Regency U41-NG3 - Manuals

Regency U41-NG3 – Manual in PDF format online.

Manuals:

Manual

Manual Regency U41-NG3

Summary

Page 2 - TO THE NEW OWNER; REGENCY

2 Regency U41-3 ULTIMATE Gas Fireplace Insert Note: Oversize faceplate 44-1/4" x 31-1/8" Extra Oversize Faceplate 50-1/4" x 35-1/8" TO THE NEW OWNER Congratulations! You are the owner of a state-of-the-art Gas Insert by FIREPLACE PRODUCTS INTERNATIONAL LTD. The Regency ULTIMATE Gas F...

Page 3 - TABLE OF CONTENTS; REGENCY ULTIMATE GAS FIREPLACE INSERT

3 Regency U41-3 ULTIMATE Gas Fireplace Insert TABLE OF CONTENTS REGENCY ULTIMATE GAS FIREPLACE INSERT SAFETY LABEL Safety Labels ............................................ 4 INSTALLATION REQUIREMENTS For your safety ................................................ 5Gas Pipe Testing ..................

Page 4 - SAFETY LABEL

4 Regency U41-3 ULTIMATE Gas Fireplace Insert This is a copy of the label that accompanieseach Regency ULTIMATE Gas Insert. Wehave printed a copy of the contents here foryour review. The safety label is located onthe right side door panel. NOTE: Regency units are constantly beingimproved. Check the ...

Page 5 - General Safety Information; INSTALLATION

5 Regency U41-3 ULTIMATE Gas Fireplace Insert Fireplace Trim Kit, Part # 610-940, is available. If the factory built fireplace height is too low for your Insert, you may remove the smoke shelf, baffle plate, and damper plate from the factory built fireplace if removable without cutting or torching, ...

Page 6 - CLEARANCES; Clearances to Combustibles

6 Regency U41-3 ULTIMATE Gas Fireplace Insert cord is hooked up to the fan switch and blower.Plug 3 wire cord into a suitable receptacle. Donot cut the ground terminal off under anyc i r c u m s t a n c e s . When connected with 120 volts, the appliancemust be electrically grounded in accordancewith...

Page 7 - HIGH ELEVATION

7 Regency U41-3 ULTIMATE Gas Fireplace Insert Burner Inlet Orifice Sizes: Natural Gas Burner #33 Max. Input Rating - Natural Gas 34,000 btu/h Min. Input Rating - Natural Gas 18,000 btu/h Output Capacity with blower Off Natural Gas 24,786 Max. Output Capacity with blower On Natural Gas 26,146 System ...

Page 8 - DRAFT HOOD; GAS CONNECTION; VENTILATION AIR

8 Regency U41-3 ULTIMATE Gas Fireplace Insert DRAFT HOOD CONNECTION 1 ) Attach the vent to the flue collar on the detachable draft hood. The flue collar of theappliance will fit inside a standard vent andmay be fastened directly to the vent bysheet metal screw or a B-Vent, single wallvent connector....

Page 9 - GAS PRESSURE TEST

9 Regency U41-3 ULTIMATE Gas Fireplace Insert INSTALLATION 9 for spillage test.) Before installing vent system ensure that thedamper plate is locked into the open position andsecure to prevent the damper plate from fallingdown and crushing the liner. GAS PRESSURE TEST The unit is preset to give the ...

Page 10 - FACEPLATE AND TRIM

10 Regency U41-3 ULTIMATE Gas Fireplace Insert INSTALLATION 3 ) Using the trim clips provided, join the left side gold trim (the one with the ON/OFFswitch and variable speed FAN switch) tothe top gold trim. See diagram 2. Repeat thisstep for right side. 8 ) Fan Switch wires: Connect the plug end fro...

