COZY BBT53 - Manual
COZY BBT53 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – CONTENTS; INTRODUCTION; SPECIFICATIONS AND DIMENSIONS; appliance be performed by a plumber or gas fitter licensed in the
- Page 3 – This heater must not be connected to a chimney flue.
- Page 4 – CLEARANCES TO COMBUSTIBLES; CLEARANCES
- Page 5 – LOCATION; This heater must be installed on an outside wall.; Check that a gas supply line is accessible.; THERMOSTAT LOCATION
- Page 6 – OPTIONAL KITS; INSTALLATION; Select area on wall where heater will be installed.; FIGURE 2; FLOOR
- Page 7 – BASEBOARD CABINET; FIGURE 3; FIGURE 4; FIGURE 4: COMPONENTS OF THE
- Page 10 – COMPLETING INSTALLATION
- Page 12 – GAS CONVERSION; CONVERSION INSTRUCTIONS; See orifice chart in these instructions.
- Page 13 – NATURAL GAS; PROPER BURNER FLAME; Turn off all electrical supply to heater.; BURNER ORIFICE; SPECIFIC ELEVATIONS; BURNER BOX
- Page 14 – WIRING; Verify proper operation after servicing.; LADDER; IGNITION MODULE; PICTORIAL
- Page 16 – VENT RISER KIT; FIGURE 1
- Page 21 – TROUBLE SHOOTING CHART; SYMPTOM
- Page 23 – Prices and specifications subject
- Page 25 – IMPORTANT SAFETY BULLETIN ON YOUR GAS CONTROL AND PILOT LIGHT; Do not try to light any appliance.
- Page 26 – LOUISVILLE TIN AND STOVE COMPANY
-
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
-
WHAT TO DO IF YOU SMELL GAS:
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use any
phone in your building.
•
Immediately call your gas supplier from a neighbor’s
phone. Follow the gas supplier’s instructions.
•
If you cannot reach your gas supplier, call the
fire department.
-
INSTALLATION AND SERVICE MUST BE PER-
FORMED BY A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER.
WARNING: If the information in these instructions are
not followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of life.
DIRECT VENT GAS
BASEBOARD HEATER
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 64900 / September 2004
R
R
U.S. PATENT #
5253635
CANADIAN PATENT #
2066870
This appliance must be connected to an
electrical ground.
WARNING:
CONNECT TO 115V ELECTRICAL
POWER SUPPLY.
DO NOT CONNECT TO 220V
POWER SUPPLY.
INSTALLER MUST LEAVE THESE INSTRUCTIONS
WITH THE CONSUMER, HAVE THEM COMPLETE,
AND RETURN THE WARRANTY CARD.
MODEL NUMBERS
NAT. GAS
L.P. GAS
BBT53
BBT54
BBT103
BBT104
NOTE: Obstruction in the vent exhaust tube or air intake tube due to insects, small animals, debris,
etc. will prevent the heater from operating but DOES NOT constitute a warranty issue.
This unit is not approved for installation in greenhouses, or environments involving dusty, wet,
corrosive, or explosive conditions. Such conditions will invalidate the warranty and may create unsafe
conditions.
WARNING: Operation of this furnace without the properly installed, factory furnished vent system could
result in Carbon Monoxide (CO) poisoning and possible death. For your safety, this furnace and the vent
system should be inspected at least annually by a qualified service person.
May be installed in an aftermarket, permanently located, manufactured home (mobile home) where not
prohibited by local codes. See owner’s manual for details. This appliance is not convertible for use with other
gases, unless a certified kit is used.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 Introduction……………………………..... 2 Specifications and Dimensions………...….. 2 Safety Rules…………………………….. 3 Clearances………………………………. 4, 5Location………………………………… 5 Installation………………………………. 6 - 10Lighting Instructions……………………... 11 Gas Conversion......................................... 12 Burner Orifice...
SAFETY RULES The Direct Vent Gas Baseboard Heater and its components meet all applicable safety standards when installed asdirected in this manual. For safe installation and operation of your Direct Vent Gas Baseboard Heater, read all theseinstructions before you begin. Failure to follow them exactl...
VENT CAP CLEARANCES Page 4 A = Clearance above grade, veranda, porch, deck or balcony (*12 inches [30cm] minimum)B = Clearance to window or door that may be opened (*6 inches [15 cm] minimum)C = Clearance to permanently closed window (minimum 12 inches [30 cm] recommended to prevent condensation on ...
