Page 2 - Model OFE/OFG/OEA/OGA-341, 342
Page 4 - TABLE OF CONTENTS; ii
Model OFE/OFG/OEA/OGA-341, 342 TABLE OF CONTENTS Section Page Section 1. TROUBLESHOOTING ...................................................................................................1-1 1-1. Introduction .............................................................................................
Page 5 - an easy to read table.; SECTION 1. TROUBLESHOOTING
Model OFE/OFG/OEA/OGA-341, 342 1-1. INTRODUCTION This section provides troubleshooting information in the form of an easy to read table. If a problem occurs during the first operation of a new fryer, recheck the Installation Section of the Operator’s Manual. Before troubleshooting, always recheck th...
Page 6 - If maintenance procedures are not followed correctly,
Model OFE/OFG/OEA/OGA-341, 342 1-3. TROUBLESHOOTING To isolate a malfunction, proceed as follows: 1. Clearly define the problem or symptom and when it occurs. 2. Locate the problem in the Troubleshooting table. 3. Review all possible causes, then one at a time work through the list of corrections un...
Page 7 - PROBLEM
Model OFE/OFG/OEA/OGA-341, 342 1-3. TROUBLESHOOTING(Continued) PROBLEM CAUSE CORRECTION Heating of • Low or improper • Use a meter and check the receptacle shortening too voltage (elec. unit) voltage against the data plate slow • Weak or burnt out • Check heating elements per Heating elements (elec....
Page 9 - DISPLAY
Model OFE/OFG/OEA/OGA-341, 342 1-4. ERROR CODES In the event of a control system failure, the digital display shows An error message. These messages are coded: “E4”, “E5”, “E6”, “E10”, “E15”, “E20”, “E31”, “E41”, “E46”, and “E92”. A Constant tone is heard when an error code is displayed, and to sile...
Page 10 - DISPLAY CAUSE PANEL
Model OFE/OFG/OEA/OGA-341, 342 1-4. ERROR CODES (Continued) DISPLAY CAUSE PANEL BOARD CORRECTION “E-20 A” Vacuum Press the timer button to try the ignition process again, switch failure and if “E-20 A” persists, check the air switch per Vacuum (stuck closed) Switch Section “E-20 B” Draft fan or Pres...
Page 11 - Checkout; SECTION 2. MAINTENANCE
Model OFE/OFG/OEA/OGA-341, 342 2-1. INTRODUCTION This section provides procedures for the check out and replacement of the various parts used within the fryer. Before replacing any parts refer to the Troubleshooting Section. It will aid you in determining the cause of the malfunction. 2-2. MAINTENAN...
Page 12 - LIMIT CONTROL
Model OFE/OFG/OEA/OGA-341, 342 1-3. HIGH TEMPERATURE 2. Using a Phillip’s head screwdriver, remove the screws securing LIMIT CONTROL the inner heat shield and remove from unit. Figure 2-3. (Gas Units) (Continued) Figure 2-3 3. Remove the screw securing the high limit bracket to the frame and remove ...
Page 14 - When plugging connectors onto new control panel, be sure the
Model OFE/OFG/OEA/OGA-341, 342 2-4. COMPLETE CONTROL Should the control board become inoperative, follow these PANEL REPLACEMENT instructions for replacing the board. 1. Remove electrical power supplied to the unit. To avoid electrical shock or property damage, move the power switch to OFF and disco...
Page 15 - To avoid electrical shock or property damage, move the
Model OFE/OFG/OEA/OGA-341, 342 2-5. POWER SWITCH (Continued) 4. With control panel removed, and the wires off the switch, push in on tabs on the switch to remove from panel. Figure 2-12. 5. Replace with new switch, and reconnect wires to switch. 6. Replace the control panel. Figure 2-12 2-6. TEMPERA...
Page 16 - Excess force will damage probe.
