Carrier PSV - Manual

Carrier PSV

Carrier PSV – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
Page: / 68

Table of Contents:

  • Page 3 – Step 2 — Check Unit —; NOTE: It is the responsibility of the purchaser to file all
  • Page 4 – Fig. 1 — Typical Installation — 50PSH Unit; UNIT HANGER ISOLATION DETAIL
  • Page 5 – Fig. 2 — 50PSH Dimensional Data
  • Page 6 – Fig. 3 — 50PSV Dimensional Data
  • Page 7 – Fig. 4 — 50PSD Dimensional Data; PSC BLOWER AIRFLOW
  • Page 8 – Step 3 — Locate Unit; Fig. 5 — Typical Vertical Installation — 50PSV Unit; Side Discharge to Back Discharge
  • Page 9 – Fig. 10 — Horizontal Unit Pitch
  • Page 10 – Step 7 — Pipe Connections —; not; Fig. 12 — Vertical Condensate Connection
  • Page 11 – Table 2 — Water Quality Guidelines
  • Page 12 – Table 3 — Metal Hose Minimum Bend Radii; Fig. 13 — Typical Ground-Water Piping Installation
  • Page 17 – Fig 18 — Units with ECM, Complete C and LON Controller (460 V)
  • Page 20 – WH
  • Page 24 – — WSHP Ope
  • Page 27 – Step 9 — Wire Field Controls; only; Fig. 27 — Low Voltage Field Wiring; Fig. 29 — Typical Accessory Wiring
  • Page 28 – view; WARNING; THERMO
  • Page 29 – Table 10 — Rnet Wiring; Step 10 — Operate ECM Interface Board —; CAUTION; Fig. 32 — Rnet Cable Wire; Fig. 33 — ECM Interface Board Physical Layout
  • Page 30 – Table 11 — ECM Blower Motor Performance Data
  • Page 35 – Operating Limits; Table 18 — Operating Limits —; Scroll Compressor Rotation —
  • Page 36 – Unit Start-Up Heating Mode
  • Page 40 – Unit Start-Up with WSHP Open Controls; Display Interface
  • Page 41 – Flow Regulation —; Water Pressure Drop; Flushing —
  • Page 42 – Table 33 — Antifreeze Percentages by Volume; Cooling Tower/Boiler Systems —
  • Page 46 – COMPLETE C AND DELUXE D BOARD; Table 34 — Complete C Control Current LED
  • Page 47 – WSHP Open Test Mode —; Retry Mode —
  • Page 50 – WSHP Open Controller —; Thermostatic Expansion Valves —; Fig. 39 — Thermistor Nominal Resistance; Fig. 38 — FP1 and FP2 Thermistor Location; COAX —
  • Page 52 – Table 37 — ECM Troubleshooting
  • Page 53 – Fig. 40 — ECM Pin Connectors
  • Page 54 – Stopped or Malfunctioned ECM Motor —; Refer; Fig. 41 — ECM Troubleshooting Flow Diagram
  • Page 55 – Moisture Check —; To perform moisture check:; Table 38 — Good Practices; DO
  • Page 58 – APPENDIX A — WSHP OPEN SCREEN CONFIGURATION
  • Page 59 – APPENDIX A — WSHP OPEN SCREEN CONFIGURATION (cont)
  • Page 61 – APPENDIX A — WSHP SCREEN OPEN CONFIGURATION (cont)
  • Page 68 – HEATING CYCLE ANALYSIS; = SUCTION TEMPERATURE – SUCTION SATURATION TEMPERATURE; SUBCOOLING; = DISCHARGE SATURATION TEMPERATURE – LIQUID LINE TEMPERATURE
Loading the manual

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.

Catalog No. 04-53500055-01

Printed in U.S.A.

