Page 3 - C O N T E N T S; Preface; Product Overview
iii Cisco 7609 Internet Router Installation Guide OL-5079-04 C O N T E N T S Preface vii Audience vii Organization vii Conventions viii Related Documentation xiii Obtaining Documentation xiii World Wide Web xiii Documentation CD-ROM xiv Ordering Documentation xiv Documentation Feedback xiv Obtaining...
Page 4 - Preparing for Installation; Installing the Cisco 7609 Internet Router
Contents iv Cisco 7609 Internet Router Installation Guide OL-5079-04 C H A P T E R 2 Preparing for Installation 2-1 Safety 2-1 Site Requirements 2-2 Environmental Requirements 2-2 Power Requirements 2-8 Power Connection Guidelines 2-8 AC-Powered Systems 2-9 DC-Powered Systems 2-11 Site Preparation C...
Page 5 - Troubleshooting; Removal and Replacement Procedures; Technical Specifications; Connector and Cable Specifications
v Cisco 7609 Internet Router Installation Guide OL-5079-04 Contents C H A P T E R 4 Troubleshooting 4-1 Getting Started 4-2 Problem Solving to the System Component Level 4-2 Identifying Startup Problems 4-3 Troubleshooting the Power Supply 4-5 Troubleshooting the Fan Assembly 4-6 Troubleshooting Mod...
Page 6 - Repacking the Cisco 7609 Internet Router
Contents vi Cisco 7609 Internet Router Installation Guide OL-5079-04 RJ-45 B-3 MT-RJ B-3 LC B-5 SC-Type B-5 Gigabit Interface Converters B-6 Cable Specifications B-8 Console Port Mode Switch B-8 Identifying a Rollover Cable B-9 Console Port Mode 1 Signaling and Pinouts B-9 Console Port Mode 2 Signal...
Page 7 - Audience
vii Cisco 7609 Internet Router Installation Guide OL-5079-04 Preface Note This document describes the Cisco 7609 Internet Router (OSR-7609) and not the Cisco 7609 Internet Router (CISCO7609). This preface describes who should read the Cisco 7609 Internet Router Installation Guide , how it is organiz...
Page 8 - Conventions
Preface Conventions viii Cisco 7609 Internet Router Installation Guide OL-5079-04 Conventions Notes use the following conventions: Note Means reader take note . Notes contain helpful suggestions or references to material not covered in the publication. Tips use the following conventions: Tip Means t...
Page 13 - Related Documentation; World Wide Web
xiii Cisco 7609 Internet Router Installation Guide OL-5079-04 Preface Related Documentation Related Documentation For additional Cisco 7600 series Internet Router information, refer to these publications: • Regulatory Compliance and Safety Information for Cisco 7600 Series Internet Routers • Cisco 7...
Page 14 - Ordering Documentation
Preface Obtaining Documentation xiv Cisco 7609 Internet Router Installation Guide OL-5079-04 Documentation CD-ROM Cisco documentation and additional literature are available in a CD-ROM package, which ships with your product. The Documentation CD-ROM is updated monthly and may be more current than p...
Page 15 - Obtaining Technical Assistance
xv Cisco 7609 Internet Router Installation Guide OL-5079-04 Preface Obtaining Technical Assistance To submit your comments by mail, for your convenience many documents contain a response card behind the front cover. Otherwise, you can mail your comments to the following address: Cisco Systems, Inc.D...
Page 16 - Technical Assistance Center; Cisco TAC Web Site
Preface Obtaining Technical Assistance xvi Cisco 7609 Internet Router Installation Guide OL-5079-04 Technical Assistance Center The Cisco TAC is available to all customers who need technical assistance with a Cisco product, technology, or solution. Two types of support are available through the Cisc...
Page 17 - Cisco TAC Escalation Center
xvii Cisco 7609 Internet Router Installation Guide OL-5079-04 Preface Obtaining Technical Assistance If you cannot resolve your technical issues by using the Cisco TAC Web Site, and you are a Cisco.com registered user, you can open a case online by using the TAC Case Open tool at the following URL: ...
