Schumacher SS-120A-PE - Manual
Schumacher SS-120A-PE – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – PERSONAL PRECAUTIONS AND SAFETY; PREPARING TO CHARGE
- Page 5 – FIGURE 1: CONNECT NEGATIVE BATTERY CLAMP; OPERATING INSTRUCTIONS: CHARGING BATTERY IN VEHICLE; NEGATIVE GROUNDED POST; FIGURE 2: CONNECTION TO NEGATIVE
- Page 7 – LIMITED WARRANTY; Send Warranty Product Repairs to:
- Page 8 – Manual del Usuario; –No destruya este manual–; Lávese las manos después de manejar estos cordones.
- Page 9 – PREPARANDO LA CARGA; LED DISPLAY
- Page 11 – INSTRUCCIONES DE OPERACION: PARA CARGAR LA BATERIA EN EL VEHÍCULO
1
A.
GENERAL BATTERY SAFETY
1.
Before you use your battery charger, be sure to read all in-
structions and cautions printed on:
• Battery Charger
• Battery
• Vehicle or unit using battery
2.
Use battery charger on LEAD-ACID type rechargeable bat-
teries only, such as used in automobiles, trucks, tractors,
airplanes, vans, RV's, trolling motors, etc. Charger is not
intended to supply power to low-voltage electrical system
other than in an automotive application.
WARNING:
Do not use battery charger for charging dry-cell
batteries that are commonly used with home appliances.
These batteries may burst and cause injury to persons and
damage to property.
3.
Use only attachments recommended or sold by manufac-
turer. Use of non-recommended attachments may result in
fire, electric shock, or injury.
4.
When disconnecting the battery charger, pull by the plug,
not by the cord. Pulling on the cord may cause damage to
cord or plug.
5.
Locate battery charger power cord so it cannot be stepped
on, tripped over, or subjected to damage or stress.
6.
Do not operate charger with damaged cord or plug. Have
cord replaced immediately.
7.
Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way. Take it to a quali-
fied professional for inspection and repair.
8.
Do not disassemble charger. Take it to a qualified profes-
sional when service or repair is required. Incorrect reassem-
bly may result in electric shock or fire.
9.
To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.
10. Do not use an extension cord unless absolutely necessary.
Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make
sure that:
• Pins on plug of extension cord are the same number, size,
and shape as those of plug on charger.
• Extension cord is properly wired and in good electrical
condition.
• Wire size is large enough for AC ampere rating of charger,
as specified below:
Length of cord (feet):
25
50
100
150
AWG size of cord:
18
18
16
14
11. Always charge battery in a well-ventilated area.
NEVER
op-
erate in a closed-in or restricted area without adequate ven-
tilation.
WARNING:
Risk of explosive gas.
12. Locate charger as far away from battery as DC charger
cables permit.
13. Do not expose charger to rain or snow.
14.
NEVER
charge a frozen battery. If battery fluid (electrolyte)
is frozen, bring into a warm area to thaw before charging.
15.
NEVER
allow battery acid to drip on charger when reading
specific gravity or filling battery.
16.
NEVER
set a battery on top of charger.
17.
NEVER
place charger directly above battery being charged.
Gases from battery will corrode and damage charger.
18.
NEVER
touch the battery clamps together when the charger
is energized.
19.
NEVER
crank engine with SS-120A-PE charger attached to
battery.
Read Rules for Safe Operation and Instructions Carefully
Working in vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases during normal
battery operation. For this reason, it is of utmost importance that each time before using your charger, you
read this manual and follow the instructions exactly.
Owner's Manual
–Save–
Important Safety Instructions
Battery
Charger
Model:
SS-120A-PE, 12 Amp
Fully Automatic Battery Charger
For 12 Volt Marine Deep Cycle &
Automotive Batteries
00-99-000307/0103
SCHUMACHER ELECTRIC CORPORATION
801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179
Send Warranty Product Repairs to: 1025 E. Thompson, Hoopeston, IL 60942-0280
Call Customer Service if you have questions: 1-800-621-5485
WARNING:
Handling the cord on this product or cords associated with accessories sold with this product, will expose you to lead, a chemical
known to the State of California to cause cancer and birth defects or other reproductive harm.
Wash hands after handling
.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 B. PERSONAL PRECAUTIONS AND SAFETY 1. WARNING: Wear complete eye protection and clothing pro- tection when working with lead-acid batteries. 2. Make sure someone is within range of your voice or closeenough to come to your aid when you work with or near alead-acid battery. 3. Have plenty of fresh ...
5 5. Plug charger AC cord into 120 volt outlet. 6. Select automatic or manual charging, see Charger Controls. 7. When battery is fully charged, unplug charger from ACpower source. 8. When battery is fully charged and charger is unplugged,(1) remove clamp from end of Negative end of cable, and(2) rem...
7 LIMITED WARRANTY SCHUMACHER ELECTRIC CORPORATION, 801 BUSINESSCENTER DRIVE, MOUNT PROSPECT, ILLINOIS, 60056-2179MAKES THIS LIMITED WARRANTY TO THE ORIGINAL PUR-CHASER AT RETAIL OF THIS PRODUCT. THIS LIMITED WAR-RANTY IS NOT TRANSFERABLE. Schumacher Electric Corporation warrants this battery charge...
