Napoleon GVFL24N - Manuals

Napoleon GVFL24N – Manual in PDF format online.

Manuals:

Manual

Manual Napoleon GVFL24N

Summary

Page 2 - TABLE OF CONTENTS

2 W415-0809 / A / 05.10.10 NOTE: Changes, other than editorial, are denoted by a vertical line in the margin. TABLE OF CONTENTS 1.0 INSTALLATION OVERVIEW 3 2.0 INTRODUCTION 4 2.1 GENERAL INSTRUCTIONS 5 2.2 GENERAL INFORMATION 6 2.3 MINIMUM APPLIANCE SIZE 6 2.4 RATING PLATE INFORMATION 7 3.0 INSTALLA...

Page 3 - INSTALLATION OVERVIEW

3 W415-0809 / A / 05.10.10 1.0 INSTALLATION OVERVIEW Andiron, see “ANDIRON AND GRATE ASSEMBLY” section. Logs, see “LOG PLACEMENT” section. Media, see “MEDIA” section. Rating Plate, see “RATING PLATE INFORMATION” section.

Page 4 - WARNING

4 W415-0809 / A / 05.10.10 3.12 ! WARNING • THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED. • ANY CHANGES TO THIS APPLIANCE OR ITS CONTROLS CAN BE DANGEROUS AND IS PROHIBITED. • Under no circumstances should this appliance be modifi ed. • Do not operate appliance before ...

Page 5 - INSTRUCTIONS; The appliance off valve must be a “T” handle gas cock.; WITH THE GLASS DOOR OPENED OR REMOVED.

5 W415-0809 / A / 05.10.10 2.1 GENERAL INSTRUCTIONS Thoroughly clean the chimney, fl ue and existing appliance before installing the new appliance into it. Do not burn solid fuels in any appliance that is equipped with this gas log set. The installation of this appliance must conform with local code...

Page 6 - INFORMATION; CARBON MONOXIDE POISONING MAY LEAD TO DEATH; MINIMUM APPLIANCE SIZE; LOG SET

6 W415-0809 / A / 05.10.10 2.2 GENERAL INFORMATION CARBON MONOXIDE POISONING MAY LEAD TO DEATH EARLY SIGNS OF CARBON MONOXIDE POISONING RESEMBLE THE FLU, WITH HEADACHE, DIZZINESS AND/OR NAUSEA. IF YOU HAVE THESE SIGNS, THE APPLIANCE MAY NOT BE WORKING PROPERLY. GET FRESH AIR AT ONCE! HAVE APPLIANCE ...

Page 7 - RATING PLATE INFORMATION

7 W415-0809 / A / 05.10.10 2.4 RATING PLATE INFORMATION THIS APPLIANCE IS NOT FIELD CONVERTIBLE FOR USE WITH OTHER GASES. REFERENCE # W/N 15533 THE RATING PLATE IS CHAINED TO THE PIEZO IGNITOR BRACKET AND SHOULD BE TUCKED UNDER THE ENTIRE ASSEMBLY

Page 8 - COMBUSTION AND VENTILATION AIR PROVISIONS; defi nes a confi ned space as a space whose volume is; DETERMINING CONFINED OR UNCONFINED SPACE; NATIONAL FUEL GAS CODE ANSI Z2; CAUSE THE APPLIANCE TO CARBON OR OVERHEAT AND MALFUNCTION.; INSTALLING IN AN UNVENTED APPLICATION

8 W415-0809 / A / 05.10.10 3.0 INSTALLATION 3.1.1 COMBUSTION AND VENTILATION AIR PROVISIONS 17.1A This appliance shall not be installed in a confi ned space or unusually tight construction unless provisions are provided for adequate combustion and ventilation air. The National Fuel Gas Code, ANSI Z2...

Page 10 - INSTALLING IN A VENTED APPLICATION; DAMPER STOP; MINIMUM DAMPER OPENING

10 W415-0809 / A / 05.10.10 3.2 INSTALLING IN A VENTED APPLICATION 3.2.1 DAMPER STOP INSTALLATION DAMPER STOP DAMPER The damper must be permanently locked in position to prevent full closure and to provide a minimum fl ue opening. Various methods for locking the damper may be used but may be restric...