Page 24 - System Features; Bandwidth and Port Density
Chapter 1 Product Overview System Features 1-6 Cisco 7609 Internet Router Installation Guide OL-5079-04 The Cisco 7609 Internet Router supports the following: • A Supervisor Engine 2 with MSFC2 and a PFC2, and an optional redundant Supervisor Engine 2 with MSFC2 and a PFC2. Each supervisor engine ha...
Page 25 - Redundancy
1-7 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 1 Product Overview System Features Redundancy The Cisco 7609 Internet Router has these redundancy features: • Ability to house two hot-swappable supervisor engines • Ability to house two fully redundant, AC-input or DC-input, load-...
Page 26 - Component Hot Swapping; Cisco 7600 Internet Router Components; Fan Assembly
Chapter 1 Product Overview Cisco 7600 Internet Router Components 1-8 Cisco 7609 Internet Router Installation Guide OL-5079-04 Component Hot Swapping You can hot swap all modules (including the supervisor engine if you have a redundant supervisor engine) and fans. You can add, replace, or remove modu...
Page 27 - Power Supplies
1-9 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 1 Product Overview Cisco 7600 Internet Router Components Figure 1-2 Cisco 7609 Internet Router Internal Airflow Power Supplies The Cisco 7609 Internet Router power supplies are available in two power ratings: • 2500W—AC and DC inpu...
Page 29 - Load Sharing
1-11 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 1 Product Overview Cisco 7600 Internet Router Components Figure 1-4 DC-Input Power Supply Load Sharing When you install and turn on two power supplies, each power supply concurrently provides approximately half of the required pow...
Page 30 - Environmental Monitoring of the Power Supply
Chapter 1 Product Overview Cisco 7600 Internet Router Components 1-12 Cisco 7609 Internet Router Installation Guide OL-5079-04 Environmental Monitoring of the Power Supply The environmental monitoring and reporting functions allow you to maintain normal system operation by resolving adverse environm...
Page 31 - Power Supply Fan Assembly
1-13 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 1 Product Overview Cisco 7600 Internet Router Components Power Supply Fan Assembly The power supplies have a built-in fan; air enters the front of the fan (power-input end) and exits through the back. An air dam keeps the airflow ...
Page 33 - Safety
C H A P T E R 2-1 Cisco 7609 Internet Router Installation Guide OL-5079-04 2 Preparing for Installation Note This document describes the Cisco 7609 Internet Router (OSR-7609) and not the Cisco 7609 Internet Router (CISCO7609). This chapter describes how to prepare your site for Cisco 7609 Internet R...
Page 34 - Site Requirements; Environmental Requirements
Chapter 2 Preparing for Installation Site Requirements 2-2 Cisco 7609 Internet Router Installation Guide OL-5079-04 Site Requirements This section provides site power requirements for the Cisco 7609 Internet Router. You should verify the site power prior to installing the switch. Power requirements ...
Page 40 - Power Requirements; Power Connection Guidelines
Chapter 2 Preparing for Installation Power Connection Guidelines 2-8 Cisco 7609 Internet Router Installation Guide OL-5079-04 Power Requirements Follow these requirements when preparing your site for the switch installation: • The redundant power option provides a second, identical power supply to e...
Page 43 - Site Preparation Checklist
2-11 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 2 Preparing for Installation Site Preparation Checklist DC-Powered Systems Basic guidelines include the following: • Each chassis power supply should have its own dedicated input power source. • The circuit must be protected by a ...
Page 46 - Unpacking the Cisco 7609 Internet Router
Chapter 3 Installing the Cisco 7609 Internet Router Unpacking the Cisco 7609 Internet Router 3-2 Cisco 7609 Internet Router Installation Guide OL-5079-04 Before starting the installation procedures in this chapter, see the “Site Preparation Checklist” section on page 2-11 to verify that all site pla...
Page 47 - Installing the Rack-Mount Kit; Rack-Mounting Guidelines
3-3 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 3 Installing the Cisco 7609 Internet Router Installing the Rack-Mount Kit Installing the Rack-Mount Kit This section describes how to install the rack-mount kit provided in the accessories box. The kit contains a shelf bracket and ...
