Heat & Glo RCOR-HV-IPI - Manual
Heat & Glo RCOR-HV-IPI – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Installers Guide; DO NOT; Owners Guide; ALERTED; Safety and Warning Information
- Page 3 – Table of Contents
- Page 4 – Log Assembly; Service Parts; Grate
- Page 5 – ITEM; supply serial and model numbers to ensure correct service parts.
- Page 8 – Part number list on following page.
- Page 13 – Appliance Certification; The Heat & Glo fireplace models discussed in this; Certification; Underwriters Laboratories; Installation Codes
- Page 14 – The following requirements reference various; G. Requirements for the Commonwealth of
- Page 15 – Getting Started; Introducing the Heat & Glo Gas Fireplaces; Pre-install Preparation; Do not install any
- Page 19 – Installing the Fireplace; Step 1. Locating the Fireplace; Fireplace Locations/Dimensions with
- Page 20 – Step 2. Framing the Fireplace
- Page 21 – Model; Framing Dimensions
- Page 23 – Step 3. Installing the Vent System
- Page 24 – On vertical venting; Flue Restrictor Instructions; BREAK; . Center the Flue Restrictor on vent and secure in; CAP; Match the amount of; Vertical; FLUE
- Page 26 – Figure 15. Venting with Two 90° Elbows
- Page 27 – Figure 17. Venting with Two 90° Elbows
- Page 28 – Figure 18. Venting with three 90° elbows
- Page 29 – Figure 19. Venting with three 90° elbows; NATURAL GAS
- Page 30 – Venting Out Vertically
- Page 32 – For Horizontal Terminations -
- Page 33 – = AREA WHERE TERMINAL IS NOT PERMITTED; Figure 29. Vent Termination Minimum Clearances; public; N O T E 3
- Page 35 – Step 5. The Gas Control System; Figure 32. Gas Control System; IPI PILOT; THE FIREPLACE JUNCTION BOX IN A IPI SYSTEM.
- Page 36 – Pressure; Figure 33. Gas Supply Line
- Page 37 – Appliance Requirements; Note; WARNING
- Page 39 – Figure 38. Junction Box Wired to Wall Switch; Wall Switch Installation for Fan (Optional)
- Page 40 – materials may be used to cover the black fireplace front.; F. MINIMUM SEALANT MATERIAL; Hearth Extensions; r e q u i r e h e a r t h; Figure 41. Sealant Material
- Page 41 – overlap onto the front face. The joints; FULL OPEN
- Page 43 – Placing the Ember Material; To place the ember material:; NOT; Replace the glass door and a front trim door on the unit.; Figure 50. Placement of the Ember Material
- Page 44 – Step 11. Before Lighting the Fireplace; Step 12. Lighting the Fireplace
- Page 45 – Maintaining and Servicing Your Fireplace; Fireplace Maintenance; Placing Ember Material
Heat & Glo • PIER-HV-IPI, ST-HV-IPI, L&R-COR-HV-IPI • 2005-900 Rev. K • 11/06
1
Models:
Pier-HV-IPI
ST-HV-IPI
LCOR-HV-IPI
RCOR-HV-IPI
In the Commonwealth of Massachusetts:
• installation must be performed by a licensed
plumber or gas fitter;
See Table of Contents for location of additional
Commonwealth of Massachusetts requirements.
- Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
-
What to do if you smell gas
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.
W A R N I N G : I M P R O P E R I N S TA L L A -
TION, ADJUSTMENT, ALTERATION,
S E R V I C E O R M A I N T E N A N C E C A N
CAUSE INJURY OR PROPERTY DAM-
AGE. REFER TO THIS MANUAL. FOR
ASSISTANCE OR ADDITIONAL INFOR-
MATION CONSULT A QUALIFIED IN-
STALLER, SERVICE AGENCY, OR THE
GAS SUPPLIER.
READ THIS MANUAL BEFORE INSTALLING OR
OPERATING THIS APPLIANCE. THIS
INSTALLERS
GUIDE
MUST BE LEFT WITH APPLIANCE FOR
FUTURE REFERENCE.
1. This appliance may be installed in an af-
termarket, permanently located, manufac-
tured (mobile) home, where not prohibited
by local codes.
2. This appliance is only for use with the type
of gas indicated on the rating plate. This
appliance is not convertible for use with
other gases, unless a certified kit is used.
Please contact your Heat & Glo dealer with any
questions or concerns. For the location of your nearest
Heat & Glo dealer, please visit www.heatnglo.com.
Printed in U.S.A. Copyright 2006
Heat & Glo, a brand of Hearth & Home Technologies Inc.
20802 Kensington Boulevard, Lakeville, MN 55044
WARNING: IF THE INFORMATION
IN THESE INSTRUCTIONS IS NOT
FOLLOWED EXACTLY, A FIRE OR
EXPLOSION MAY RESULT CAUS-
ING PROPERTY DAMAGE, PER-
SONAL INJURY, OR DEATH.
Owner’s Manual
Installation and Operation
This product may be covered by one or more of the following patents: (United States) 4593510, 4686807, 4766876, 4793322, 4811534, 5000162, 5016609, 5076254, 5113843, 5191877, 5218953, 5263471,
5328356, 5341794, 5347983, 5429495, 5452708, 5542407, 5601073, 5613487, 5647340, 5688568, 5762062, 5775408, 5890485, 5931661, 5941237, 5947112, 5996575, 6006743, 6019099, 6048195, 6053165,
6145502, 6170481, 6237588, 6296474, 6374822, 6413079, 6439226, 6484712, 6543698, 6550687, 6601579, 6672860, 6688302B2, 6715724B2, 6729551, 6736133, 6748940, 6748942, 6769426, 6774802,
6796302, 6840261, 6848441, 6863064, 6866205, 6869278, 6875012, 6880275, 6908039, 6919884, D320652, D445174, D462436; (Canada) 1297749, 2195264, 2225408, 2313972; (Australia) 780250,
780403, 1418504 or other U.S. and foreign patents pending.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Heat & Glo • PIER-HV-IPI, ST-HV-IPI, L&R-COR-HV-IPI • 2005-900 Rev. K • 11/06 2 These units MUST use one of the vent systems described in the Installing the Fireplace section ofthe Installers Guide . NO OTHER vent systems or components MAY BE USED . This gas fireplace and vent assembly MUST ...
Heat & Glo • PIER-HV-IPI, ST-HV-IPI, L&R-COR-HV-IPI • 2005-900 Rev. K • 11/06 3 Table of Contents Safety and Warning Information .................................................. 2 Service Parts List ......................................................................... 4 Approvals and C...
Heat & Glo • PIER-HV-IPI, ST-HV-IPI, L&R-COR-HV-IPI • 2005-900 Rev. K • 11/06 4 6 Log Assembly (NG, LP) Exploded Parts Diagram Service Parts Pier-HV-IPI Beginning Manufacturing Date: 6-03Ending Manufacturing Date: ______ 5 2 1 3 4 Grate Bar
