Harman TL 300 - Manual - manualsarea.com

Page 3 - Please read this entire manual before you install and use your new; index; 52 Mountain House Road

3 Harman TL300 Please read this entire manual before you install and use your new heating appliance. Failure to follow instructions may result in property damage, bodily injury, or even death. index hearth & home Technologies, inc. 352 Mountain House Road Halifax, PA 17032 ~ U.S.A. Introduction ...

Page 4 - introduction; appliance certification.

4 Harman TL300 Prevention des incendies: Respectez scrupuleusement les instructions du constructeur pour l’installation et l’utilisation. Respectez les regles et normes applicables dans votre region. Dans tous les cas, l’installation devra au minimum satisfaire aux exigences de NFPA 211 AUX Etats-Un...

Page 5 - for wood heaters sold after July 1, 1990.; Specifications; SaFeTY noTice: iF ThiS STove iS noT ProPerLY inSTaLLed, a houSe Fire

5 Harman TL300 The Harman TL300 meets the U.S. Environmental Protection Agency’s emission limits for wood heaters sold after July 1, 1990. Specifications Weight 525 lbs Flue Size 6 Inch Log Length Recommended 18 in. / 20 in. Max Heating Capacity 1,500 - 3,000 sq. ft. Average Emissions 1.1 Grams Per ...

Page 7 - do not burn garbage or flammable fluids; never oPeraTe WiTh More Than one; always wear fire retardant gloves

Harman TL300 7 The Stove doors Your stove has a large glass-paneled door for loading and fire viewing, a separate smaller door for removing ashes, and a top loading door. Front door Before opening, always check for wood, embers, or ash that may be ready to fall out of the door. To open the glass doo...

Page 8 - noTe; Floor Protection; installation; Mobile home installation; MobiLe hoMe reguLaTionS do noT

8 Harman TL300 clearances Clearance is the empty space required between the stove or chimney connector and the nearest combustible surface or object, such as walls, ceilings, floors, or furniture. Clearance distances may only be reduced by using methods approved by either the CAN/CSA B365 standard (...

Page 9 - installation/clearances; Single Wall Pipe - Top Vent - Parallel Installation

9 Harman TL300 *Check with your local building codes for clearance. Single Wall Pipe - Parallel installation Single W all Pipe installation/clearances Top Vent to vented out side wall with 90 o elbow Top vent vented out back wall with 90 o elbow. 23" 17" 15"* 2' 31" 17" 23" T...

Page 10 - venting; chimney connectors and chimneys; draft; chimney connectors

10 Harman TL300 venting chimney connectors and chimneys draft Draft is widely misunderstood. It is important that you, the stove operator, realize that draft is a variable effect , not a given quantity. Stoves and chimneys do not have draft, yet draft is the key to your stove’s performance. Draft is...

Page 11 - The chimney; Do not connect this unit to a chimney; AN APPROVED CANADIAN WALL

11 Harman TL300 venting The chimney The TL300 must be installed into a chimney approved for use with solid-fuel appliances. In the U.S., the TL300 must be connected to (1) a prefabricated chimney complying with the requirements for Type HT chimneys in the Standard for Chimneys, Factory-Built, Reside...

Page 12 - installing to a Prefabricated chimney; Do not connect to any air distribution; existing Masonry chimneys; The Harman TL300 was tested with the fuel

12 Harman TL300 Do not burn any fuel other than wood, such as charcoal, which can cause increased carbon monoxide production or overfiring. Never use highly volatile substances in your stove, such as gasoline, which could cause an explosion. When solid fuels are burned completely, they produce water...

Page 13 - Standard ceiling installation with

13 Harman TL300 venting Standard ceiling installation with Factory built chimney cathedral ceiling installation with Factory built chimney

Page 14 - chimney breach Fireplace conversion with non-combustible Wall

14 Harman TL300 venting Minimum clearance to unprotected ceiling 18" chimney connector Sealed at Thimble Flue Liner with required air Space Minimum of three Sheet Metal Screws per joint of chimney connector Mantel and Trim Protection * Floor Protection in accordance with Solid Fuel appliance Lis...

