Page 3 - Contents; SAVE THESE INSTRUCTIONS
1 Contents Safety and warnings 2 Installation instructions 8 First use 21 Setting the clock 22 Using your oven 23 Cooking functions 26 Cooking guide 28 Using the rotisserie 30 Using the electronic timer 32 Automatic cooking 33 Using your gas cooktop 34 Care and cleaning 38 Using the Self Clean funct...
Page 4 - Safety and warnings; Electrical Shock Hazard; Important safety instructions; General; These products are registered:; Installation; Cut Hazard
2 Safety and warnings WARNING! Electrical Shock Hazard Always disconnect the cooker from the mains electricity supply before carrying out any maintenance operations or repairs. Failure to follow this advice may result in death or electrical shock. Important safety instructions General To avoid hazar...
Page 5 - Electrical; installed in the active (phase) conductor of the fixed wiring.; Power
3 Electrical This cooker is to be installed and connected to the electricity supply only by an authorised person. If the installation requires alterations to the domestic electrical system, call a qualified electrician. The electrician should also check that the electrical system is suitable for the...
Page 6 - Operation; Hot Surface Hazard
4 Operation Your freestanding cooker has been carefully designed to operate safely during normal cooking procedures. Please keep the following guidelines in mind when you are using it: Safety and warnings WARNING! Hot Surface Hazard Accessible parts may become hot when this cooker is in use.To avoid...
Page 7 - Do not line the walls with aluminium foil.
5 Safety and warnings Important safety instructions Never leave the appliance unattended when in use. Boilover causes smoking and greasy spillovers that may ignite. Isolating switch: make sure this cooker is connected to a circuit which incorporates an isolating switch providing full disconnection f...
Page 9 - Always keep oven vents unobstructed.
7 Operation Safety and warnings Important safety instructions Never leave the appliance unattended when in use. Boilover causes smoking and greasy spillovers that may ignite. Wear proper apparel. Do not wear loose fitting or hanging garments when using the appliance. They could ignite or melt if the...
Page 10 - Dimensions and clearances; Overhead Clearances; Installation instructions
8 Dimensions and clearances Installation clearances and protection of combustible surfaces shall comply with the current local regulations eg. AS/NZS5601.1:2010 Gas Installations code. Installation shall comply with the dimensions in Fig. 1, bearing in mind the following requirements: Overhead Clear...
Page 11 - • height:; • cavity width; Locating the area for gas and electrical connection
9 200 mm 750 mm 500 mm 450 mm Installation instructions Cooker overall dimensions [mm] • height: min 897 - max 910 • product width: 897• depth: 600 • cavity width 900 Fig. 1 Dimensions and distances from cooker 240 mm (*) 450 mm (*) (*) Depending on feet adjustment 70 mm 70 mm Locating the area for ...
Page 12 - Levelling the cooker
10 Installation instructions Installation instructions + 8 0 mm + 8 mm + 1 3 mm Levelling the cooker Important! Using the supplied adjustable feet is MANDATORY. For safety reasons and to ensure adequate ventilation, the cooker chassis MUST NOT sit directly on the floor, a plinth, or other support su...
Page 13 - Fitting the anti-tilt bracket
11 Installation instructions Dotted line showing the position of the cooker when installed Rear left foot of cooker Anti-tilt bracket Fitting the anti-tilt bracket Important! To restrain the appliance and prevent it tipping accidentally, the anti-tilt bracket and restraining plate supplied must be f...
Page 14 - Moving the cooker; Fixing the backguard; Before assembling, remove any protective
12 Installation instructions Installation instructions Important! To prevent damaging the adjustable feet or lower trim, ensure the cooker is always lifted by two people. Do not lift the cooker by the door handles.DO NOT DRAG the cooker. Lift the feet clear of the floor. Take extra care not to damag...
Page 15 - Connecting the cooker to the gas supply; Installation with a flexible hose assembly
13 Installation instructions Connecting the cooker to the gas supply The gas connection must be carried out by an authorised person according to the relevant standards. Before connecting the appliance to the gas main, mount the brass conical adaptor onto the gas inlet pipe, upon which the washer has...
Page 16 - Gas connection for; Fitting the brass conical adaptor
14 Installation instructions Gas connection for LPG Gas connection for NATURAL GAS Gas inlet pipe Nipple Washer Brass conical adaptor (Thread tight: use suitable seal) Gas inlet pipe Nipple Washer Brass conical adaptor (Thread tight: use suitable seal) Gas pressure regulator Test point adaptor Testp...
Page 17 - Leak-testing and flame-testing the cooker; Do not use a naked flame to test for leaks.; Converting to a different gas type; Replacing the injectors; Remove the pan supports and burners from the cooktop.; Adjusting the minimum burner setting; See ‘Adjusting the minimum burner setting’ for instructions.
