Vermont Casting BC36 - Manuals

5 Majestic Fireplaces ® BR/BC Series 7412944 WF554 BR/BC Combo of IWF261 AND IWF265 11/10/97 Chase Installation Insulation methods shown are optional for cold climate, not a requirement for unit operation. FP554 Fig. 5 Fireplace and chase parts identification. Termination Cap Storm CollarPan Flashing...

6 Majestic Fireplaces ® BR/BC Series 7412944 Chimney Support Chimney Requirements - Offset Installations 0 0 0 0 0 3" 11" 1 0 0 0 0 8 ¹⁄₄ " 20" 0 1 0 0 0 11 ¹⁄₄ " 25 ¹⁄₄ " 2 0 0 0 0 13 ¹⁄₂ " 29 ¹⁄₄ " 1 1 0 0 0 16 ¹⁄₂ " 34 ¹⁄₄ " 0 0 1 0 0 20 ¹⁄₄ " 40 ³⁄₄ &#...

7 Majestic Fireplaces ® BR/BC Series 7412944 Planning Information The Ten Foot Rule Major U.S. building codes specify a minimum chimney height above the roof top. The “Ten Foot Rule” is a fire safety rule and not a draft rule. To ensure proper draft, it is recommended that you always meet or exceed t...

8 Majestic Fireplaces ® BR/BC Series 7412944 Insulating Fireplace Enclosure for Cold Climates Installation Chimney Supports The chimney system is supported by the fireplace for vertical chimney heights less than 30' (9m) above the hearth. Chimney supports are required if the vertical height exceeds 3...

9 Majestic Fireplaces ® BR/BC Series 7412944 Framing Framing can be constructed before or after the fire-place is set in place, however, most installers build the frame before setting the fireplace.Frame fireplace with 2 x 4 lumber or heavier materials. Refer to framing dimensions in Figures 1, 2, 3 or...

10 Majestic Fireplaces ® BR/BC Series 7412944 Determine offset distance of your chimney arrangement from centerline of fireplace to centerline of chimney where it is to pass through ceiling.Locate center point of the chimney on ceiling as though a straight up chimney arrangement is to be used. Mea-su...

11 Majestic Fireplaces ® BR/BC Series 7412944 The following table gives firestop spacer model num-bers: The inside dimension of the frame must be the same as the hole size selected from Figure 13 in order to provide the required 1 ¹⁄₂ " (38 mm) of air space between the outside diameter of the chi...

12 Majestic Fireplaces ® BR/BC Series 7412944 Installing the Chimney System Start by attaching the first chimney section to the collar on top of the fireplace. Install the pipe as pictured in Figure 16. When you get a good lock, you will hear the pipe clearly snap together. Once sections are snap-lock...

13 Majestic Fireplaces ® BR/BC Series 7412944 Firestop spacers are not available for nor are they re-quired on vertical walls. DO NOT put any sealant around the area where the outer pipe slides through the firestop spacer. If you seal this area, it may cause a fire hazard. Canadian Requirements for In...

14 Majestic Fireplaces ® BR/BC Series 7412944 Install Remainder of Chimney Sections Since you have already preplanned the height of your termination according to the Ten Foot Rule , continue to install pipe to the predetermined height.Check the chimney top installation instructions for details on ho...

15 Majestic Fireplaces ® BR/BC Series 7412944 MA81 rev. 8/5/97 1 ¹⁄₂ " Ref. Combustible materials are permitted within a shaded area shown in Figure 23 titled Minimum Wall Clearances. * ** MA81 Fig. 22 Combustible mantel clearances. *12" from top of fireplace opening for radiant models12"...

16 Majestic Fireplaces ® BR/BC Series 7412944 Side Wall Protection Adjacent combustible side walls that are within mini-mum dimensions shown in Figure 23 of the fireplace opening must be protected with CFM Corporation Wall Shield Model SP40 or a specifically built wall shield described in Figure 20.Th...

17 Majestic Fireplaces ® BR/BC Series 7412944 Example of Determining Hearth Extension Equivalents To determine the thickness required for any new mate- rial: NEW K of new material (per inch) thickness required = --------------------------------------- X of listed thickness K of listed material (per ...

18 Majestic Fireplaces ® BR/BC Series 7412944 CAUTION: WHEN USING DECORATIVE GAS APPLIANCE, FLUE DAMPER MUST BE SET IN FULLY OPEN POSITION. IF YOU HAVE GLASS DOORS ON THE FIRE-PLACE, THEY MUST ALSO BE FULLY OPENED. WARNING: DO NOT OPERATE AN UN-VENTED GAS LOG SET IN THIS FIRE-PLACE WITH THE CHIMNEY ...

19 Majestic Fireplaces ® BR/BC Series 7412944 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, with out notice. 944 1 2 3 4 5 6 a b c 7 8 9 10 11 12 944 BR/BC parts 5/16/00 djt d 13 BR/BC SERIE...

20 Majestic Fireplaces ® BR/BC Series 7412944 The following accessories for this appliance are available from your local Majestic Fireplaces distributor. Should you need additional information beyond what your distributor can furnish, contact: CFM Specialty Home Products, 410 Admiral Blvd., Mississa...

21 Majestic Fireplaces ® BR/BC Series 7412944 Chimney Components Round Top Termination Top used to terminate chimney at roof. (Flashing not included.) RLTSK8 Round Top Termination - Top used to terminate chimney at chase. Extended (Flashing not included.) RLTSK8L Flashing Metal finishing required aro...

22 Majestic Fireplaces ® BR/BC Series 7412944 Chimney Collar Enclosure Installs on the "over the chimney collar" of the CCE-SK fireplace; provides outside air to assist in cooling the chimney system. Attic Insulation Shield Used to prevent insulation from coming in AIS-SK contact with the chi...

23 Majestic Fireplaces ® BR/BC Series 7412944 Limited Warranty & 30 Year Protection Plan For MAJESTIC FIREPLACES ® PRE-ENGINEERED Fireplace Systems CFM Specialty Home Products warrants its MAJESTIC FIRE-PLACES® Pre-Engineered Fireplace (“Fireplace”) and the CFM Specialty Home Products supplied fi...