Keating 2006 - Manuals

INSTALLATION This fryer MUST be installed, inspected, calibrated andserviced by qualified and/or certified and/or licensedservice personnel - you may void your Keatingwarranty if installation is not completed per local,national and Keating specifications. Contact yourdealer for assistance. DAMAGE DU...

GAS PRESSURE AT MANIFOLD NATURAL Gas - 3.0 in. W.C. LP Gas - 10.0 in. W.C. MAXIMUM INCOMING GAS PRESSURE NATUARAL Gas - 7.0 in. W.C. LP Gas - 11.0 in. W.C. NOTE: It is estimated that half of all service calls made on Keating Incredible Frying Machine® (IFM) resultfrom an inadequate gas supply. Durin...

Figure 3-4 Keating Klenzer and Sea Powder 1. Put on safety attire. See Draining. 2. Turn the fryer off 3. Drain oil from fryer, see draining steps 2-4 above. 4. Remove oil container to a secure area to preventaccidental spillage. 5. Fill fryer vessel to “Max” line with water. UNDER NO CIRCUMSTANCES ...

MAINTENANCE WARRANTY REPAIRS Keating’s warranty begins with the date of installation(or ship date if we are not notified of an installationdate). In the event that your fryer, under warranty, needsrepairs other than routine maintenance or cleaning, you are required to contact Keating of Chicago (at ...

Short Cycle : The thermostat will cycle rapidly while the fryer is in the idle mode; the temperature will beerratic. Thermostat Bulb Positioning 18 " & up Fryer Gas SERVICE ALL HI-LIMIT CONTROLS ARE PRESET AT THEFACTORY FOR A SPECIFIC TEMPERATURE. DONOT ATTEMPT TO CHANGE THE SETTING OF THEHI...

12 Problem Probable Cause Solution Main power light does not come on. a. Fryer not plugged in. b. Breaker has tripped. c. Main power switch is faulty. a. Plug fryer into approved outlet. Must be properly grounded. b. Reset the breaker lcoated on the bottom of the control panel c. Replace the main po...

ITEM MODEL PART NO. DESCRIPTION QTY 1 14” 030862 Blower 1 18” & 20” 053726 Blower 1 052471 Insulation 2 2 054162 Air Hose 2 015393 1 / 2 " Clamp 2 3 Call 1-800-KEATING Fry Pot 1 4 020717 Pilot Tee 1 5 022031 Pilot Tubing 1 / 8 S/S 2 6 016231 Elbow Brass 90° 2 015390 Bushing 2 14” 016502 Orif...

Oil Return Piping Assembly (Enlarged View) Front View Side View 3 2 1 8 9* 4 5 10 7 6 15 16 17 18 13 14 Burner & Electrode AssemblySee Detail on Page 23 12 11 19 20 16 INCREDIBLE FRYING MACHINE® GAS FRYER REAR DRAIN - MODEL 2000 (corresponds with parts list on page 15) * Not shownSee pages 20-22...

18 INCREDIBLE FRYING MACHINE® GAS FRYER FRONT DRAIN - MODEL 2006 (corresponds with parts list on page 17) See pages 23-25 for Control Panel Parts List. Front View Side View 2 5 6 4 9 11 12 7 8 10 3 1 13

ITEM DESCRIPTION QTY PART NUMBER 1 Power Switch with green Light 1 032242 Power Switch without Light 1 035030 2 Indicating Light Blue 1 015120 3 Indicating Light Amber 1 021254 4 Indicating Light Green 1 021255 5 Indicating Light Red 1 021209 6* High Limit Test Switch (Momentary) 1 015384 7 Spark Ig...

27 DESCRIPTION QTY PART # 1 TRANSFORMER 120/208/240/480V 1 056036 2* CIRCUIT BREAKER 3A/250V 1 053338 3 RELAY DPDT 24V AC 2 030844 4 RECTIFIER 1 018321 5 POWER CORD 1 021289 6 CONNECTION 3 CIRCUITS PLUG 1 032210 7 CONNECTOR 2 CIRCUIT CAP 2 032207 8 COVER FOR CIRCUIT BREAKER 1 054664 9 PUSH ROD 1 018...

28 Single Basket Lift Power Supply Box NOTES: 1. Wire Material: See wires specification2. Remove 3/8” of insulation from end of wire 3. Route all wires so they lay flat and are organized inappearance.4. Tug test all wires connect- NOTE: A separate wiring diagram has been included with this manual an...

29 14 IFM 120V CONNECTION DIAGRAM - NO TIMERS, FRONT DRAIN - MODEL 2000 CONTROL PANEL INSERT CONTROL PANEL BACK

30 CONTROL PANEL INSERT IFM - 120V CONNECTION DIAGRAM - TIMERS, FRONT DRAIN WITH LIGHTED ROCKER SWITCH - MODEL 2000 CONTROL PANEL BACK

31 14 IFM - MODEL 2006 FRONT DRAIN WITHOUT LIGHTED ROCKER SWITCH

34 18 & 20 IFM - MODEL 2006 FRONT DRAIN WITH LIGHTED ROCKER SWITCH

35 18 & 20 IFM - MODEL 2007 FRONT DRAIN WITHOUT LIGHTED ROCKER SWITCH

36 18 & 20 IFM - MODEL 2007 REAR DRAIN WITHOUT LIGHTED ROCKER SWITCH

37 18 & 20 IFM - MODEL 2007 WITH SAFE AND EASY® FILTER WITHOUT LIGHTED ROCKER SWITCH

38 BOB EVANS IFM - 120V CONNECTION DIAGRAM - NO TIMERS, REAR DRAIN - MODEL 2006 WITH TOGGLE SWITCHES Ef fective 5/2006

L IMITED W ARRANTY Keating Of Chicago, Inc. ("Keating”) warrants to the original purchaser . ("Customer"), all new Keating Fryers, Filter Systems, Griddles, Keep Krisp®, Custom Pasta Systems, T op-Side™ Cookers, Computer T imers, Fryer & Pasta V essels, and Keating replacement parts ...

SERVICE INFORMATION If you have a service related question call 1-800-KEATING. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. KEATING OF CHICAGO, INC. 8901 W. 50th Street, McCook, Illinois 605...