White Rodgers SST1600 - Manuals

Page 2 - ELECTROCUTION HAZARD

2 DID YOU GET THE RIGHT SIZE DID YOU GET THE RIGHT SIZE DID YOU GET THE RIGHT SIZE DID YOU GET THE RIGHT SIZE DID YOU GET THE RIGHT SIZE AIR CLEANER AIR CLEANER AIR CLEANER AIR CLEANER AIR CLEANER Model SST1000 Model SST1000 Model SST1000 Model SST1000 Model SST1000 is designed for heating or coolin...

Page 3 - Handle

3 A B C Dirty Air In Clean Air Out Cabinet Pre-Filters Handle ContactButton ContactButton Collecting Cells Power Pack HOW THE AIR CLEANER WORKS HOW THE AIR CLEANER WORKS HOW THE AIR CLEANER WORKS HOW THE AIR CLEANER WORKS HOW THE AIR CLEANER WORKS Dirt particles flowing through the ducts (Figure 1) ...

Page 4 - Figure 3; Figure 5; PREINSTALLATION

4 Air Flow FurnaceOpening Not to Exceed 20 Air Flow ElectronicAir CleanerOpening ElectronicAir Cleaner Furnace Transition Section (if Needed) Figure 3 Cabinet (Interchangeable) Collecting Cell (Interchangeable) Collecting Cell Outlet Box Power Pack Handle Contact Button Contact Button Pre-Filters (I...

Page 5 - TYPICAL MOUNTING POSITIONS; Air Flow

5 At Least9 Inches Less than7 Inches Offset Figure 10 Air Flow Figure 9 HIGHBOY FURNACE HIGHBOY FURNACE HIGHBOY FURNACE HIGHBOY FURNACE HIGHBOY FURNACE(Figure 9) (Figure 9) (Figure 9) (Figure 9) (Figure 9) Installation beneath furnace.Cleaner mounts horizontally,where return air enters frombelow. Ra...

Page 6 - Transition Fittings; INSTALLATION

6 Figure 12 Figure 13 Duct Frame Power Supply Box Mounting Holes Air Flow Turning Vanes Figure 14 Optional method (Bend tabs outward at 90˚ angle) Figure 15 REMOVE OLD FILTER AND DISCARD REMOVE OLD FILTER AND DISCARD REMOVE OLD FILTER AND DISCARD REMOVE OLD FILTER AND DISCARD REMOVE OLD FILTER AND D...

Page 7 - WARNING; WIRING INSTRUCTIONS

7 VerticalSection Wood Block Tape All Joints Figure 16 Hot Neutral Grounding Conductor Front View Figure 17 Floor Conduit Duct Electronic Air Cleaner Figure 18 Cabinet Pre-Filters Handle ContactButton ContactButton Collecting Cells Power Pack Figure 19 7. With the cabinet installed, the air cleaner ...

Page 8 - CAUTION; CLEANING THE CELLS

8 OperatingLight On-Off Switch Figure 20 1. With the 120 VAC power turned on at the circuitbreaker for the furnace, push the air cleaner ON-OFFswitch to the “ON” position (Figure 20). 2. With the furnace blower running, the air cleaner willbe operating. An arcing or “snapping” sound may beheard. Thi...

Page 9 - Hook the new wire onto the support at one end.; SPECIFICATIONS

9 REPLACING AN IONIZING WIRE REPLACING AN IONIZING WIRE REPLACING AN IONIZING WIRE REPLACING AN IONIZING WIRE REPLACING AN IONIZING WIRE If an ionizing wire should break, it can be replaced asfollows: 1. Remove all pieces of broken wire. Make sure sup-ports at each end are in good condition and not ...

Page 11 - Collecting Cell

11 TECHNICAL REPAIR GUIDE TECHNICAL REPAIR GUIDE TECHNICAL REPAIR GUIDE TECHNICAL REPAIR GUIDE TECHNICAL REPAIR GUIDE The solid-state power supply is not designed for individual component part replacement and must be replaced as a complete "snap-in" unit. Input voltage: 120 VAC 60 Hz.Output ...

Page 13 - Place washer on rivet; ELECTRONIC AIR CLEANER RETROFIT (ACR) KITS

13 OZONE REDUCTION OZONE REDUCTION OZONE REDUCTION OZONE REDUCTION OZONE REDUCTION All electronic air cleaners typically produce a smallamount of ozone that is within established limits.Some customers may notice an odor especially athigh altitudes or low air flow rates. This power supply has a “hair...

Page 15 - PARTS LIST FOR ELECTRONIC AIR CLEANERS; The PART DESCRIPTION; REPAIR PARTS

15 ITEM NO. DESCRIPTION PART NUMBER SST1000 SST1400 SST1600 SST2000 1 Cabinet N/A N/A N/A N/A 2 Pre-Filter • F825-0431 • F825-0432 • F825-0337 • F825-0338 3 Collecting Cell • F811-0398 • F811-0397 • F811-0321 • F811-0319 4 Junction Box Cover F838-0072 F838-0072 F838-0072 F838-0072 5 * Screw #6 x 3/8...

Page 16 - NOTICE TO CONSUMERS; Electronic Air Cleaner; WASH REMINDER SCHEDULE

NOTICE TO CONSUMERS White-Rodgers Electronic Air Cleaner Dear Consumer; White-Rodgers would like to thank you for purchasing a White-Rodgers Electronic AirCleaner or product containing a White-Rodgers Electronic Air Cleaner. Although White-Rodgers does not extend a warranty directly to consumers, Wh...