Makita MAC700-AF506 - Manuals

Page 2 - Page; TABLE OF CONTENTS; GENERAL INFORMATION

Page 2 TABLE OF CONTENTS SAFETY INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Warning Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 GLOSSARY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

Page 3 - IMPORTANT SAFETY INSTRUCTIONS; WARNING; HAZARD

Page 3 IMPORTANT SAFETY INSTRUCTIONS *SAVE THESE INSTRUCTIONS* WARNING IMPROPER OPERATION OR MAINTENANCE OF THIS PRODUCT COULD RESULT IN SERIOUS INJURY AND PROPERTY DAMAGE. READ AND UNDERSTAND ALL WARNINGS AND OPERATING INSTRUCTIONS BEFORE USING THIS EQUIPMENT. HAZARD Risk ofUnsafeOperation WHAT CAN...

Page 7 - GLOSSARY

Page 7 GLOSSARY CFM: Cubic feet per minute. SCFM: Standard cubic feet perminute; a unit of measure of airdelivery. PSIG: Pounds per square inchgauge; a unit of measure ofpressure. CUT-IN PRESSURE: While themotor is off, air tank pressuredrops as you continue to useyour accessory or air tool. Whenthe...

Page 8 - STORAGE; Protect the electrical cord and; DESCRIPTION OF

Page 8 product was shipped directly toyou, report any damages to thecarrier and arrange for inspectionof goods immediately. STORAGE Before you store the aircompressor, make sure you dothe following: 1. Review the “Maintenance” and “Operating Procedures”sections and performmaintenance as necessary. B...

Page 9 - INSTALLATION AND; LUBRICATION AND OIL

Page 9 reaches “cut-out” pressure.PRESSURE SWITCH: Thepressure switch automaticallystarts the motor when the airtank pressure drops to thefactory set “cut-in” pressure. Itstops the motor when the airtank pressure reaches thefactory set “cut-out” pressure. SAFETY VALVE: If the pressureswitch does not...

Page 11 - OPERATING; Daily Star t-up Checklist

Page 11 grounding plug. The plug mustbe used with an outlet that hasbeen installed and grounded inaccordance with all local codesand ordinances. The outlet musthave the same configuration asthe plug. DO NOT USE ANADAPTER. Inspect the plug and cord beforeeach use. Do not use if there aresigns of dama...

Page 12 - MAINTENANCE

Page 12 MAINTENANCE WARNING: UNIT CYCLESAUTOMATICALLY WHENPOWER IS ON. WHENDOING MAINTENANCE, YOU MAY BE EXPOSED TO VOLTAGE SOURCES,COMPRESSED AIR ORMOVING PARTS. PERSONALINJURIES CAN OCCUR.BEFORE PERFORMING ANY MAINTENANCE ORREPAIR, UNPLUG THECOMPRESSOR AND BLEEDOFF ALL AIR PRESSURE. To ensure effi...

Page 13 - SERVICE; Motor

Page 13 Allow oil to drain completely. 2. Replace the oil drain plug (The use of a sealing compound orTeflon tape to avoid leakage isrecommended.) 3. Refill with the recommended oil to the proper level. SERVICE INSTRUCTIONS Air Filter - Inspection andReplacement:• Keep the air filter clean at all ti...

Page 14 - TROUBLESHOOTING GUIDE; • Move the pressure switch lever to the

Page 14 TROUBLESHOOTING GUIDE PERFORMING REPAIRS MAY EXPOSE VOLTAGE SOURCES, MOVING PARTS OR COMPRESSED AIR SOURCES. PERSONAL INJURY MAY OCCUR. PRIOR TO ATTEMPTING ANY REPAIRS, UNPLUG THE COMPRESSOR AND BLEED OFF TANK AIR PRESSURE. CAUSE Defectivepressureswitch. Improperwiring. Fittings arenot tight...

Page 17 - FACTORY SERVICE CENTERS; RETAIN THIS PORTION FOR YOUR RECORDS

Page 17 FACTORY SERVICE CENTERS 1-800-4-MAKITA RETAIN THIS PORTION FOR YOUR RECORDS ARIZONA 3707 E. Broadway Road, Suite 6Phoenix, AZ 85040(602) 437-2850 CALIFORNIA 41850 Christy StreetFremont, CA 94538-5107(510) 657-9881 14930 Northam StreetLa Mirada, CA 90638-5753(714) 522-8088 1970 Fulton AvenueS...

Page 18 - • arsenic and chromium from chemically-treated lumber.; MAKITA LIMITED ONE YEAR WARRANTY; Warranty Policy; Makita Corporation

Page 18 WARNING Some dust created by power sanding, sawing, grinding, drilling, andother construction activities contains chemicals known to the State ofCalifornia to cause cancer, birth defects or other reproductive harm.Some examples of these chemicals are:• lead from lead-based paints,• crystalli...

Page 19 - MAIL THIS PORTION; Your answers to the following questions are appreciated.

DATE PURCHASED MODEL NO. MONTH DAY YEAR SERIAL NO. STATUS SEX INTL. LAST NAME/COMPANY NAME Married Single M F STREET ADDRESS CITY AREA CODE STATE ZIP CODE PHONE AGE: Under 19 20-29 30-39 40-49 50-59 Over 60 BE SURE TO COMPLETE THE CUSTOMER’S PORTION OF THIS FORM AND RETAIN FOR YOUR RECORDS Please re...