15 Leak-testing and flame-testing the cooker After installing the freestanding cooker and connecting the gas supply: 1 Using a suitable leak detection fluid solution, check each gas connection one at a time by brushing the solution over the connection. The presence of bubbles will indicate a leak. I...
Page 18 - Injector
16 J Injectors forouter crown J Injector for nner crown J Installation instructions Injector Fig. 15 Semi-rapid burner Fig. 16 Triple-ring wok burner Fig. 17 Dual burner Injector Injectors forouter crown Injector for inner crown
Page 19 - Inside crown of dual burner:; regulation scre
17 Installation instructions Adjusting the minimum burner setting Check whether the flame spreads to all burner ports when the burner is lit with the gas valve set to the minimum position. If some ports do not light, increase the minimum gas rate setting. Check whether the burner remains lit even wh...
Page 21 - Wiring diagram; GIR
19 Installation instructions Wiring diagram ELECTRIC DIAGRAM KEY F1 Oven switch ST Safety thermostat STL Safety thermal overload TL Thermal overload PR Electronic programmer PB T e mperature probe TS Oven temperature selector EC Oven function selector (encoder) SF State functions DL Door lock device...
Page 23 - First use
21 First use Fig. 20 Control panel - OR90SDBGFPX 1 Control buttons 2 Clock display 3 Temperature dial 4 Function dial 5 Front left (triple-ring wok) burner dial 6 Rear left (semi-rapid) burner dial 7 Central (dual) burner dial 8 Rear right (semi-rapid) burner dial 9 Front right (triple-ring) burner ...
Page 24 - Buttons; See instructions below.; To set the clock
22 First use Fig. 21 Clock display and control buttons Buttons sets the timer sets the cooking time sets the stop time for automatic cooking set the oven temperature / select Celsius or Fahrenheit decreases the time and temperature increases the time and temperature sets the Self Clean time starts t...
Page 25 - Using your oven; Guard rail
23 Using your oven Before using your new oven, please: 1 Read this user guide, taking special note of the ‘Safety and warnings’ section. 2 Remove all accessories and packaging. Peel the protective film off all surfaces and accessories. 3 Set the clock. The oven will not work until the clock has been...
Page 26 - dEF
24 Using your oven 210 C 225 C Fig. 23 Function and temperature dials FUNCTION TEMPERATURE 1 Select a function Rotate the function dial to select a function The function indicator light will come on. The preset function temperature will flash in the display. (Each cooking function has a preset tempe...
Page 27 - When you have finished cooking
25 Using your oven C 89 FUNCTION 3 When the oven is preheating and during cooking The indicator will show in the display. The indicator will go out when the oven has reached the set temperature. Note: this indicator may turn on and off during cooking as the oven maintains the set temperature. 5 When...
Page 28 - Cooking functions; this is not a cooking function
26 Cooking functions OVEN LAMP Only the oven light comes on. It remains on in all the cooking functions. DEFROST this is not a cooking function Only the oven fan comes on. The fan circulates air around the oven, speeding up the defrosting process by approximately 30%. Note: this function is not for ...
Page 29 - ROTISSERIE
27 Cooking functions ROTISSERIE A delicious way to cook meat and poultry. The slowly rotating meat is basted continuouslyin its own juices, making it tender on the inside and well browned and full of flavour on theoutside. See ‘Using the rotisserie’. SELF CLEAN this is not a cooking function The ove...
Page 30 - Cooking guide; Changing the oven from Celsius to Fahrenheit
28 Cooking guide Changing the oven from Celsius to Fahrenheit You can set your oven to display the temperature in Fahrenheit or Celsius. 1 Select a cooking function. 2 While the display is flashing, press to reduce the oven to the minimum temperature (50 o C / 120 o F). 3 When the display stops flas...
Page 31 - SAVOURY
29 Cooking guide SAVOURY BAKING Food Shelves Recommended Function Shelf positions Temp (°C) Time (mins) Roast Chicken Rotisserie Rotisserie 1 180-210 15-20 min/450g Lasagne Single Fan Bake 3 175-180 45-50 Quiche Single Pastry Bake 1 180-200 30-40 Pizza Single Pastry Bake 3 225-250 10-15 Casserole Si...
Page 32 - Using the rotisserie; Remove all oven shelves and trays.; Prepare the rotisserie supports.; Lock stud
30 Using the rotisserie Fig. 24b Secure the meat Fig. 24a Prepare the rotisserie supports Important! If fitted, remove the sliding shelf supports from shelf position 1 before using the rotisserie. Remove all oven shelves and trays. 1 Prepare the rotisserie supports. Place the grill tray on the bench...
