Powermate PLA4708065 - User Manual

Powermate PLA4708065

Powermate PLA4708065 Compressor – User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
Page: / 36

Table of Contents:

  • Page 2 – – A POTENTIAL HAZARD THAT WILL CAUSE SERIOUS INJURY OR LOSS OF LIFE.; RISK OF FIRE OR EXPLOSION.; it immediately with a new tank or replace the entire compressor.; RISK OF ELECTRICAL SHOCK.
  • Page 3 – in a well ventilated area when using tools that generate dust.; IMPORTANT SAFETY INSTRUCTIONS
  • Page 4 – OVERVIEW; BASIC AIR COMPRESSOR COMPONENTS
  • Page 5 – ASSEMBLY; ASSEMBLING THE COMPRESSOR
  • Page 6 – TYPICAL INSTALLATION; Air dryers and after coolers; inside the tank, not pressure in the air line; Air lubrication; Do not use a lubricator for paint spraying or similar; Shut–off valves; Compressor may vary from one shown.
  • Page 7 – not; COMPRESSOR CONTROLS; NEVER force
  • Page 8 – DO NOT; return the unit to the; OPERATING INSTRUCTIONS; SHUTDOWN
  • Page 9 – MAINTENANCE
  • Page 10 – TO REPLACE OR CLEAN CHECK VALVE
  • Page 11 – CHECKING THE RELIEF VALVE
  • Page 12 – TROUBLESHOOTING
  • Page 13 – SPÉCIFICATIONS DE L’ALIMENTATION; TABLE DES MATIÈRES
  • Page 14 – produits chimiques comprennent :; DIRECTIVES DE SÉCURITÉ IMPORTANTES
  • Page 15 – Pression de conjonction :; GLOSSAIRE DES TERMES; moteur électrique; VUE D’ENSEMBLE; ÉLÉMENTS DE BASE DU COMPRESSEUR D’AIR
  • Page 16 – ASSEMBLAGE; ASSEMBLAGE DU COMPRESSEUR
  • Page 17 – INSTALLATION TYPIQUE; Dessicateurs et radiateurs secondaires; à l’intérieur du réservoir et non pas la pression dans; Lubrification de l’air; N’utilisez pas de lubrificateur pour les; Soupapes d’arrêt; Le compresseur peut varier d’un montré.
  • Page 18 – COMMANDES DU COMPRESSEUR; INTERRUPTEUR DE REMISE EN MARCHE DU MOTEUR; SPÉCIFICATIONS DU COURANT ÉLECTRIQUES; CÂBLAGE ÉLECTIQUE
  • Page 19 – DÉMARRAGE PAR TEMPS FROID; MODE D’EMPLOI; RODAGE DE LA POMPE; INSTRUCTIONS POUR LA MISE À LA TERRE
  • Page 20 – ENTRETIEN; D = Bouchon de l’orifice de
  • Page 21 – ALIGNEMENT DE LA POULIE
  • Page 22 – NETTOYAGE DU FILTRES À AIR; ENTRETIEN PÉRIODIQUE; Utilisez une huile
  • Page 23 – DÉPANNAGE
  • Page 24 – - RIESGO POTENCIAL DE LESIONES GRAVES O PÉRDIDA DE LA VIDA.; INDICE; RIESGO DE INCENDIO O; RIESGO DE
  • Page 25 – INSTRUCCIONES IMPORTANTES DE SEGURIDAD
  • Page 26 – motor eléctrico; RESUMEN GENERAL; COMPONENTES BÁSICOS DEL COMPRESOR DE AIRE; Presión de encendido:; GLOSARIO DE TÉRMINOS
  • Page 27 – MONTAJE; MONTAJE DEL COMPRESOR
  • Page 28 – INSTALACIÓN TIPICA; Secadores de aire y post–enfriadores; en el interior del receptor y no la presión en la línea; Lubricación de aire; No utilice un lubricador para rociar; Válvulas de apagado; El compresor puede variar a partir del uno demostrado.
  • Page 29 – INTERRUPTOR DE RESTABLECIMIENTO DEL MOTOR
  • Page 30 – INSTRUCCIONES OPERATIVAS; Si después de 30 minutos la unidad no funciona; PUESTA EN MARCHA INICIAL DE LA BOMBA; REQUISITOS DE ALIMENTACION ELECTRICA; INSTRUCCIONES DE PUESTA A TIERRA
  • Page 31 – MANTENIMIENTO
  • Page 32 – ALINEACIÓN DE LA POLEA
  • Page 33 – REVISIÓN DE LA VÁLVULA DE DESCARGA; INTERVALOS DE SERVICIO; LIMPIEZA DEL FILTROS DE AIRE
  • Page 34 – CUADRO DE DETECCIÓN DE FALLOS
  • Page 35 – NOTES
  • Page 36 – PARTS AND SERVICE
Loading the manual

