Keating 028951 - Manuals - manualsarea.com

Page 2 - TABLE OF CONTENTS

i TABLE OF CONTENTS SECTION I INTRODUCTION General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1Standard Features . . . . . . . . . . . . . . . . . . . . . . . . . .1Standard Accessories . . . . . . . . . . . . . . . . . . . . . . .1Cooking Head Specifications . . . . . . . . ...

Page 3 - WARNING; WAR N I NG; Disconnect all power; WAR N I NG

i NOTICE: This operating, installation, and service manual should be given to the user. The operator of the Top- Side Cooker ™ should be familiar with its functions and operation. This manual must be kept in a prominent, easily reachable location near the Top-Side Cooker ™ . i NOTICE: Keating of Chi...

Page 4 - I INTRODUCTION; II INSTALLATION

1 I INTRODUCTION GENERAL Keating Top-Side ™ Cookers are designed to give maximum production efficiency, delivering high quality food products. The following design features are incorporated into Keating Top-Side ™ Cookers. STANDARD FEATURES l Stainless steel control panel l Stainless steel head cove...

Page 5 - III OPERATING

2 ELECTRICAL CONNECTION Each Keating Top-Side ™ Cooking head is equipped with a 9' (2.74m) neoprene covered, 12 gauge 4mm(2), three wire with ground electrical cord. Each cooking head is rated 4000W, 18 amps, single phase at 220 Volts and is designed to be connected to its own 208- 240V single phase...

Page 6 - IV MAINTENANCE; WARRANTY REPAIRS; CAUTION

3 BECAUSE OF THE SUPERIOR MIRACLEAN ® SURFACE, THE ONLY TOOLS YOU WILL EVER NEED TO CLEAN THE TOP-SIDE ™ COOKING HEAD ARE A DAMP SOFT COTTON CLOTH AND A KEATING SCRAPER. l NEVER SCRAPE COOKING SHEETS WITH THE SCRAPER. l NEVER USE A GRIDDLE STONE, BRICK, GRIDDLE SCREEN OR HARSH CHEMICALS TO CLEAN THE...

Page 8 - V SERVICE DIAGNOSIS; Disconnect power before servicing.; PROBLEM

5 V SERVICE DIAGNOSIS A properly adjusted Keating Top-Side ™ Cooker, with no load, will cycle “ON” approximately every 5 1 / 2 to 6 1 / 2 minutes. Each cycle will last 40 seconds, ensuring that the temperature setting is held within a narrow range. A. Trouble-Shooting The following diagnosis is only...

Page 9 - TROUBLESHOOTING THE THERMOSTAT; For troubleshooting the thermocouple, use the chart below

Temperature (°F) Resistance (Ohm) 95 0.30 100 3.80 125 4.60 150 5.50 175 6.40 200 7.90 225 8.40 250 9.70 275 10.90 300 12.40 325 13.80 350 15.10 375 17.00 400 18.40 425 20.20 450 21.30 475 23.30 6 TROUBLESHOOTING THE THERMOSTAT Temperature reading is incorrect, showing a sensor error, or LOAD LED is...

Page 10 - VI EXPLODED VIEW & PARTS LIST; ORDERING PARTS; WARNING AND OPERATING PLATES; COOKER

7 VI EXPLODED VIEW & PARTS LIST ORDERING PARTS Parts may be ordered by part number by calling 1-800-KEATING or your local service company. You may also order online at Keating’s part store, www.keatingofchicago.com.Refer to the Keating Top-Side ™ Cooker Limited Warranty for complete service and ...

Page 13 - INSTRUCTIONS FOR MICROSWITCH ADJUSTMENT

10 1. Remove the limit switch black plastic cover on the actuator.2. Turn on the power on unit and push the T1, T2 or T3 button on the timer. The actuator will extend the stroke and lower head. The motor must stop and the stroke should stop extending before it reaches its mechanical stop. This movem...

Page 14 - COOKER CONTROL PANEL; Top View with Cover Removed

11 TOP-SIDE ™ COOKER CONTROL PANEL Figure 6-4 PART ITEM DESCRIPTION QTY. NUMBER 1 THERMOSTAT 1 056840 THERMOSTAT REPLACEMENT KIT 1 057138 2 HI-LIMIT CONTROL 1 010311 3 HI-LIMIT MOUNTING BRACKET 1 016654 4 CONTACTOR, 50A, 3 POLE 1 011184 5 ROCKER SWITCH, LIGHTED, ON/OFF 1 016689 6 INSTRUCTION PLATE O...

Page 15 - VII WIRING DIAGRAM; COOKER MANUAL LIFT WIRING DIAGRAM

12 VII WIRING DIAGRAM TOP-SIDE ™ COOKER MANUAL LIFT WIRING DIAGRAM Figure 6-5 LIGHTED ROCKER ON/OFF SWITCH GREEN LIGHT ON TOP LIGHTED ROCKER ON/OFF SWITCH GREEN LIGHT ON BOTTOM OR NOTE: ANGLED TERMINALS OF SWITCH ARE ALWAYS TOWARD CONTROL PANEL BOTTOM.

Page 16 - COOKER AUTO-LIFT WIRING DIAGRAM

13 TOP-SIDE ™ COOKER AUTO-LIFT WIRING DIAGRAM Figure 6-6

Page 18 - SERVICE INFORMATION; Have your serial and model number available when ordering parts.; KEATING LIMITED WARRANTY CARD; “Serving Those Who Serve The Very Best”

15 SERVICE INFORMATION If you have a service related question call 1-800-KEATING. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. KEATING OF CHICAGO, INC. 8901 W. 50th Street, McCook, Illinois ...