Vermont Casting 2160 - Manuals

5 Dutchwest Sequoia 2001049 Prefabricated Chimneys A prefabricated metal chimney must be one tested andlisted for use with solid-fuel burning appliances to theHigh-Temperature (H.T.) chimney Standard UL-103-1985 (2100 ° F.) for the United States, and High Tem- perature (650 ° C) Standard ULC S-629 f...

7 Dutchwest Sequoia 2001049 A special piece called the "thimble sleeve," slightlysmaller in diameter than the standard connector andmost thimbles, will ease the removal of the chimneyconnector system for inspection and cleaning. (Fig. 6)Thimble sleeves should be available from your localdeal...

8 Dutchwest Sequoia 2001049 Floor Protection A tremendous amount of heat radiates from the bottomplate of your Sequoia stove. The floor area directlyunder and around the stove will require protection fromradiant heat as well as from stray sparks or embersthat may escape the firebox. Heat protection ...

9 Dutchwest Sequoia 2001049 completely noncombustible surface such as unpaintedconcrete over earth may be used without the heatshield. Even when the bottom heat shield is installed, youmust provide special protection to the floor beneath.For installation with the heat shield attached, use anoncombus...

10 Dutchwest Sequoia 2001049 insulation board such as Durock ® or Wonderboard ® , or common brick “laid on flat,” with the 3 ¹⁄₂ " (90 mm) side down. Shields must be spaced out from the combustiblesurface 1" (25 mm) on noncombustible spacers, as inFigure 14. The spacers should not be directl...

11 Dutchwest Sequoia 2001049 Unprotected A. Mantel 24” (610mm) B. Trim 24” (610mm) C. Side Walls 32” (813mm) Fireplace and Mantel Trim Clearances ST731 Fig. 15 Maintain clearances to combustible components ofthe mantelpiece. B B A B C C

12 Dutchwest Sequoia 2001049 Sequoia Clearance Chart Stove Clearance Stove InstalledParallel to Wall Unprotected Surfaces Protected Surfaces Side Rear Corners Side Rear Corners No stove heat shields 1 Chimney Connector Clearance Unprotected Vertical Surfaces Protected Vertical Surfaces Clearance to ...

13 Dutchwest Sequoia 2001049 Top Exit Installations, no heat shields Stove Installed Parallel to Wall Stove in Corner Stove Installed Parallel to Wall Unprotected Surfaces Protected Surfaces Stove in Corner Sequoia Clearance Diagrams A B C C D E G H I I F F J K L L M N O O P Q R R S T N/A U V N/A To...

14 Dutchwest Sequoia 2001049 Wall Shield Requirements for Common Sequoia Installations 36" (914mm) 1" (25mm) 32" (813mm) 1" (25mm) 58" (1473mm) 14" (356mm) 48" (1219mm) 17" (432mm) ST750 1" (25mm) 32" (813mm) 32" (813mm) 19" (483mm) 58" (1473mm) 12...

16 Dutchwest Sequoia 2001049 Unpack the Parts Remove all loose parts from the firebox and the ashpan. Check to make sure all the parts are included andintact. You should have received: • 1 fully assembled heater body, (with catalytic burnerinstalled in its chamber below the stove top) • 4 legs • 1 I...

17 Dutchwest Sequoia 2001049 Install Air Duct for Outside Air If your installation will include outside air for combus-tion, follow these directions for attaching the three inchduct to the stove: • Screw a #10 x 1/2” sheet metal screw into the duct.Tighten the screw, then back it off two turns. • Th...

18 Dutchwest Sequoia 2001049 The Sequoia Controls Air Controls The Sequoia has three air controls that regulate theamount of air drawn into the stove. Generally, more airentering the stove makes the fire burn hotter andfaster, while less air prolongs the burn. The Primary Air Control is the lever lo...

19 Dutchwest Sequoia 2001049 Successful Wood Burning Burning wood and coal is often said to be more of anart than a science. You will easily master the art if youstart by using good, dry fuel and by understanding howthe stove’s air supply system operates. Burn Only High-Quality Fuel This heater is d...

20 Dutchwest Sequoia 2001049 ST743 Fig. 21 High-efficiency performance when burning wood is aresult of catalytic combustor that is coated with preciousmetals to cause smoke to burn at temperatures lower thannormal. Sequoia Control Settings for Coal Fires (The primary air and combustor air controls a...

21 Dutchwest Sequoia 2001049 Never kindle a fire with colored paper or paper that hascolored ink or a glossy surface, and never burn treatedwood, garbage, solvents, or trash. All of these maypoison the catalyst and prevent it from operatingproperly. Never burn cardboard or loose paper exceptfor kind...

22 Dutchwest Sequoia 2001049 ST744 Fig. 22 Wear a heavy stove glove for protection whenremoving ash. correct this situation, roll up a couple pieces of newspa-per, place them on top of the kindling and toward theback of the stove, light them and close the doors. Thisshould heat the chimney enough to...

23 Dutchwest Sequoia 2001049 Keep Your Stove Looking New And Working Its Best Care of the Cast Iron Surface An occasional dusting with a dry rag will keep thepainted cast iron of your Sequoia looking new. If the paint needs retouching, allow the stove to coolcompletely. Wire-brush areas needing to b...

24 Dutchwest Sequoia 2001049 Adjusting Bolt Lock Nut Damper Rod Anchor Bolt ST441 Front ofStove Fig. 26 Damper adjustment. Repair Missing Cement in Seams The cement in the stove seams may deteriorate overtime and fall out in places. Just as with the stovedoors, it is necessary to keep the seam seals...

25 Dutchwest Sequoia 2001049 Care of the Catalytic Combustor This wood heater contains a catalytic combustor, whichneeds regular inspection and periodic replacement forproper operation. Reminder: It is against the law in theUnited States to operate this wood heater in a mannerinconsistent with opera...

27 Dutchwest Sequoia 2001049 Clean the chimney using a specially designed chimneycleaning brush, the same size and shape as the flueliner, attached to flexible fiberglass rods designed forthis purpose. Run the brush up and down the liner sothat any deposits fall to the bottom of the chimneywhere the...

28 Dutchwest Sequoia 2001049 In any chemical reaction, including the combustionprocess, there are certain conditions which must be metbefore the reaction can take place. For example, areaction may require a certain temperature, or a certainconcentration of the reactants (the combustion gases andoxyg...

29 Dutchwest Sequoia 2001049 Your stove is only one part of a system that includes thechimney, the operator, the fuel, and the home. The otherparts of the system will affect how well the stove works.When there is a good match between all the parts, thesystem works well. Wood stove operation depends ...

31 Dutchwest Sequoia 2001049 72 50 2 4 46 11 9 14 23 53 66 49 73 26 26 25 36 27 75 21 20 19 23 57 38 18 39 23 37 64 52 1 43 3 45 42 41 44 41 42 57 16 40 17 23 62 15 53 76 77 79 80 81 48 70 35 29 55 28 34 34 12 13 8 7 6 5 74 10 78 1049 CFM Specialty Home Products reserves the right to make changes in...

33 Dutchwest Sequoia 2001049 © CFM Specialty Home Products Warranty Limited 3 Year Warranty CFM Specialty Home Products warrants that this woodburningstove will be free of defects in material and workmanship for aperiod of three years from the date you receive it, except that thecatalyst, thermostat...

410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com CFM Specialty Home Products