Operator Manual

Manuel de l’opérateur

Manual del operador

Belt Drive, Electric Air Compressors
Actionnement pour courroie, Compresseur d’air électrique
Accionamiento por correa, Compresor de aire électrico

• Français, p. 13-23

• Español, p. 24-34

200-2824

Revision E

200-2824_Revision E_5/29/18

WARNING:

Read and understand all safety precautions in this manual before operating. Failure to comply with instructions in

this manual could result in personal injury, property damage, and/or voiding of your warranty. The manufacturer

WILL NOT

be liable

for any damage because of failure to follow these instructions.

AVERTISSEMENT:

Lire et s’assurer de bien comprendre toutes les consignes de sécurité du présent manuel avant

d’utiliser l’outil. Toute dérogation aux instructions contenues dans ce manuel peut entraîner l’annulation de la garantie, causer des

blessures et/ou des dommages matériels. Le fabricant

NE SAURA

être tenu responsable de dommages résultant de l’inobservation

de ces instructions.

ADVERTENCIA:

Lea y comprenda todas las precauciones de seguridad contenidas en este manual antes de utilizar esta

herramienta. El no cumplir con las instrucciones de este manual podría dar como resultado la anulación de su garantía, lesiones

personales y/o daños a la propiedad. El fabricante

NO SERA

responsable de cualquier daño debido a no acatar estas instrucciones.

NOTE: These units DO NOT require

a magnetic starter.

REMARQUE : Ces compresseurs ne

nécessitent pas l’installation d’un

démarreur magnétique.

NOTA: Estas unidades no requieren

la instalación de un arrancador

magnético.

Product style and configuration may vary.
Le style et la configuration du produit peuvent varier.
El estilo y la configuración del producto puede variar.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - – A POTENTIAL HAZARD THAT WILL CAUSE SERIOUS INJURY OR LOSS OF LIFE.; RISK OF FIRE OR EXPLOSION.; it immediately with a new tank or replace the entire compressor.; RISK OF ELECTRICAL SHOCK.

2 - ENG 200-2824 SAFETY GUIDELINES .......................................................... 2-4 GLOSSARY OF TERMS .......................................................... 4 OVERVIEW ........................................................................... 4-5 ASSEMBLY ............................

Page 3 - in a well ventilated area when using tools that generate dust.; IMPORTANT SAFETY INSTRUCTIONS

3 - ENG 200-2824 RISK TO BREATHING/ INHALATION HAZARD. Always wear MSHA/NIOSH approved, properly fitting face mask or respirator and work in a well ventilated area when using tools that generate dust. Some dust created by power sanding, grinding, drilling and other construction activities contains c...

Page 4 - OVERVIEW; BASIC AIR COMPRESSOR COMPONENTS

4 - ENG 200-2824 The basic components of the air compressor are the electric motor, pump, pressure switch and tank (see Fig. 1 ). The electric motor (see A ) powers the pump. The pump (see B ) compresses the air and discharges it into the tank. The tank (see C ) stores the compressed air. The pressu...

Other Powermate Compressors Models