Heat & Glo ST-36TR-IPI - Manual

Heat & Glo ST-36TR-IPI

Heat & Glo ST-36TR-IPI – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
69 Page 69
70 Page 70
71 Page 71
72 Page 72
73 Page 73
74 Page 74
75 Page 75
76 Page 76
77 Page 77
78 Page 78
79 Page 79
80 Page 80
81 Page 81
82 Page 82
83 Page 83
84 Page 84
85 Page 85
Page: / 85

Table of Contents:

  • Page 2 – Listing Label Information/Location; This owner ’s manual; Homeowner Reference Information; Model Number; XXXXXXXX; Read this manual before installing or operating this appliance.
  • Page 3 – Safety Alert Key:; • NOTICE: Used to address practices not related to personal injury.; Table of Contents; User Guide
  • Page 6 – This warranty is void if:; QRWOLPLWHGWRLPSURSHUFKLPQH\RUYHQWLQJLQVWDOODWLRQ; LIMITATIONS OF LIABILITY:; DWLRQRIJODVV
  • Page 7 – NOT INTENDED FOR USE AS A PRIMARY HEAT SOURCE.; Listing and Code Approvals; TYPE: Direct Vent Gas Appliance Heater; Models
  • Page 8 – T h e f o l l o w i n g r e q u i r e m e n t s r e f e r e n c e va r i o u s
  • Page 9 – Operating Instructions; A. Gas Fireplace Safety; WARNING; HOT SURFACES; touch glass until it is cooled
  • Page 10 – have a
  • Page 11 – NOT FOR USE; Final inspection by
  • Page 12 – ISSUE; Condensation on the glass
  • Page 13 – Glass Cleaning; Tools Needed; Maintenance and Service; Tools needed; Remote Control
  • Page 15 – Burner Ignition and Operation; DO NOT
  • Page 16 – A. Typical Appliance System; Getting Started; Installer Guide; Dual venting c onf igurations; ARE NOT; b e ve nt e d; E I T H E R; ve r t i c a l l y; O R
  • Page 17 – Read all of the instructions before starting the instal-; C. Tools and Supplies Needed; • Installation and use of any damaged appliance or vent; Any such action may cause a fi re hazard.
  • Page 18 – Framing and Clearances; A. Selecting Appliance Location
  • Page 19 – B. Constructing the Appliance Chase; • Insulation and other materials must be secured to prevent; Inches
  • Page 21 – See-Through Combustible Mantel; D. Mantel and Wall Projections; PIER Non-Combustible Mantel
  • Page 23 – A. Vent Termination Minimum Clearances; Termination Locations; pack air space with insulation or other
  • Page 24 – public; Covered Alcove Applications; NOT
  • Page 25 – B. Continue Adding Vent Components; To Install the Heat Shield:; CORRECT; C. Install Support Brackets; elbow in the venting system.
  • Page 26 – mix pipe, fi ttings or joining methods from differ-; Vent Information and Diagrams; D. Measuring Standards; • Pipe measurements are shown using the effective length; Horizontal
  • Page 27 – Note: The Multi-Sided series fi replaces can adapt; After; Reference Figure 7.14 for
  • Page 28 – Elbow only; Elbow only
  • Page 29 – Three Elbows
  • Page 30 – No Elbow; If installing a vertical vent/; Exhaust restrictor Instructions; Remove refractory panel and exhaust baffl e from pilot
  • Page 31 – Restrictor; Note; BREAK
  • Page 32 – One Elbow; Two Elbows; ELBOW ONLY
  • Page 33 – use a 45o elbow
  • Page 35 – Back to Back 90° Elbows
  • Page 36 – *No specifi c restrictions on this value EXCEPT; Maximum
  • Page 37 – A. Pipe Clearances to Combustibles; Vent Clearances and Framing; When venting off the top of the unit and terminating; B. Wall Penetration Framing; Combustible Wall Penetration; • The opening must be framed on all four sides using the; Non-Combustible Wall Penetration
  • Page 38 – C. Vertical Penetration Framing; ATTIC ABOVE; A ceiling fi restop; MUST; be used between; DVP pipe only; • Frame the area with the same sized lumber
  • Page 39 – D. Install Attic Insulation Shield; Flat Ceiling Installation; Vaulted Ceiling Installation
