMOST IMPORTANCE THAT EACH TIME BEFORE USING YOUR
CHARGER, YOU READ THIS MANUAL AND FOLLOW THE INSTRUCTIONS EXACTLY.
GENERAL BATTERY SAFETY
1.
Before you use your battery charger, be sure to read all
instructions and cautions printed on:
• Battery Charger
• Battery
• Vehicle or unit using battery
2.
Use battery charger on LEAD ACID type rechargeable bat-
teries only, such as used in autos, trucks, tractors, airplanes,
vans, RV's, trolling motors, etc. Charger is not intended to
supply power to low-voltage electrical system other than in
an automotive application.
WARNING:
Do not use battery charger for charging dry-
cell batteries that are commonly used with home appliances.
These batteries may burst and cause injury to persons and
damage to property.
3.
Use only attachments recommended or sold by manufac-
turer. Use of non-recommended attachments may result in
fire, electric shock, or injury.
4.
When disconnecting the battery charger, pull by the plug
not by the cord. Pulling on the cord may cause damage to
cord or plug.
5.
Locate battery power cord so it cannot be stepped on,
tripped over, or subjected to damage or stress.
6.
Do not operate charger with damaged cord or plug. Have
cord replaced immediately.
7.
Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way. Take it to a
qualified professional for inspection and repair.
8.
Do not disassemble charger. Take it to a qualified profes-
sional when service or repair is required. Incorrect reas-
sembly may result in electric shock or fire.
9.
To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.
10. Do not use an extension cord unless absolutely necessary.
Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make
sure that:
• Pins on plug of extension cord are the same number, size,
and shape as those of the plug on the charger.
• Extension cord is properly wired and in good electrical
condition.
• Wire size is large enough for AC ampere rating of charger,
as specified below:
_____________________________________________
Length of cord (feet): 25
50 100 150
AWG size of cord:
16
12 10
8
(American Wire Gauge)
_____________________________________________
11. Always charge battery in a well ventilated area.
NEVER
operate in a closed-in or restricted area without
adequate ventilation because of risk of explosive gases.
WARNING:
Risk of explosive gas.
12. Locate charger as far away from battery as DC charger
cables permit.
13. Do not expose charger to rain or snow.
14.
NEVER
charge a frozen battery. If battery fluid (electrolyte)
is frozen, bring into a warm area to thaw before charging.
15.
NEVER
allow battery acid to drip on charger when reading
specific gravity or filling battery.
16.
NEVER
set a battery on top of charger.
17.
NEVER
place charger directly above battery being charged.
Gases from battery will corrode and damage charger.
18.
NEVER
touch the battery clips together when the charger
is energized.
A
487-699
MODEL
SE 3612
Read Rules for
Safe Operation
and Instructions
Carefully
• IMPORTANT SAFETY INSTRUCTIONS •
• SAVE THESE INSTRUCTIONS •
ELECTRIC CORPORATION
801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179
Send Warranty Product Repairs to: P.O. Box 280 • 1025 East Thompson Avenue, Hoopeston, IL 60942
Call Customer Service if you have questions: 1-800-621-5485
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 Sch487 1. WARNING: Wear complete eye protection and clothing protection, when working with lead-acid batteries. 2. Make sure someone is within range of your voice or closeenough to come to your aid when you work with or near alead-acid battery. 3. Have plenty of fresh water and soap nearby for use...
3 Sch487 OPERATING INSTRUCTIONS: CHARGING BATTERY IN VEHICLE When charging battery in the vehicle, take care to determine the battery type and which post is grounded. To reduce risk of a sparknear battery, follow these steps when battery is installed in vehicle. WARNING: A spark near battery may cau...
4 Sch487 H. OUTPUT SELECTOR CONTROLS Switches Select down 12v 40A up 12v 2A #1 #2 #3 12v 200A Start 6v 40A or 6v 100A Start CHARGING START DC AMPS 0 10 20 30 40 200 Discharged40 AMP Reading TIMER: The main function of the timer is to prevent over charg- ing while allowing a battery time to obtain a ...
