Schumacher SF-3000 - Manual
Schumacher SF-3000 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – CHARGER LOCATION PRECAUTIONS; Remove all personal metal items such as rings, bracelets,; PERSONAL PRECAUTIONS AND SAFETY; Do not set battery on top of the charger.; PREPARING TO CHARGE
- Page 3 – Position AC power cord and DC charging cords to reduce
- Page 4 – OUTPUT SELECTOR CONTROLS
- Page 5 – BATTERY CHARGING; NOTE: These battery chargers are not automatic and can; CHARGER MUST BE ASSEMBLED BEFORE USING.; ENGINE START; CHARGE PERIOD
- Page 6 – ASSEMBLY INSTRUCTIONS; TROUBLESHOOTING
- Page 7 – C. PREPARACION PARA CARGAR
- Page 8 – GARANTIA
1
A.
GENERAL BATTERY SAFETY
1.
Before you use your battery charger, be sure to read all
instructions and cautions printed on:
• Battery Charger
• Battery
• Vehicle or unit using battery
2.
Use battery charger on LEAD ACID type rechargeable
batteries only, such as used in autos, trucks, tractors,
airplanes, vans, RV's, trolling motors, etc. Charger is not
intended to supply power to low-voltage electrical system
other than in an automotive application.
WARNING: Do not use battery charger for charging dry-
cell batteries that are commonly used with home appliances.
These batteries may burst and cause injury to persons and
damage to property.
3.
U s e o n l y a t t a c h m e n ts r e c o m m e n d e d o r s o l d b y
manufacturer. Use of non-recommended attachments may
result in fire, electric shock, or injury.
4.
When disconnecting the battery charger, pull by the plug
not by the cord. Pulling on the cord may cause damage to
cord or plug.
5.
Locate battery power cord so it cannot be stepped on,
tripped over, or subjected to damage or stress.
6.
Do not operate charger with damaged cord or plug. Have
cord replaced immediately.
7.
Do not operate charger if it has received a sharp blow,
been dropped, or otherwise damaged in any way. Take it to
a qualified professional for inspection and repair.
8.
D o n o t d i s a s s e m b l e c h a r g e r. Ta k e i t t o a q u a l i f i e d
professional when service or repair is required. Incorrect
reassembly may result in electric shock or fire.
9.
To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.
10. Do not use an extension cord unless absolutely necessary.
Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make
sure that:
• Pins on plug of extension cord are the same number,
size, and shape as those of the plug on the charger.
• Extension cord is properly wired and in good electrical
condition.
• Wire size is large enough for AC ampere rating of charger,
as specified below:
Length of cord (feet):
25
50
100
150
AWG size of cord:
16
12
10
8
(American Wire Gauge)
11. Always charge battery in a well ventilated area.
NEVER operate in a closed-in or restricted area without
adequate ventilation because of risk of explosive gases.
WARNING: Risk of explosive gas.
12. Locate charger as far away from battery as DC charger
cables permit.
13. Do not expose charger to rain or snow.
14. NEVER charge a frozen battery. If battery fluid (electrolyte)
is frozen, bring into a warm area to thaw before charging.
15. NEVER allow battery acid to drip on charger when reading
specific gravity or filling battery.
16. NEVER set a battery on top of charger.
17. NEVER place charger directly above battery being charged.
Gases from battery will corrode and damage charger.
18. NEVER touch the battery clips together when the charger
is energized.
00-00-000-556/0103
SCHUMACHER ELECTRIC CORPORATION
801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179
Send Warranty Product Repairs to: 1025 E. Thompson, Hoopeston, IL 60942-0280
Call Customer Service if you have questions: 1-800-621-5485
Read Rules for Safe Operation and Instructions Carefully
Working in vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases during normal
battery operation. For this reason, it is of utmost importance that each time before using your charger, you
read this manual and follow the instructions exactly.
Owner's Manual
–Save–
Important Safety Instructions
WARNING: Handling the cord on this product or cords associated with accessories sold with this product, will expose you to lead, a
chemical known to the State of California to cause cancer and birth defects or other reproductive harm.
Wash hands after handling.
SE-2352, SE-3000, SF-3000,
SE-2158, SE-6030, SE-8050,
SF-8050
Battery
Charger
Models:
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 CHARGER LOCATION PRECAUTIONS 1. WARNING: Wear complete eye protection and clothingprotection, when working with lead-acid batteries. 2. Make sure someone is within range of your voice or closeenough to come to your aid when you work with or near alead-acid battery. 3. Have plenty of fresh water an...
3 OPERATING INSTRUCTIONS: CHARGING BATTERY IN VEHICLE When charging battery in the vehicle, take care to determine the battery type and which post is grounded. To reduce risk of a sparknear battery, follow these steps when battery is installed in vehicle. WARNING: A spark near battery may cause batt...
4 H. OUTPUT SELECTOR CONTROLS TIMER: The main function of the timer is to prevent over charging whileallowing a battery time to obtain a satisfactory charge. To properly setthe timer you must know the size of the battery in ampere hours orreserve capacity in minutes and the state of charge. Often th...
