COZY DVCF557B-R - Manual
COZY DVCF557B-R – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – 4 VOLT SYSTEM WITH LOW-BTU STANDING PILOT
- Page 3 – SAFETY RULES; Do not attempt to extend vent pipes. 12 inches is maximum length.
- Page 4 – Vent Terminal; VENT TERMINAL CLEARANCES
- Page 5 – CLEARANCES
- Page 7 – FIGURE 6
- Page 8 – FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS:; LIGHTING INSTRUCTIONS
- Page 10 – INSPECTION AND CLEANING; PROPER BURNER FLAME
- Page 12 – AMPS
- Page 13 – TERMINAL BLOCK WIRING DIAGRAM; MAINTENANCE INSTRUCTION
- Page 14 – SIDE
- Page 15 – 4-PEK KIT INSTRUCTIONS; ALL; UNITS WITH TERMINAL BOARD
- Page 16 – TROUBLE SHOOTING CHART
- Page 17 – TROUBLE SHOOTING CHART - Continued; SERVICE RECORD; SYMPTOM
- Page 18 – DIRECT VENT COUNTERFLOW WALL FURNACE; THERMOSTAT
- Page 19 – HOW TO PROPERLY ORDER PARTS
- Page 22 – TABLE A; LOUISVILLE TIN AND STOVE COMPANY; LIMITED WARRANTY
DIRECT VENT
COUNTERFLOW
WALL FURNACE
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 72900 - REV. 12/03
MODEL NUMBERS
NAT. GAS DVCF407B-R DVCF557B-R
L.P. GAS DVCF408B-R DVCF558B-R
WARNING: If the information in this manual is not followed
exactly, a fire or explosion may result causing property damage,
personal injury or loss of life.
MODEL NUMBERS
NAT. GAS DVCF403B-R DVCF653B-R
L.P. GAS DVCF404B-R DVCF654B-R
24 VOLT SYSTEM WITH LOW-BTU PILOT
24 VOLT SYSTEM W/INTERMITTENT IGNITION (IID)
INSTALLER MUST LEAVE THESE
INSTRUCTIONS WITH THE CONSUMER
HAVE THEM COMPLETE,AND RETURN
THE WARRANTY CARD.
The coating selected to provide longer life to
the heat exchanger may smoke slightly upon
initial firing. Please provide adequate
ventilation if this ocurs.
WARNING: Operation of this furnace without the properly installed, furnished vent system and vent cap
could result in Carbon Monoxide (CO) poisoning and possible death. For your safety, this furnace and the
vent system should be inspected at least annually by a qualified service person.
This unit is not approved for installation in greenhouses, or environments involving dusty, wet,
corrosive, or explosive conditions. Such conditions will invalidate the warranty and may create
unsafe conditions.
-
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
-
WHAT TO DO IF YOU SMELL GAS:
•••••
Do not try to light any appliance.
•••••
Do not touch any electrical switch; do not use any phone in your
building.
•••••
Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
•••••
If you cannot reach your gas supplier, call the fire department.
-
INSTALLATION AND SERVICE MUST BE PERFORMED
BY A QUALIFIED INSTALLER, SERVICE AGENCY OR
THE GAS SUPPLIER.
R
R
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
CONTENTS Introduction………………………………. 2Specifications and Dimensions…………… 2 Safety Rules………………………………. 3Clearances………………………………… 4, 5Location…………………………………… 6Installation………………………………… 6 Operation…………………………………. 7 Lighting Instructions……………………… 8, 9 Pilot Adjustment………………………….. 10 Removing Burner………………………. ...
SAFETY RULES 1. Follow all applicable local codes and ordinances. If there are none, follow the latest edition of the National Fuel Gas Code, ANSI.Z223.1. A copy may be obtained from American Gas Association,1515 Wilson Blvd., Arlington, Virginia 22209, or the National Fire Protection Association,Ba...
REFERENCE LETTER TO DRAWING CANADIAN INSTALLAT A = Clearance above grade, veranda, porch, deck, or balcony 12 Inches (30 cm) B = Clearance to window or door that may be opened 12 Inches (30 cm) C = Clearance to permanently closed window 12 Inches (30 cm) D = Vertical clearance to ventilated soffit l...