Page 11 - DOOR INSTALLATION

11 Regency U41-3 ULTIMATE Gas Fireplace Insert DOOR INSTALLATION (Packaged Separately) 1 ) Open the two side doors. 2 ) Slide the door onto the two hinge pins making sure the two pieces are flush to-gether. See diagram 1. Diagram 1 Diagram 3 Diagram 2 Diagram 4 Diagram 2 Diagram 1 Diagram 3 LOG INST...

Page 12 - OPTIONAL WALL

12 Regency U41-3 ULTIMATE Gas Fireplace Insert 14 GA.16 GA.18 GA.20 GA.22 GA. 50 Ft.32 Ft.20 Ft.12 Ft. 9 Ft. Recommended Maximum Lead Length (Two-Wire) When Using Wall Thermostat (CP-2 System) Wire Size Max. Length INSTALLATION Thermostat Wire Table OPTIONAL WALL THERMOSTAT A wall thermostat may be ...

Page 13 - WIRING DIAGRAM

13 Regency U41-3 ULTIMATE Gas Fireplace Insert WIRING DIAGRAM CAUTION: Label all wires prior todisconnection when servicing con-trols. Wiring errors can cause im-proper and dangerous operation. WARNING: Electrical Grounding Instructions This appliance is equipped with a three pronged (grounding) plu...

Page 14 - OPERATING INSTRUCTIONS

14 Regency U41-3 ULTIMATE Gas Fireplace Insert OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS Before operating this appliance, proceedthrough the following check list. 1 ) Read and understand these Instructions before operating this appliance. 2 ) Check to see that all wiring is correct and enclosed ...

Page 15 - COPY OF THE LIGHTING PLATE INSTRUCTIONS; LIGHTING INSTRUCTIONS; DO NOT REMOVE THIS; FOR YOUR SAFETY

15 Regency U41-3 ULTIMATE Gas Fireplace Insert COPY OF THE LIGHTING PLATE INSTRUCTIONS LIGHTING INSTRUCTIONS 2) Wait five (5) minutes to clear out any gas. If you then smell gas STOP! follow “B” in the safetyinformation above on this label. If you don’tsmell gas, go to the next step. 3) Turn knob on...

Page 16 - MAINTENANCE; NORMAL OPERATING

16 Regency U41-3 ULTIMATE Gas Fireplace Insert MAINTENANCE NORMAL OPERATING SOUNDS OF GAS APPLIANCES It is possible that you will hear some soundsfrom your gas appliance. This is perfectlynormal due to the fact that there are variousgauges and types of steel used within yourappliance. Listed below a...

Page 18 - Label all wires prior to disconnection when servicing controls.; FAN MAINTENANCE

18 Regency U41-3 ULTIMATE Gas Fireplace Insert MAINTENANCE CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. IMPORTANT Disconnect power supply before servicing WARNING: Electrical GroundingInstructionsThis appliance is ...

Page 19 - PARTS LIST; MAIN ASSEMBLY

19 Regency U41-3 ULTIMATE Gas Fireplace Insert PARTS LIST MAIN ASSEMBLY Part # Description Part # Description 27) 910-142 Thermodisc - Fan Auto/On/Off 28) * Thermodisc Bracket 30) 610-175 Rear Panel 31) 591-187 Firebox Baffle Plate 908-727 Manual *Not available as a replacement part. 1 ) 611-525 Bot...

Page 22 - NOTES

22 Regency U41-3 ULTIMATE Gas Fireplace Insert NOTES _____________________________________________________________________________________ ____________________________________________________________ __________________________________________________________ _________________________________________...

Page 23 - WARRANTY

23 Regency U41-3 ULTIMATE Gas Fireplace Insert WARRANTY Regency Fireplace Products, are designed with reliability and simplicity in mind. In addition, our internal Quality AssuranceTeam carefully inspects each unit thoroughly before it leaves our door. Regency Industries Ltd. is pleased to extend th...

Page 24 - Printed in Canada

Installer: Please complete the following information Dealer Name & Address: ______________________________________________ __________________________________________________________________ Installer: ___________________________________________________________ Phone #: __________________________...