Page 11 - PIPING; ANDIRON AND GRATE ASSEMBLY; USE ONLY ACCESSORIES

11 W415-0809 / A / 05.10.10 3.3 GAS PIPING ! WARNING DO NOT CONNECT EITHER THE WALL SWITCH, THERMOSTAT OR GAS VALVE TO ELECTRICITY (110 VOLTS). This appliance and it’s appliance main valve must be disconnected from the gas supply piping system during any pressure testing of that system at test press...

Page 12 - PLACEMENT

12 W415-0809 / A / 05.10.10 4.2 LOG PLACEMENT Failure to position these logs in accordance with these diagrams or failure to use parts specifi cally approved with this appliance may result in property damage or personal injury. Do not place glowing embers, charcoal embers, vermiculite or charcoal lu...

Page 13 - LOGO; Sprinkle remaining lava rock onto the

13 W415-0809 / A / 05.10.10 4.3 LOGO PLACEMENT LOGO ½" LOGO ½" Remove the backing of the logo supplied. Centre the logo on the front of the appliance, ½” in from the left side, as shown. 4.4 MEDIA 4.4.1 Place lava or ember rock around the base of the appli-ance, making sure not to block any ...

Page 14 - OPERATING INSTRUCTIONS

14 W415-0809 / A / 05.10.10 5.0 OPERATING INSTRUCTIONS If the appliance is equipped with decorative glass doors, they must be fully opened when operating this gas log set. 5.1 LIGHTING INSTRUCTIONS 1 3 4 5 2 5.1.1 Locate the pilot burner at the rear of the log set on the right side. 5.1.2 Turn the g...

Page 16 - SHUTTER; SOOTING AND PROPERTY DAMAGE.; CORRECT PILOT FLAME; becomes unstable with more; CHARACTERISTICS

16 W415-0809 / A / 05.10.10 7.0 ADJUSTMENTS 7.1 AIR SHUTTER ! WARNING CARBON CAN BE DISTRIBUTED IN SURROUNDING LIVING AREAS IF THE AIR SHUTTER IS IMPROPERLY ADJUSTED. FAILURE TO KEEP THE PRIMARY AIR OPENING(S) OF THE BURNER (S) CLEAN MAY RESULT IN SOOTING AND PROPERTY DAMAGE. LOG SET AIR SHUTTER FUE...

Page 17 - COMPONENTS; ACCESSORIES

17 W415-0809 / A / 05.10.10 9.0 REPLACEMENTS Contact your dealer or the factory for questions concerning prices and policies on replacement parts. Normally all parts can be ordered through your Authorized dealer / distributor. FOR WARRANTY REPLACEMENT PARTS, A PHOTOCOPY OF THE ORIGINAL INVOICE WILL ...

Page 19 - SHOOTING; SYMPTOM; WITH THE GLASS DOOR OPEN OR REMOVED.

19 W415-0809 / A / 05.10.10 10.0 TROUBLE SHOOTING SYMPTOM PROBLEM TEST SOLUTION Main burner goes out; pilot stays on. Pilot fl ame is not large enough or not engulfi ng the thermopile. - Ensure adequate supply pressure. - Replace pilot assembly. Thermopile shorting / loose connection. - Clean thermo...

Page 21 - Check pressure readings:; DO NOT CLEAN GLASS WHEN HOT!; PILOT SCREW

21 W415-0809 / A / 05.10.10 SYMPTOM PROBLEM TEST SOLUTION Flames are consistently too large or too small. Carboning occurs. Unit is over-fi red or under-fi red. - Check pressure readings: - Inlet pressure can be checked by turning screw (A) counter-clockwise 2 or 3 turns and then placing pressure ga...

Page 22 - NAPOLEON® GAS LOG SET LIFETIME LIMITED WARRANTY

22 W415-0809 / A / 05.10.10 NAPOLEON® warrants its products against manufacturing defects to the original purchaser only. Registering your warranty is not necessary. Simply provide your proof of purchase along with the model and serial number to make a warranty claim. NAPOLEON® reserves the right to...

Page 23 - HISTORY

23 W415-0809 / A / 05.10.10 12.0 SERVICE HISTORY 43.1