Page 48 - Required Tools; Installing the Shelf and Crossbar Brackets
Chapter 3 Installing the Cisco 7609 Internet Router Installing the Rack-Mount Kit 3-4 Cisco 7609 Internet Router Installation Guide OL-5079-04 Note Chassis height is measured in rack units (RU). Caution If the rack is on wheels, ensure that the brakes are engaged or that the rack is otherwise stabil...
Page 50 - Installing the L Brackets and Cable Guides
Chapter 3 Installing the Cisco 7609 Internet Router Installing the Rack-Mount Kit 3-6 Cisco 7609 Internet Router Installation Guide OL-5079-04 Installing the L Brackets and Cable Guides The Cisco 7609 Internet Router L bracket screw holes are stamped + and –. You can install the brackets either on t...
Page 52 - Installing the Cisco 7609 Chassis in the Rack
Chapter 3 Installing the Cisco 7609 Internet Router Installing the Cisco 7609 Chassis in the Rack 3-8 Cisco 7609 Internet Router Installation Guide OL-5079-04 Installing the Cisco 7609 Chassis in the Rack Note If you are not installing the Cisco 7609 Internet Router in the rack, you must install the...
Page 54 - Installing the Stabilizer Kit
Chapter 3 Installing the Cisco 7609 Internet Router Installing the Stabilizer Kit 3-10 Cisco 7609 Internet Router Installation Guide OL-5079-04 Installing the Stabilizer Kit Note The stabilizer kit is included only in the accessory kits for the Cisco 7609 Internet Router. If you are not installing t...
Page 56 - System Ground Connection; Required Tools and Equipment
Chapter 3 Installing the Cisco 7609 Internet Router System Ground Connection 3-12 Cisco 7609 Internet Router Installation Guide OL-5079-04 System Ground Connection This section describes how to connect a system (earth) ground to the Cisco 7609 Internet Router. Note You must connect both the system g...
Page 58 - Connecting the System Ground
Chapter 3 Installing the Cisco 7609 Internet Router Installing the Power Supplies in the Cisco 7609 Chassis 3-14 Cisco 7609 Internet Router Installation Guide OL-5079-04 Connecting the System Ground You must complete this procedure before connecting system power or turning on the Cisco 7609 Internet...
Page 59 - Attaching the Interface Cables; Connecting the Supervisor Engine Console Port
3-15 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 3 Installing the Cisco 7609 Internet Router Attaching the Interface Cables Attaching the Interface Cables This section provides general information on attaching interface cables to the supervisor engines and to the modules. Depend...
Page 63 - Connecting to the Interface Ports
3-19 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 3 Installing the Cisco 7609 Internet Router Attaching the Interface Cables Note When you plug the SC-type connector into the GBIC, make sure that both the transmit (Tx) and receive (Rx) fiber-optic cables are fully inserted into t...
Page 65 - Verifying Cisco 7609 Chassis Installation
3-21 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 3 Installing the Cisco 7609 Internet Router Verifying Cisco 7609 Chassis Installation Verifying Cisco 7609 Chassis Installation After you finish connecting the modules, you need to verify that the modules, power supplies, and fan ...
Page 68 - Getting Started
Chapter 4 Troubleshooting Getting Started 4-2 Cisco 7609 Internet Router Installation Guide OL-5079-04 Note This chapter covers only the chassis component hardware aspects of troubleshooting. For module-specific information, refer to the Cisco 7600 Series Internet Router Module Installation Guide . ...
Page 69 - Identifying Startup Problems
4-3 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 4 Troubleshooting Identifying Startup Problems LED is red, this indicates that one or more fans in the fan assembly is not operating. You should immediately contact a customer service representative. (See the “Contacting Customer S...
Page 71 - Troubleshooting the Power Supply
4-5 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 4 Troubleshooting Troubleshooting the Power Supply Troubleshooting the Power Supply Perform these steps when troubleshooting the power supply to isolate a power subsystem problem: Step 1 Verify that the INPUT OK LED on the power su...