  • Page 40 – Appliance Preparation; Cut the metal retaining band and fold the sides
  • Page 42 – C. Securing and Leveling the Appliance; Once appliance is setup for top or rear venting, it; Failure to ensure that the fireplace opening
  • Page 43 – Attach Vent to the Firebox Assembly; The end of the pipe sections with the lanced tabs will face; Make sure that the seams are not aligned to prevent; INCORRECT; Lances
  • Page 44 – C. Assemble Slip Sections; Pilot hole; • Apply a bead of silicone sealant inside the female outer
  • Page 45 – E. Disassemble Vent Sections
  • Page 46 – F. Install Decorative Ceiling Components
  • Page 47 – G. Install Metal Roof Flashing; CAULK; H. Assemble and Install Storm Collar
  • Page 48 – I. Install Vertical Termination Cap; Heat shields may not be fi eld constructed.; K. Heat Shield Requirements for Horizontal; • DO NOT remove the heat shields attached to the
  • Page 49 – L. Install Horizontal Termination Cap (DVP
  • Page 50 – • Purge should be performed by; Gas Information; Gas Pressure; • If substituting for these components, please consult; D. High Altitude Installations
  • Page 51 – Electrical Information; D. Junction Box Installation; INSIDE
  • Page 52 – AN ELECTRIC CODE; The electrical junction box provided with the fi replace
  • Page 53 – Wiring the Wall Switch
  • Page 54 – F. Install the Flame Solenoid; Do not; G. Connect the Temperature Sensor Switch
  • Page 55 – I. Setting Flame Height/Manifold Pressure; J. Wall Switch Button Operation; Flame Button; The temperature displayed by the wall switch may take
  • Page 56 – Can be operated independently of all functions.; The controller will turn off the fi replace at 2° F over
  • Page 57 – Finishing; Risk of Fire; To install the Splatter Guard:
  • Page 59 – B. Mantel and Wall Projections
  • Page 60 – Top and Side Seal Joint
  • Page 61 – D. Finishing Material; Stop fi nishing material fl ush with opening.; Finishing materials over 1 inch thick.; Finishing materials 1 inch maximum thick.
  • Page 63 – E. Elevated Hearth Systems
  • Page 64 – Appliance Setup; Placement; Prepare Electric Ember Bed and Lava Rock.
  • Page 65 – Placing the Ember Material; • Embers CANNOT be placed directly over ports. Care
  • Page 66 – F. Install the Log Assembly; Logs are fragile! Carefully remove the logs; BAR
  • Page 68 – Notch; Log Assembly Installed.; Notch engaged with
  • Page 69 – I. Air Shutter Setting; G. Fixed Glass Assembly; Air Shutter Settings; H. Install Trim Kits and Surrounds; Removing Fixed Glass Assembly; NG
  • Page 70 – Troubleshooting; A. IntelliFire Ignition System; Symptom
  • Page 71 – a. A shorted or loose connection in fl ame
  • Page 72 – Reference Materials; A. Appliance Dimension Diagram; Location Inches
  • Page 74 – B. Vent Components Diagrams
  • Page 75 – Horizontal Termination Cap; Max; The heat shield is designed to be; Heat
  • Page 78 – Optional Wire Harness; Power Vent Inline
  • Page 79 – Effective Height/Length; Horizontal Pipe
  • Page 81 – ITEM; Log Set Assembly; 6” See-Through Gas Fireplace
  • Page 82 – 6” Pier Direct Vent Fireplace
  • Page 83 – Additional service part numbers appear on following page.
  • Page 85 – D. Contact Information; For the location of your nearest Heat & Glo dealer,; DO NOT DISCARD THIS MANUAL; NOTICE; • Leave this manual with
Loading the manual

Heat & Glo • ST-36TR-IPI, PIER-36TR-IPI • 2176-900 Rev. F • 8/11

1

Models:
ST-36TR-IPI
ST-36TRLP-IPI
PIER-36TR-IPI
PIER-36TRLP-IPI

•

DO NOT

store or use gasoline or other fl am-

mable vapors and liquids in the vicinity of this
or any other appliance.