Model OFE/OFG/OEA/OGA-341, 342 2-6. TEMPERATURE PROBE 5. Remove the probe from the frypot, and disconnect wire REPLACEMENT (GAS) connector from the control panel. Figure 2-15. (Continued) 6. Place the nut and new ferrule on the new probe and insert the probe into the compression fitting until it ext...
Page 18 - PILOT / IGNITOR
Model OFE/OFG/OEA/OGA-341, 342 2-8. FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY (Gas) (Continued) 2. Remove the control panel and heat shield from control area. Figure 2-19. Figure 2-19 3. Disconnect the flame sense wire from ignition module. Figure 2-20. Figure 2-20 4. Using a 7/16” wrench, loosen the n...
Page 21 - REPLACEMENT; To avoid property damage, do not tamper with, or disas semble
Model OFE/OFG/OEA/OGA-341, 342 2-12. VACUUM SWITCH This switch senses the airflow from the induction blower. If REPLACEMENT the airflow is reduced below a set amount, the switch opens and the I/O board cuts power to the gas control valve, which shuts the pilot flame off. 1. Remove electrical power s...
Page 24 - Figure; Figure; Using a 1-inch wrench, loosen the nut securing the main gas; Figure
Model OFE/OFG/OEA/OGA-341, 342 2-15. GAS CONTROL VALVE REPLACEMENT (Continued) 1. Remove right side panel. Figure 2-37. Figure 2-37 2. Label and remove wires from gas valve. Figure 2-38 Figure 2-38 3. Using a 7/16 wrench, remove the pilot line from the gas valve. Figure 2-39. Figure 2-39 4. Using a ...
Page 26 - Remove the wire cover from the blower motor housing.
Model OFE/OFG/OEA/OGA-341, 342 2-16. BLOWER MOTOR REPLACEMENT (Continued) 3. Remove the wire cover from the blower motor housing. Figure 2-44. Figure 2-44 4. Remove wire nuts connecting blower motor wires to wires in conduit. Figure 2-45. Figure 2-45 5. Loosen conduit from blower motor. Figure 2-46....
Page 28 - Wire; Heating elements should never be energized without
Model OFE/OFG/OEA/OGA-341, 342 2-17. HEATING ELEMENTS 4. Perform an ohm check on one element at a time, with wires (ELECTRIC) disconnected. The 2 elements actually have 3 small heating (Continued) elements inside the outer plate. It’s important to check between the correct wires to obtain an accurat...
Page 29 - Heat
Model OFE/OFG/OEA/OGA-341, 342 2-18. HEATING Each well of an electric fryer requires two switching contactors. CONTACTORS The first in line is the primary contactor and the second in line is (ELECTRIC) the heat contactor. When open, the primary contactor does not allow power to flow to the heat cont...
Page 36 - MOTOR
Model OFE/OFG/OEA/OGA-341, 342 2-21. FILTER PUMP AND 1. Remove electrical power supplied to unit. MOTOR REMOVAL To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacle. 2. Open the door (left door on 2 well uni...
Page 39 - Using 7/16” socket, remove the 4 nuts securing the support
Model OFE/OFG/OEA/OGA-341, 342 2-24. AUTOLIFT ACTUATOR (MOTOR) REPLACEMENT (if applicable) 5. Disconnect actuator connector. Figure 2-80. Figure 2-80 6. Remove female connector from plate. Figure 2-81. Figure 2-81 Figure 2-82 7. Using 7/16” socket, remove the 4 nuts securing the support plate. 2 nut...
Page 40 - Remove the 2 top screws securing the support plate and
Model OFE/OFG/OEA/OGA-341, 342 2-24. AUTOLIFT ACTUATOR (MOTOR) REPLACEMENT (if applicable) 8. Remove the 2 top screws securing the support plate and remove the plate from the unit. Figure 2-84. Figure 2-84 9. Using a 15T torx driver, remove the 2 torx screws from the back shroud, and pull the actuat...