Page 72 - Troubleshooting the Fan Assembly; Troubleshooting Modules
Chapter 4 Troubleshooting Troubleshooting the Fan Assembly 4-6 Cisco 7609 Internet Router Installation Guide OL-5079-04 Troubleshooting the Fan Assembly Perform these steps when troubleshooting the fan assembly to isolate a fan assembly problem: Step 1 Verify that the FAN LED on the fan assembly is ...
Page 73 - Contacting Customer Service
4-7 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 4 Troubleshooting Contacting Customer Service If the status LED on a switching module is orange, the module might be busy or disabled. Refer to the Cisco 7600 Series Internet Router Software Configuration Guide, the Cisco 7600 Seri...
Page 76 - Removing and Replacing the Power Supply
Chapter 5 Removal and Replacement Procedures Removing and Replacing the Power Supply 5-2 Cisco 7609 Internet Router Installation Guide OL-5079-04 Removing and Replacing the Power Supply This section describes how to remove and install power supplies for the Cisco 7609 Internet Router. Note In system...
Page 79 - Installing an AC-Input Power Supply
5-5 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 5 Removal and Replacement Procedures Removing and Replacing the Power Supply Installing an AC-Input Power Supply Caution Use both hands to install and remove power supplies. Each Cisco 7609 Internet Router AC-input power supply wei...
Page 80 - Removing a DC-Input Power Supply
Chapter 5 Removal and Replacement Procedures Removing and Replacing the Power Supply 5-6 Cisco 7609 Internet Router Installation Guide OL-5079-04 Step 8 Turn the power switch to the On (|) position on the power supply. Switching the power switch to On also engages a pawl that locks the power supply ...
Page 84 - Installing a DC-Input Power Supply
Chapter 5 Removal and Replacement Procedures Removing and Replacing the Power Supply 5-10 Cisco 7609 Internet Router Installation Guide OL-5079-04 Installing a DC-Input Power Supply Warning Before performing any of the following procedures, ensure that power is removed from the DC circuit. To ensure...
Page 86 - Removing and Replacing the Fan Assembly
Chapter 5 Removal and Replacement Procedures Removing and Replacing the Fan Assembly 5-12 Cisco 7609 Internet Router Installation Guide OL-5079-04 Step 9 After ensuring that all wire connections are secure, reinstall the terminal block cover. Caution To prevent a short circuit or shock hazard after ...
Page 87 - Removing the Fan Assembly
5-13 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 5 Removal and Replacement Procedures Removing and Replacing the Fan Assembly Removing the Fan Assembly The fan assembly is designed to be removed and replaced while the system is operating without presenting an electrical hazard o...
Page 88 - Installing the Fan Assembly
Chapter 5 Removal and Replacement Procedures Removing and Replacing the Fan Assembly 5-14 Cisco 7609 Internet Router Installation Guide OL-5079-04 Step 2 Loosen the two captive installation screws by turning them counterclockwise. Step 3 Grasp the fan assembly with both hands and pull it outward; ro...
Page 89 - Checking the Installation
5-15 Cisco 7609 Internet Router Installation Guide OL-5079-04 Chapter 5 Removal and Replacement Procedures Removing and Replacing the Fan Assembly Checking the Installation Perform these steps when checking the installation to verify that the new fan assembly is installed correctly: Step 1 Listen fo...
Page 92 - Cisco 7609 Internet Router
Appendix A Technical Specifications Cisco 7609 Internet Router A-2 Cisco 7609 Internet Router Installation Guide OL-5079-04 Cisco 7609 Internet Router The Cisco 7609 Internet Router (OSR-7609) specifications are provided in Table A-1 . Table A-1 Cisco 7609 Internet Router Specifications Item Specifi...
Page 93 - Cisco 7609 Internet Router Power Supplies
A-3 Cisco 7609 Internet Router Installation Guide OL-5079-04 Appendix A Technical Specifications Cisco 7609 Internet Router Power Supplies Cisco 7609 Internet Router Power Supplies Table A-2 lists the specifications for the Cisco 7609 Internet Router power supplies. Table A-2 Cisco 7609 Internet Rou...