• What to do if you smell gas

-

DO NOT

try to light any appliance.

-

DO NOT

touch any electrical switch.

DO

NOT

use any phone in your building.

- Immediately call your gas supplier from a

neighbor’s phone. Follow the gas suppli-
er’s instructions.

- If you cannot reach your gas supplier, call

the fi re department.

• Installation and service must be performed

by a qualifi ed installer, service agency, or the
gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a fi re
or explosion may result causing property
damage, personal injury, or death.

Owner’s Manual

Installation and Operation

DO NOT DISCARD THIS MANUAL

NOTICE

This appliance may be installed as an OEM installation in
manufactured home (USA only) or mobile home and must be
installed in accordance with the manufacturer’s instructions
and the manufactured home construction and safety standard,

Title 24 CFR, Part 3280

or

Standard for Installation in Mobile

Homes, CAN/CSA Z240MH, in Canada.

This appliance is only for use with the type(s) of gas indicated
on the rating plate.

Installation and service of this appliance should be
performed by qualifi ed personnel. Hearth & Home
Technologies suggests NFI certifi ed or factory trained
professionals, or technicians supervised by an NFI
certifi ed professional.

• Leave this manual with

party responsible for use
and operation.

DO NO

T

DISCARD

WARNING

• Important operating

a n d m a i n t e n a n c e
instructions included.

• Read, understand and follow

these instructions for safe
installation and operation.

In the Commonwealth of Massachusetts installation must be
performed by a licensed plumber or gas fi tter.

See Table of Contents for location of additional Commonwealth
of Massachusetts requirements.

This appliance has been supplied with an integral barrier
to prevent direct contact with the fi xed glass panel. DO
NOT operate the appliance with the barrier removed.

Contact your dealer or Hearth & Home Technologies if the
barrier is not present or help is needed to properly install one.

HOT SURFACES

!

Glass and other surfaces are hot during
operation AND cool down.

Hot glass will cause burns.

•

DO NOT

touch glass until it is cooled

• NEVER allow children to touch glass
• Keep children away

• CAREFULLY SUPERVISE children in same room as

fi replace.

• Alert children and adults to hazards of high temperatures.

High temperatures may ignite clothing or other fl ammable
materials.

• Keep clothing, furniture, draperies and other fl ammable

materials away.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Listing Label Information/Location; This owner ’s manual; Homeowner Reference Information; Model Number; XXXXXXXX; Read this manual before installing or operating this appliance.

Heat & Glo • ST-36TR-IPI, PIER-36TR-IPI • 2176-900 Rev. F • 8/11 2 Listing Label Information/Location Model Name: ___________________________________________ Date purchased/installed: __________________ Serial Number: __________________________________________ Location on fi replace: ___________...

Page 3 - Safety Alert Key:; • NOTICE: Used to address practices not related to personal injury.; Table of Contents; User Guide

Heat & Glo • ST-36TR-IPI, PIER-36TR-IPI • 2176-900 Rev. F • 8/11 3 Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. •...

Page 6 - This warranty is void if:; QRWOLPLWHGWRLPSURSHUFKLPQH\RUYHQWLQJLQVWDOODWLRQ; LIMITATIONS OF LIABILITY:; DWLRQRIJODVV

Heat & Glo • ST-36TR-IPI, PIER-36TR-IPI • 2176-900 Rev. F • 8/11 6 B. Limited Lifetime Warranty (continued) 4021-645C 12-29-10 Page 2 of 2 WARRANTY CONDITIONS: ‡ 7KLVZDUUDQW\RQO\FRYHUV++7DSSOLDQFHVWKDWDUHSXUFKDVHGWKURXJKDQ++7DXWKRUL]HGGHDOHURUGLVWULEXWRU$OLVWRI ++7DXWKRUL]HGGHDOHUVLVDYDLODEOHRQW...

Other Heat & Glo Models

All Heat & Glo Other