Page 41 - Drain switch wired N/C
Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 106 2-31
Page 49 - Drain switch wired N/O
Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 106 2-39
Page 57 - SECTION 3. PARTS INFORMATION
Model OFE/OFG/OEA/OGA-341, 342 SECTION 3. PARTS INFORMATION 3-1. INTRODUCTION This section list the replaceable parts of the Henny Penny OFE/OFG- 32X Open Fryers. 3-2. GENUINE PARTS Use only genuine Henny Penny parts in your fryer. Using a part of lesser quality or substitute design may result in da...
Page 58 - Description; Autolift PC Board; recommended parts
Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 Item No. Part No. Description Qty. per Well √ 1 60207 Transformer – 120-24V 1 √ 1 60536 Transformer – 230-24V 1 √ 2 50290 Autolift PC Board 1 √ 3 54561 Speaker Assy. 1 √ 4 72515 Vacuum Switch (Gas Only) 1 √ 5 TS22-012 Transformer-Autolift 1 √ recommended part...
Page 59 - Gas Components
Model OFE/OFG/OEA/OGA-341, 342 Gas Components 1 2 3 4 5 Item No. Part No. Description Qty. per Well √ 1 77602 Ignition Module – CE (OFG-SN: BR0804001 & Above) 2 (OGA-SN: BS0805001 & Above) √ 1 77839 Ignition Module – Non -CE 2 (OFG-SN: BR0804001 & Above) (OGA-SN: BS0805001 & Above) √...
Page 60 - Gas Burner Assembly
Model OFE/OFG/OEA/OGA-341, 342 Gas Burner Assembly Item No. Part No. Description Qty. per Well 1 FP01-091 Union – ½ NPT Female - BI 1 2 FP01-088 Elbow – Street ½ x 90 BI 2 3 NS03-067 Nut – Locking ½-20 x 3/16 LON 3 4 23389 Weldment - Manifold 1 5 64055-03 Orifices – Burner - LP 3 5 64055-16 Orifices...
Page 61 - Electric Components
Model OFE/OFG/OEA/OGA-341, 342 Electric Components 1 2 3 4 5 Item No. Part No. Description Qty. per Well √ 1 29510 Mercury Contactor – 24V 1 √ 2 51795 Standard Contactor – 24V 1 √ 2 65075 Assy.-240v E/M Heat Contactor-CE-240V (UK) 1 √ 2 65074 Assy.-240v E/M Heat Contactor-CE-230V 1 √ 3 18364 Fuse an...
Page 66 - Weld Assy. – Drain Extension – Gas
Model OFE/OFG/OEA/OGA-341, 342 Item No. Part No. Description Qty. per Unit √ 12 52129 Gas Valve - 24V - Nat. 1 (per well) √ 12 60632 Gas Valve - 24V - Nat. - CE 1 (per well) √ 12 21332 Gas Valve - 24 V - LP 1 (per well) √ 12 60633 Gas Valve - 24V - LP - CE 1 (per well) 13 23443 Weld Assy. – Drain Ex...
Page 67 - Control Panel Assy. less transformers
Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 6 7 8 9 Item No. Part No. Description Qty. per Well √ 1 60207 Transformer – 120-24V 1 √ 1 60536 Transformer – 230-24V 1 √ 2 74127RB Control Panel Assy. less transformers 1 √ 3 71029RB Control Board Assy – China 1 √ 4 58790RB I/O Board w/Power Supply Assy. 1 5...
Page 68 - Blower Motor Assy – 120V
Model OFE/OFG/OEA/OGA-341, 342 6 1 2 3 4 5 Item No. Part No. Description Qty. per Unit 1 33501 Gas Line – ¾ in. w/Double Swivel – 341 1 1 33167 Gas Line – 1 in. w/Double Swivel – 342 1 √ 2 64197 Blower Motor Assy – 120V 1 (per well) √ 2 21037 Blower Motor Assy – 220V-50 Hz 1 (per well) 3 33353 120V ...