Page 94 - Regulatory Standards Compliance
Appendix A Technical Specifications Regulatory Standards Compliance A-4 Cisco 7609 Internet Router Installation Guide OL-5079-04 Regulatory Standards Compliance The Cisco 7609 Internet Router complies with the regulatory standards listed in the Regulatory Compliance and Safety Information for the Ci...
Page 95 - Connector Specifications
B-1 Cisco 7609 Internet Router Installation Guide OL-5079-04 A P P E N D I X B Connector and Cable Specifications Note This document describes the Cisco 7609 Internet Router (OSR-7609) and not the Cisco 7609 Internet Router (CISCO7609). This chapter describes the cables and connectors used with the ...
Page 99 - LC
B-5 Cisco 7609 Internet Router Installation Guide OL-5079-04 Appendix B Connector and Cable Specifications Connector Specifications LC Warning Because invisible laser radiation may be emitted from the aperture of the port when no cable is connected, avoid exposure to laser radiation and do not stare...
Page 100 - Gigabit Interface Converters
Appendix B Connector and Cable Specifications Connector Specifications B-6 Cisco 7609 Internet Router Installation Guide OL-5079-04 Gigabit Interface Converters Warning Because invisible laser radiation may be emitted from the aperture of the port when no cable is connected, avoid exposure to laser ...
Page 102 - Cable Specifications; Console Port Mode Switch
Appendix B Connector and Cable Specifications Cable Specifications B-8 Cisco 7609 Internet Router Installation Guide OL-5079-04 Cable Specifications The Cisco 7609 Internet Router comes with an accessories box that contains the cable and adapters you need to connect a console (an ASCII terminal or P...
Page 103 - Console Port Mode 1 Signaling and Pinouts
B-9 Cisco 7609 Internet Router Installation Guide OL-5079-04 Appendix B Connector and Cable Specifications Cable Specifications Identifying a Rollover Cable You can identify a rollover cable by comparing the two ends of the cable. Holding the cables side by side, with the tab at the back, the wire c...
Page 105 - Modem Adapter
B-11 Cisco 7609 Internet Router Installation Guide OL-5079-04 Appendix B Connector and Cable Specifications Cable Specifications Modem Adapter Use the RJ-45-to-RJ-45 rollover cable and RJ-45-to-DB-25 male DCE adapter (labeled “Modem”) to connect the console port to a modem. Table B-4 lists the pinou...
Page 106 - Console Port Mode 2 Signaling and Pinouts
Appendix B Connector and Cable Specifications Cable Specifications B-12 Cisco 7609 Internet Router Installation Guide OL-5079-04 Console Port Mode 2 Signaling and Pinouts This section provides the signaling and pinouts for the console port in mode 2 (port mode switch in the out position). (See Table...
Page 107 - Mode-Conditioning Patch Cord; Patch Cord Configuration Example
B-13 Cisco 7609 Internet Router Installation Guide OL-5079-04 Appendix B Connector and Cable Specifications Cable Specifications Mode-Conditioning Patch Cord When using the long wavelength/long-haul (LX/LH) GBIC with 62.5-micron diameter MMF, you must install a mode-conditioning patch cord (Cisco pr...
Page 108 - Differential Mode Delay
Appendix B Connector and Cable Specifications Cable Specifications B-14 Cisco 7609 Internet Router Installation Guide OL-5079-04 Patch Cord Installation Warning Because invisible laser radiation may be emitted from the aperture of the port when no cable is connected, avoid exposure to laser radiatio...
Page 115 - Numerics
IN-1 Cisco 7609 Internet Router Installation Guide OL-5079-04 I N D E X Numerics 2500W power supplies specifications A-3 4000W power supplies specifications A-4 A accessories box, console port B-8 AC-input power supply installing 5-5 LEDs 1-12, 4-5 removing 5-2 troubleshooting 4-5 adapters console p...