Page 33 - Always ensure that poultry is cooked thoroughly.; Rotisserie drive hole
31 Using the rotisserie Fig. 24e Place the rotisserie in the oven Fig. 24c Position the skewer on the supports Fig. 24d Rotisserie drive hole cover 3 Position the skewer on the supports. Place the skewer on the supports, and check that the meat does not touch the grill tray. Twist the handle off. It...
Page 34 - Using the electronic timer; The timer does NOT turn the oven off.; To set the timer; To check the remaining time
32 Using the electronic timer You can use the timer at any time, even whenthe oven is not in use. Important! The timer does NOT turn the oven off. To set the timer 1 Press the timer button. The time will show 0:00. 2 Press and buttons to set the time you want (up to 3 hours in one minute steps). The...
Page 35 - Automatic cooking; To set the oven for automatic cooking; Set the oven; End
33 Automatic cooking To set the oven for automatic cooking 1 Set the oven Check the clock shows the correct time (eg 12:07). Select the function and set the temperature. The oven will turn on. 2 Set the cooking time Decide how long the food will take to cook, allowing time for preheating if necessar...
Page 36 - Using your gas cooktop; Gas burners; Dual burner
34 Using your gas cooktop Gas burners The dial controls the flow of gas through the safety valve. Semi-rapid and triple-ring wok burners o = closed valve (OFF) = maximum flow of semi-rapid and triple-ring burner burners = minimum flow of semi-rapid and triple-ring burner burners You can choose to co...
Page 37 - Before using your cooktop
35 Using your gas cooktop Before using your cooktop Before using your new cooktop, please: Read this user guide, taking special note of the ‘Safety and warnings’ section. Make sure all burner control dials are turned off. Turn the power to the cooker on at the wall. Using the gas burners 1 Choose th...
Page 39 - The wok stand fits over the dual and triple ring burner pan support.; Burners; Maximum diameter for woks 36 cm; WRONG
37 Matching cookware to burner Use flat-bottomed pans, and make sure they match the size of the burner, as shown in the following table. A small pot on a large burner is not efficient. Diameters of pans which may be used on the cooktop Wok stand The wok stand fits over the dual and triple ring burne...
Page 40 - General advice; Wipe down the cooktop and wipe out the oven after every use.; Cleaning the outside of the cooker; Maintenance Period; Daily; Care and cleaning
38 Important! Before you start cleaning your cooker, please: Read these cleaning instructions and the ‘Safety and warnings’ section at the start of this user guide. Turn the cooker off at the wall. Make sure the cooker is a safe temperature to touch. Do not use a steam cleaner. Do not keep flammable...
Page 41 - Burner parts and pan supports
39 Care and cleaning S F C T Cap Ignitor Flame spreader Fig. 31 Replacing the semi-rapid burner caps Fig. 30 Correct line-up of semi-rapid burner parts Probe Burner parts and pan supports You can remove and clean these parts with hot soapy water or non-abrasive detergents. Clean spills regularly bef...
Page 42 - Replacing the triple-ring wok and dual burners
40 A B S T Care and cleaning Replacing the triple-ring wok and dual burners Carefully replace the burner parts as per the following Figs. Fit the flame spreader to the housing as shown by the arrow in the Figs.32a-32b. Make sure the burner is not able to rotate (Fig. 33). Check that: the ignitor is ...
Page 43 - Cleaning the inside of your oven; Do not use abrasive cleaners, cloths or pads to clean the enamel.; Removing the side racks; Slide the side rack clear of the rear lock stud and remove.; Refitting the side racks
41 Care and cleaning Cleaning the inside of your oven Note: if using the Self Clean function remove all shelves and side racks first. See ‘Using the Self Clean function’. Do not use abrasive cleaners, cloths or pads to clean the enamel. Removing the side racks 1 Using a small coin or a flat-head scr...
Page 44 - Cleaning the enamel cavity; they are between the two wires of a shelf position
42 Care and cleaning Cleaning the enamel cavity Clean the enamel on the inside of the oven when it has cooled down, using household detergents. You may use ‘off the shelf ’ oven cleaners, if you carefully follow the manufacturers’ instructions. Cleaning the grill tray and shelves Clean these in hot,...
Page 45 - Fitting and removing the sliding shelf supports; When fitting the sliding shelf supports, make sure that you fit:
43 Care and cleaning Fitting and removing the sliding shelf supports When fitting the sliding shelf supports, make sure that you fit: the side racks the slides to the top wire of a shelf position both sides of each pair of slides both slides on the same level. Important! Remove the side racks first ...
Page 46 - Storage Drawer; To remove the drawer; Open the drawer fully.; Replace the drawer; Insert the drawer rails into the guide rails.
44 Care and cleaning Storage Drawer The drawer opens like a normal drawer. The drawer slides prevent the drawer from sliding out. To remove the drawer 1 Open the drawer fully. 2 Press the lever on the left guide rail down and the right guide rail up. 3 Holding the levers, disengage and remove the dr...