Page 15 - chimney breach Fireplace conversion with combustible Wall

15 Harman TL300 venting chimney breach Fireplace conversion with combustible Wall M i n i m u m c l e a r a n c e f r o m c h i m n e y c o n n e c t o r t o unprotected ceiling Flue Liner with required air Space Listed or approved Thimble assembly 1" clearance for exterior chimney or 2" cle...

Page 16 - operation; The combustion Process; Top loading door handle/damper interlock.; Top Load door open

Harman TL300 16 Combustion in the Harman TL300 is precisely controlled and is divided into two parts. During combustion, primary air enters at the bottom front of the stove and travels up channels at either side of the front door. This pre-heated air then enters the manifold, located above the front...

Page 17 - building a Fire; building and Maintaining the Fire; Minimum

Harman TL300 17 building a Fire Begin with the bypass damper open, and the air control lever at the maximum setting, all the way to the right. Be sure the ash pan door is closed and latched. Start with a bed of crumpled paper and kindling sized about finger width; place several 1" - 2" (25mm...

Page 18 - Avoid overfiring your stove.; Building and Maintaining the Fire Cont.; As you begin to operate your stove at higher; CAUTION; CAUTION: Always wear fire-resistant gloves

Harman TL300 18 building a Fire Always remember to open the bypass damper when you are loading, this allows the exhaust gases to pass directly into the flue outlet and reduces the chance of smoke spillage into the room. Reloading: Once you have prepared and maintained a thick charcoal bed, and the s...

Page 19 - do not; Maintenance; Surface; noTe: be sure not to insert anything such as a

19 Harman TL300 glass - cleaning S o m e t i m e s i t w i l l b e n e c e s s a r y t o c l e a n accumulated ash from the glass surface; allowing this ash to remain on the glass for long periods can result in “etching” due to the acidity of the ash. The creosote which accumulates on the glass shou...

Page 20 - The chimney System; creosote; when properly burned with dry; amper ramp adjustment; To adjust the ramp, the stove MuST be allowed; gaskets

20 Harman TL300 The chimney System creosote When wood is burned slowly, it produces tar and other organic vapors, as well as soot, which combine with expelled moisture to form creosote. The creosote vapors condense in the relatively cool chimney flue (associated with a slow burning fire). As a resul...

Page 21 - options

Harman TL300 21 cooking grill- #1-00-08121 The TL300 offers a unique stainless steel cooking grill that can easily be taken in and out of the stove for easy cleaning. n o t e : P l e a s e u s e h e a t r e s i s t a n t g l o v e s w h e n handling the cooking grill. Surfaces will be hot enough to ...

Page 23 - Service Parts; Stocked

Service Parts 02/12 TL300 beginning Manufacturing date: aug. 2007 ending Manufacturing date: active IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from...

Page 24 - #18 damper arm assembly; #17 air Slide assembly

Service Parts 02/12 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. Stocked at depot iTeM deScriPTion coMMenTS ParT nuMber 15...

Page 26 - This page intentionally left blank.

26 Harman TL300 This page intentionally left blank.

Page 27 - LIMITED LIFETIME WARRANTY

4021-645C 12-29-10 Page 1 of 2 Hearth & Home Technologies Inc. LIMITED LIFETIME WARRANTY Hearth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT autho...

Page 29 - notes

Page 32 - Proudly Printed On 100% Recycled Paper

Proudly Printed On 100% Recycled Paper At Harman, we build each product to a standard, not a price.This powerful heating appliance boasts uncompromising attention to detail and helps preserve our planet by using environmentally responsible fuels. (Signature of Boxer) Your premium quality hearth prod...

Harman TL 300 - Manual

Table of Contents:

Summary

Other Harman Models