Harman TL 300 - Manuals

Harman TL300 7 The Stove doors Your stove has a large glass-paneled door for loading and fire viewing, a separate smaller door for removing ashes, and a top loading door. Front door Before opening, always check for wood, embers, or ash that may be ready to fall out of the door. To open the glass doo...

8 Harman TL300 clearances Clearance is the empty space required between the stove or chimney connector and the nearest combustible surface or object, such as walls, ceilings, floors, or furniture. Clearance distances may only be reduced by using methods approved by either the CAN/CSA B365 standard (...

9 Harman TL300 *Check with your local building codes for clearance. Single Wall Pipe - Parallel installation Single W all Pipe installation/clearances Top Vent to vented out side wall with 90 o elbow Top vent vented out back wall with 90 o elbow. 23" 17" 15"* 2' 31" 17" 23" T...

10 Harman TL300 venting chimney connectors and chimneys draft Draft is widely misunderstood. It is important that you, the stove operator, realize that draft is a variable effect , not a given quantity. Stoves and chimneys do not have draft, yet draft is the key to your stove’s performance. Draft is...

11 Harman TL300 venting The chimney The TL300 must be installed into a chimney approved for use with solid-fuel appliances. In the U.S., the TL300 must be connected to (1) a prefabricated chimney complying with the requirements for Type HT chimneys in the Standard for Chimneys, Factory-Built, Reside...

12 Harman TL300 Do not burn any fuel other than wood, such as charcoal, which can cause increased carbon monoxide production or overfiring. Never use highly volatile substances in your stove, such as gasoline, which could cause an explosion. When solid fuels are burned completely, they produce water...

13 Harman TL300 venting Standard ceiling installation with Factory built chimney cathedral ceiling installation with Factory built chimney

14 Harman TL300 venting Minimum clearance to unprotected ceiling 18" chimney connector Sealed at Thimble Flue Liner with required air Space Minimum of three Sheet Metal Screws per joint of chimney connector Mantel and Trim Protection * Floor Protection in accordance with Solid Fuel appliance Lis...

15 Harman TL300 venting chimney breach Fireplace conversion with combustible Wall M i n i m u m c l e a r a n c e f r o m c h i m n e y c o n n e c t o r t o unprotected ceiling Flue Liner with required air Space Listed or approved Thimble assembly 1" clearance for exterior chimney or 2" cle...

Harman TL300 16 Combustion in the Harman TL300 is precisely controlled and is divided into two parts. During combustion, primary air enters at the bottom front of the stove and travels up channels at either side of the front door. This pre-heated air then enters the manifold, located above the front...

Harman TL300 17 building a Fire Begin with the bypass damper open, and the air control lever at the maximum setting, all the way to the right. Be sure the ash pan door is closed and latched. Start with a bed of crumpled paper and kindling sized about finger width; place several 1" - 2" (25mm...

Harman TL300 18 building a Fire Always remember to open the bypass damper when you are loading, this allows the exhaust gases to pass directly into the flue outlet and reduces the chance of smoke spillage into the room. Reloading: Once you have prepared and maintained a thick charcoal bed, and the s...

19 Harman TL300 glass - cleaning S o m e t i m e s i t w i l l b e n e c e s s a r y t o c l e a n accumulated ash from the glass surface; allowing this ash to remain on the glass for long periods can result in “etching” due to the acidity of the ash. The creosote which accumulates on the glass shou...

20 Harman TL300 The chimney System creosote When wood is burned slowly, it produces tar and other organic vapors, as well as soot, which combine with expelled moisture to form creosote. The creosote vapors condense in the relatively cool chimney flue (associated with a slow burning fire). As a resul...

Harman TL300 21 cooking grill- #1-00-08121 The TL300 offers a unique stainless steel cooking grill that can easily be taken in and out of the stove for easy cleaning. n o t e : P l e a s e u s e h e a t r e s i s t a n t g l o v e s w h e n handling the cooking grill. Surfaces will be hot enough to ...

Service Parts 02/12 TL300 beginning Manufacturing date: aug. 2007 ending Manufacturing date: active IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from...

Service Parts 02/12 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. Stocked at depot iTeM deScriPTion coMMenTS ParT nuMber 15...

26 Harman TL300 This page intentionally left blank.

4021-645C 12-29-10 Page 1 of 2 Hearth & Home Technologies Inc. LIMITED LIFETIME WARRANTY Hearth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT autho...

Proudly Printed On 100% Recycled Paper At Harman, we build each product to a standard, not a price.This powerful heating appliance boasts uncompromising attention to detail and helps preserve our planet by using environmentally responsible fuels. (Signature of Boxer) Your premium quality hearth prod...