RedMax HBZ2500 - Manuals - manualsarea.com

Page 2 - SAFETY FIRST; Notes on types of warnings

Read this manual carefully to understand allsafety precautions, controls, proper operationa n d m a i n t e n a n c e o f y o u r R e d M a x b l o w e r.Failure to do so could result in serious injury. Instructions labeled as shown at left concern critical steps orprocedures which must be followed ...

Page 3 - CONTENTS

CONTENTS SAFETY PRECAUTIONS ················································································ 4 OPERATOR USE OF BLOWER WORKING CONDITION AVOID NOISE PROBLEM AVOID CHANCES OF DAMAGE SYMBOLS ON THE MACHINE ······································································· 7 PARTS L...

Page 4 - OPERATOR; Safety Precautions; USE OF BLOWER

• Read this Blower Owner/Operator Manual carefully. Be sure you understand how tooperate this unit properly before you useit. Failure to do so could result in seriousinjury. • Be sure to keep this manual handy so that you may refer to it later whenever anyquestions arise. Also note that you arer e q...

Page 7 - Symbols on the machine; Position: FUEL TANK CAP; IMPORTANT ENGINE INFORMATION; INFORMATION IMPORTANTE CONCERNANT LE MOTEUR

❲ 7 ❳ Symbols on the machine For safe operation and maintenance, symbols arecarved in relief on the machine. According to theseindications, please be careful not to take a mistake. (a) The port to refuel the "MIX GASOLINE" Position: FUEL TANK CAP (b) The direction to close the chokePosition:...

Page 8 - BLOWER PIPE

Parts Location & Specifications Assembly ■ BLOWER PIPE • Align groove in blower pipe with projection on blower housing (or another blower pipe) andslide the pipe onto the blower housing (oranother blower pipe). Rotate the pipe clockwise to lock it into place. MODEL HBZ2500 Dimensions ( L x W x H...

Page 9 - Fuel

❲ 9 ❳ • G a s o l i n e i s v e r y f l a m m a b l e . A v o i d s m o k i n g o r b r i n g i n g a n y f l a m e o rsparks near fuel. Make sure to stop thee n g i n e a n d a l l o w i t c o o l b e f o r erefueling the unit. Select outdoor bareground for fueling and move at least3m(10ft) away fr...

Page 10 - Operation

❲ 10 ❳ ■ RESTARTING ENGINE WHILE ENGINE IS HOT 1. When restarting the engine immediately after stopping it, leave the choke open. 2. I f t h e e n g i n e w o n ' t s t a r t a f t e r s e v e r a l a t t e m p t s , c l o s e t h e c h o k e a n d r e p e a tpulling the rope or remove the spark plu...

Page 11 - Maintenance

■ FUEL FILTER • A c l o g g e d f u e l f i l t e r m a y c a u s e p o o r a c c e l e r a t i o n o f t h e e n g i n e . C h e c kperiodically to see if the filter is cloggedwith dirt. The filter can be taken out of thef u e l i n g p o r t u s i n g a s m a l l w i r e h o o k .Disconnect the fi...

Page 14 - Troubleshooting guide

❲ 14 ❳ Troubleshooting guide Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw ➞ out of normal range ➞ adjust to normal range sparking (no spark) ➞ spark plug is f...

Page 15 - Parts List; HANDHELD BLOWER

Parts List NOTE : 1. Use KOMATSU ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. KOMATSU ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company. 3. When placing parts orders for repair and/...

Page 20 - CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT

THE CALIFORNIA AIR RESOURCES BOARD AND KOMATSU ZENOAH Co. ARE PLEASED TO EXPLAIN THE EMISSION CONTROL SYSTEM WARRANTY ON YOUR 1995 AND LATER LAWN AND GARDEN EQUIPMENT ENGINE. IN CALIFORNIA, NEW UTILITY AND LAWN AND GARDEN EQUIPMENT ENGINES MUST BE DESIGNED, BUILT AND EQUIPPED TO MEET THE STATE'S STR...

Page 21 - RedMax

EMISSION-RELATED PARTS; FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE MODELHBZ2500 UNIT, KOMATSU ZENOAH AMERICA INC. (THE COMPANY), THROUGH ANY RedMax DEALER, WILL REPAIROR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART ORPARTS FOUND TO BE DEFECTIVE I...