Page 70 - Strap - Capillary Tube
Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 6 7 8 Item No. Part No. Description Qty. per Well √ 1 64210-01 Element – OFE34X – 208V 2 √ 1 64210-02 Element – OFE34X – 220V 2 √ 1 64210-03 Element – OFE34X – 230V 2 √ 1 64210-04 Element – OFE34X – 240V 2 √ 1 64210-07 Element – OFE34X – 480V 2 2 24194 Spread...
Page 71 - Orifice – Pilot – Nat.
Model OFE/OFG/OEA/OGA-341, 342 1 3 2 Item No. Part No. Description Qty. per Well √ 1 60266 Pilot - Tee Style & Ignitor Assy. 1 23735 Orifice – Pilot – Nat. 1 60614 Orifice – Pilot – LP 1 √ 2 60292 Sensor - Flame - Pilot 1 3 21827 Tube – Pilot 1 3 67817 Tube – Pilot – CE 1 √ recommended parts 106...
Page 72 - Assy-Heater Terminal Block
Model OFE/OFG/OEA/OGA-341, 342 Electric Components 1 2 3 4 Item No. Part No. Description Qty. per Well 1 60241 High Limit - 425º F 1 2 23823 Assy-Heater Terminal Block 1 3 14973 Temperature Probe Assembly 1 4 18227 Microswitch 1 5* 32497 EMC Filter Board - CE 1 6* 32498 Assy – 4 Inch Termi...
Page 74 - Hook – Basket Hanger – 1⁄2-Size
Model OFE/OFG/OEA/OGA-341, 342 Item No. Part No. Description Qty. per Well 1 24809 Hook – Basket Hanger – ½-Size (before 06/01/05) 1 1 70102 Hook – Basket Hanger – ½-Size (06/01/05 & after) 1 2 36030 Bracket – 1/3-Size Basket 1 3 38912 Bracket – 1/2-Size Basket (before 06/01/05) 1 3-18 106
Page 75 - OFG/OFE ELECTRO MECHANICAL PARTS LIST
Model OFE/OFG/OEA/OGA-341, 342 OFG/OFE ELECTRO MECHANICAL PARTS LIST PART NUMBER DESCRIPTION √ 60816 Adjustable Relay Base √ 60817 Adjustable Time Delay Relay √ 60818 24VAC Coil Relay √ 60765 24V Dual Face Timer √ 14851 Thermostat Kit 60814 E/M Bulb Mounting Clip (Gas) √ 35916 Transformer 120V to 24...
Page 76 - CONDUIT
Model OFE/OFG/OEA/OGA-341, 342 OVER-THE-TOP PUMBING W/O D.C. PARTS (March 1, 2006 & After) Item No. Part No. Description Qty. 1 73370 HANGER-ACTUATOR CONDUIT 1 2 SC06-013 U BOLT 1/4-20 FOR 3/4 DIA 3 3 71185 BRACKET-TUBE 1 4 SC03-001 SCREW #10 X 1/2 PH PHD TEK 2 C 4 5 71139 ASSY-TUBE RETURN LINE ...
Page 77 - FEMALE
Model OFE/OFG/OEA/OGA-341, 342 OVER-THE-TOP FAUCET ASSY. (March 1, 2006 & After) Item No. Part No. Description Qty. 1 71899 ASSY. – 341 FAUCET 1 17333 FEMALE DISCONNECT 1 1 71665 ASSY. – 342 FAUCET 1 17334 MALE DISCONNECT 1 2 71830 HANDLE – DIVERTER VALVE ( Direct-Connect units) 1 1209 3-21
Page 78 - DISCARD
Model OFE/OFG/OEA/OGA-341, 342 341 DIRECT-CONNECT PARTS LIST (Before March 1, 2006) Part No. Description Qty. 16282 NIPPLE 3/4 X CLOSE 1 21611 DISCONNECT-MALE 1 21612 DISCONNECT-FEMALE 1 21753 HOSE-SHORTENING DISCARD 1 21800 VALVE-3/4 CHECK 1 23430 VALVE-3/4 INLET-E34X 1 67850 BRACKET-34X D/C REAR S...