Form 50PS-3SI

Pg 1

7-09

Replaces: 50PS-2SI

Installation, Start-Up, and

Service Instructions

CONTENTS

Page

SAFETY CONSIDERATIONS

. . . . . . . . . . . . . . . . . . . . . . . 2

GENERAL

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

INSTALLATION

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-31

Step 1 — Check Jobsite

. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Step 2 — Check Unit

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

• STORAGE

• PROTECTION

• INSPECT UNIT

Step 3 — Locate Unit

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

• FIELD CONVERSION OF DISCHARGE AIR

Step 4 — Mount the Unit

. . . . . . . . . . . . . . . . . . . . . . . . . . . 9

• HORIZONTAL UNIT

• VERTICAL UNITS

Step 5 — Check Duct System

. . . . . . . . . . . . . . . . . . . . . . 9

• SOUND ATTENUATION

• EXISTING DUCT SYSTEM

Step 6 — Install Condensate Drain

. . . . . . . . . . . . . . . . . 9

• HORIZONTAL UNIT

• VERTICAL UNITS

• VENTING

Step 7 — Pipe Connections

. . . . . . . . . . . . . . . . . . . . . . . 10

• WATER LOOP APPLICATIONS

• GROUND-WATER APPLICATIONS

• GROUND-LOOP APPLICATIONS

• INSTALLATION OF SUPPLY AND RETURN HOSE

KIT

Step 8 — Wire Field Power Supply

. . . . . . . . . . . . . . . . 13

• POWER CONNECTION

• SUPPLY VOLTAGE

• 208-VOLT OPERATION

• 460-VOLT OPERATION

Step 9 — Wire Field Controls

. . . . . . . . . . . . . . . . . . . . . 27

• THERMOSTAT CONNECTIONS

• WATER FREEZE PROTECTION

• AIR COIL FREEZE PROTECTION

• ACCESSORY CONNECTIONS

• WATER SOLENOID VALVES

• WSHP OPEN WIRING

Step 10 — Operate ECM Interface Board

. . . . . . . . . . 29

• COOLING

• HEATING

• CFM ADJUST

• DEHUMIDIFICATION MODE

PRE-START-UP

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

System Checkout

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

FIELD SELECTABLE INPUTS

. . . . . . . . . . . . . . . . . . 32-35

Complete C Control Jumper Settings

. . . . . . . . . . . . . 32

Deluxe D Control Jumper Settings

. . . . . . . . . . . . . . . . 32

Complete C Control DIP Switches

. . . . . . . . . . . . . . . . . 32

Deluxe D Control DIP Switches

. . . . . . . . . . . . . . . . . . . 32

Units with Modulating Hot Water Reheat

(HWR) Option

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Deluxe D Control Accessory

Relay Configurations

. . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Page

START-UP

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35-42

Operating Limits

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35

Scroll Compressor Rotation

. . . . . . . . . . . . . . . . . . . . . . .35

Unit Start-Up Cooling Mode

. . . . . . . . . . . . . . . . . . . . . . .35

Unit Start-Up Heating Mode

. . . . . . . . . . . . . . . . . . . . . . .36

Unit Start-Up with WSHP Open Controls

. . . . . . . . . .40

Flow Regulation

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41

Flushing

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41

Antifreeze

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41

Cooling Tower/Boiler Systems

. . . . . . . . . . . . . . . . . . . .42

Ground Coupled, Closed Loop and Plateframe

Heat Exchanger Well Systems

. . . . . . . . . . . . . . . . . . .42

OPERATION

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42-46

Power Up Mode

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42

Units with Aquazone Complete C Control

. . . . . . . . .42

Units with Aquazone Deluxe D Control

. . . . . . . . . . . .42

Units with HWR Option

. . . . . . . . . . . . . . . . . . . . . . . . . . . .43

Units with WSHP Open Multiple Protocol

. . . . . . . . . .43

COMPLETE C AND DELUXE D BOARD

SYSTEM TEST

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46,47

Test Mode

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46

WSHP Open Test Mode

. . . . . . . . . . . . . . . . . . . . . . . . . . . .47

Retry Mode

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47

Aquazone Deluxe D Control LED Indicators

. . . . . . .47

SERVICE

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48,49

Filters

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Water Coil

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Condensate Drain Pans

. . . . . . . . . . . . . . . . . . . . . . . . . . .48

Refrigerant System

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Compressor

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Fan Motors

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Condensate Drain Cleaning

. . . . . . . . . . . . . . . . . . . . . . .48

Air Coil Cleaning

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Condenser Cleaning

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

Checking System Charge

. . . . . . . . . . . . . . . . . . . . . . . . .49

Refrigerant Charging

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49

Air Coil Fan Motor Removal

. . . . . . . . . . . . . . . . . . . . . . .49

Replacing the WSHP Open Controller’s

Battery

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49

TROUBLESHOOTING

. . . . . . . . . . . . . . . . . . . . . . . . . . . 49-57

Control Sensors

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

Thermistor

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49

WSHP Open Controller

. . . . . . . . . . . . . . . . . . . . . . . . . . . .50

Thermostatic Expansion Valves

. . . . . . . . . . . . . . . . . . . 50

Stopped or Malfunctioned ECM Motor

. . . . . . . . . . . . . 54

Moisture Check

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

APPENDIX A — WSHP OPEN SCREEN

CONFIGURATION

. . . . . . . . . . . . . . . . . . . . . . . . . . . . 58-63

50PSH,PSV,PSD START-UP

CHECKLIST

. . . . . . . . . . . . . . . . . . . . . . . . . . . . CL-1, CL-2

IMPORTANT: Read the entire instruction manual before

starting installation.

AQUAZONE™

50PSH, PSV, PSD006-070

Single-Stage Water Source Heat Pumps

with PURON

®

Refrigerant (R-410A)

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - Step 2 — Check Unit —; NOTE: It is the responsibility of the purchaser to file all

3 Table 1 — Physical Data — 50PSH, PSV, PSD018-070 Units LEGEND *Unit sizes 006-012 not available on 50PSD unit.NOTE: All units have spring compressor mountings, TXV expansion devices, and 1 / 2 - in. and 3 / 4 -in. electrical knockouts. Step 2 — Check Unit — Upon receipt of shipment at the jobsite,...

Page 4 - Fig. 1 — Typical Installation — 50PSH Unit; UNIT HANGER ISOLATION DETAIL

4 Before installing any of the system components, be sure to examine each pipe, fitting, and valve, and remove any dirt or foreign material found in or on these components. INSPECT UNIT — To prepare the unit for installation, com- plete the procedures listed below: 1. Compare the electrical data on ...

Page 5 - Fig. 2 — 50PSH Dimensional Data

5 NOTES:1. Condensate is 3 / 4 -in. FPT copper. 2. Horizontal unit shipped with filter bracket only. This bracket should beremoved for return duct connection. 3. Discharge flange and hanger kit is factory installed. 4. Shaded areas are recommended service areas, not required. 50PSH UNIT SIZE OVERALL...

Other Carrier Models