COZY HEDV404 - Manual
COZY HEDV404 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – CONTENTS; INTRODUCTION; SPECIFICATIONS AND DIMENSIONS
- Page 4 – VENT TERMINAL CLEARANCES; Vent Terminal
- Page 5 – Ceiling or Overhang
- Page 6 – 2” Minimum above grade
- Page 7 – INSTALLATION; Locate studs on each side of this area.; FIGURE 6; FIGURE 7
- Page 8 – INSTALLATION - CONTINUED; BRACKETS
- Page 9 – Temperature Sensing Unit
- Page 11 – Turn off all electrical supply to heater.
- Page 12 – WIRING; C wire or its equivalent.; WARNING
- Page 14 – CONTENTS OF KIT
- Page 15 – ELBOW KIT; Elbow 2”
- Page 17 – Flame too large
- Page 18 – TROUBLE SHOOTING CONTROL BOARD; Reason for Indication
- Page 19 – Prices and specifications subject
- Page 20 – Model Number HEDV403 HEDV404
- Page 21 – IMPORTANT SAFETY BULLETIN ON YOUR GAS CONTROL AND PILOT LIGHT; Do not try to light any appliance.
- Page 22 – LOUISVILLE TIN AND STOVE COMPANY
hi-efficient direct
vent wall furnace
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 72903 / December 2003
MODEL NUMBERS
NAT. GAS
L.P. GAS
HEDV403
HEDV404
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch any electrical switch; do not
use any phone in your building.
Immediately call your gas supplier from a
neighbor’s phone. Follow the gas
supplier’s instructions.
If you cannot reach your gas supplier, call
the fire department.
INSTALLER MUST LEAVE THESE INSTRUCTIONS
WITH THE CONSUMER, HAVE THEM COMPLETE,
AND RETURN THE WARRANTY CARD.
-
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
-
WHAT TO DO IF YOU SMELL GAS:
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use any
phone in your building.
•
Immediately call your gas supplier from a neighbor’s
phone. Follow the gas supplier’s instructions.
•
If you cannot reach your gas supplier, call the
fire department.
-
INSTALLATION AND SERVICE MUST BE PER-
FORMED BY A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER.
WARNING: Operation of this furnace without the properly installed, factory furnished vent system and
vent cap could result in Carbon Monoxide (CO) poisoning and possible death. For your safety, this
furnace and the vent system should be inspected at least annually by a qualified service person.
May be installed in an aftermarket, permanently located, manufactured home (mobile home) where not
prohibited by local codes. See owner’s manual for details. This appliance is not convertible for use
with other gases, unless a certified kit is used.
WARNING: If the information in these instructions are
not followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of life.
This unit is not approved for installation in greenhouses, or environments involving dusty, wet, corro-
sive, or explosive conditions. Such conditions will invalidate the warranty and may create unsafe
conditions.
R
R
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 Introduction…………………………….. 2 Specifications and Dimensions…………. 2 Safety Rules…………………………….. 3 Clearances………………………………. 4/5 Location………………………………… 6 Installation……………………………… 7 Lighting Instructions…………………… 10 Pilot Adjustment……………………….. 11 Burner Orifice………………………….. 11 Wiring Diagram………………………… 12...
REFERENCE LETTER TO DRAWING CANADIAN INSTALLATIONS¹ A = Clearance above grade, veranda, porch, deck, or balcony 12 Inches (30 cm) B = Clearance to window or door that may be opened 12 Inches (30 cm) C = Clearance to permanently closed window 12 Inches (30 cm) D = Vertical clearance to ventilated sof...
Page 5 CLEARANCES 1. As you face the heater, the clearance to a side wall on the right side is 0” (Fig. 1), and the left side is 1”(Fig. 2). 2. The minimum clearance from the top of the heater to the ceiling or any projecting overhang is 10”. (See Figure 3). 3. The minimum clearance from the bottom ...