Page 47 - Replacing the oven light bulbs; Note: oven bulb replacement is not covered by your warranty.
45 Care and cleaning Replacing the oven light bulbs The oven light bulbs (12V/20 W halogen) have a very long life, but if you should need to replace one, use only a replacement bulb purchased from your nearest Fisher & Paykel dealer and follow these steps. Note: oven bulb replacement is not cove...
Page 48 - Removing and replacing the door glass panes for cleaning.; Switch the oven off at the wall before removing the door.
46 Care and cleaning Removing and replacing the door glass panes for cleaning. Make sure you follow the precautions and instructions below very carefully. Replacing theglass panes and the door incorrectly may result in damage to the oven and may voidyour warranty. Your oven door has 4 panes of glass...
Page 49 - Removing the door; Open the door to its full extent.
47 Care and cleaning Removing the door 1a Turn the oven off at the wall. Make sure you have prepared enough space for resting the door and its glass panes on a clean, flat surface. 1b Open the door to its full extent. 2 Open the levers on the left and right hinges to their full extent, as shown. 3 G...
Page 50 - Remove the inner and middle glass panes; Press down on both tabs (
48 Care and cleaning Remove the inner and middle glass panes 1 Press down on both tabs ( 1 ) to release the glass retainer ( 2 ). 2 Lift the inner pane (D) slightly ( 1 ), then gently slide out ( 2 ). 1 2 1 2 Glass retainer 3 Slide the first middle pane (C) slightly towards yourself ( 1 ), then lift...
Page 51 - slightly towards yourself (; After cleaning, replace the glass panes; When replacing the glass panes, make sure that:
49 Care and cleaning Note - the two middle panes (B and C) are identical. 1 Take the middle pane (B) and hold it firmly. Insert it in the lowest pair of grooves ( 1 ), push it slightly towards yourself ( 2 ) and gently lower into place ( 3 ). 2 1 3 3 After cleaning, replace the glass panes When repl...
Page 54 - Refit the door; Hold the door firmly.
52 Care and cleaning Refit the door 1 Hold the door firmly. 3 Open the door to its full extent. 2 Insert the hinge tongues into the slots, making sure that the notches on both sides drop into place as shown. 4a Fully close the levers on the left and right hinges, as shown. 4b Close the door, turn th...
Page 56 - Using the Self Clean function
54 During the pyrolytic Self Clean cycle the extremely high temperature burns off and breaks down grime and grease deposits. All that is left is a small amount of grey ash that you can easily remove. You can set the Self Clean cycle time between one and a half and three hours. The heavier the soilin...
Page 57 - To start a Self Clean cycle; Wipe up any spills. Failure to do so may discolour the oven surfaces.
55 Using the Self Clean function To start a Self Clean cycle 1a Remove oven shelves, side racks and all other accessories, bakeware, and utensils. 1b Wipe up any spills. Failure to do so may discolour the oven surfaces. 1c Check the inner glass pane of the oven door (D). If it has soiling on it (eg ...
Page 58 - Fdor; To cancel a Self Clean cycle; hot
56 Using the Self Clean function 3 Select the Self Clean Function The display will show The P will flash 4 Adjust the cycle time (optional) You may set the time between 1-1/2 hours (P1:30 and 3 hours (P3:00). For normal soiling use a 3 hour cycle. For light or localised soiling decrease the time. Pr...
Page 59 - Troubleshooting; Problem; A burner does not light.; There are objectionable odours.; Call your service person to service the cooker.; There is an electricity failure.
57 Troubleshooting Problem Possible solutions A burner does not light. Check the cooker is switched on at the wall.Check the gas supply valve is turned on and the supply to the house is working. You should hear the gas when you turn a burner on.Check the gas bottle is not empty.The ignitors may be d...
Page 60 - The display shows; when
58 Troubleshooting Problem Possible solutions The oven door does not open after a Self Clean cycle. The oven is too hot for the door to beopened safely.When the oven has cooled to a safetemperature the door will automaticallyunlock and the door lock indicator will go out. The display shows 12.00 and...
Page 61 - Product details; Warranty and service
59 Before you call for service or assistance ... Check the things you can do yourself. Refer to the installation instructions and your user guide and check that: 1 Your product is correctly installed. 2 You are familiar with its normal operation. If after checking these points you still need assista...
Page 64 - NZ AU
NZ AU 04.2013 F&P PN - 590575 A F&P ITALY PN - 1104231-ß1 www.fi sherpaykel.com Copyright © Fisher & Paykel 2013. All rights reserved. The product specifications in this booklet apply to the specific products and models described at the date of issue. Under our policy of continuous produ...
