Henny Penny CMC/CMR-104 - Manuals

Page 2 - LIMITED WARRANTY FOR HENNY PENNY APPLIANCES; EXTENDED FRYPOT WARRANTY:

Model CMC/CMR-103,104,105,106,107 LIMITED WARRANTY FOR HENNY PENNY APPLIANCES Subject to the following conditions, Henny Penny Corporation makes the following limited warranties to the original purchaser only for Henny Penny appliances and replacement parts: NEW EQUIPMENT: Any part of a new applianc...

Page 3 - TABLE OF CONTENTS; Section

Model CMC/CMR-103,104,105,106,107 TABLE OF CONTENTS Section Page Section 1. INTRODUCTION ................................................................................................................... 1-1 1-1. Henny Penny Cold Tops ...................................................................

Page 4 - SECTION 1. INTRODUCTION

Model CMC/CMR-103,104,105,106,107 1-1. COLD TOPS The Henny Penny cold tops are full service units, designed to holdchilled or refrigerated products. The units are electronicallycontrolled for easy use and for consistent operation. 1-2. FEATURES • Can be matched with hot or cold merchandisers in all ...

Page 5 - NOTICE is used to highlight especially important information.

Model CMC/CMR-103,104,105,106,107 1-5. SAFETY The Henny Penny cold tops have many safety featuresincorporated. However, the only way to ensure a safe operationis to fully understand the proper installation, operation, andmaintenance procedures. The instructions in this manual havebeen prepared to ai...

Page 6 - SECTION 2. INSTALLATION

Model CMC/CMR-103,104,105,106,107 2-1. INTRODUCTION This section provides the installation for Henny Penny cold tops. Installation of this unit should be performed only by aqualified service technician. Do not puncture the unit with any objects such asdrills or screws, or component damage or electri...

Page 7 - or damage to the refrigeration system.; T h e; Peel off any protective covering from exterior of the cabinet.; Volts

Model CMC/CMR-103,104,105,106,107 2-2. UNPACKING Take care when moving the fryer to prevent personalinjury or damage to the refrigeration system. T h e CMC-107s weigh over 700 lbs. (318 kg). 4. Peel off any protective covering from exterior of the cabinet. 5. Install the grids into unit. 6. Unpack s...

Page 8 - Design Pressure; INFORMATION; High Low; UL Specs; Refrigerant Type Amount of Refrig.

Model CMC/CMR-103,104,105,106,107 303 2-3 2-5. REFRIGERANT Design Pressure INFORMATION High Low CMC-103 R22 1.5 lbs (0.680 kg) 440psig 162 psig (30.3 bar) (11.2 bar) CMC-104 R22 1.5 lbs (0.680 kg) 440psig 162 psig (30.3 bar) (11.2 bar) UL Specs CMC-105 R22 2.5 lbs (1.134 kg) 440psig 162 psig (30.3 b...

Page 9 - CMR MODELS; DRAIN& REFRIGERATION CONNECTIONS

Model CMC/CMR-103,104,105,106,107 2-8. FOOT PRINT DRAWING CMR MODELS DRAIN& REFRIGERATION CONNECTIONS 2-4 303 2-7. COMPRESSOR SIZE AND LOAD Model CMC Motor HP CMR Motor HP CMC/ BTU Load UL CE UL CE CMR R-22 R-134a R-22 R-134a 103 2860 1/4 1/3 Remote 104 2860 1/4 1/3 Compressor 105 2830 1/3 1/2 S...

Page 11 - AND BULB REPLACEMENT; M o d e l; UL Units; Install new fluorescent bulb in reverse order.; CE Units; Install new fluorescent lamp in reverse order.

Model CMC/CMR-103,104,105,106,107 2-10. FLOURESCENT LIGHTING N o . AND BULB REPLACEMENT M o d e l of Lights Size CMR/CMC-103 1 36 in. (.914 m) CMR/CMC-104 1 48 in. (1.22 m) CMR/CMC-105 1 24 in. (.610 m) 1 36 in. (.914 m) CMR/CMC-106 2 36 in. (.914 m) CMR/CMC-107 1 36 in. (.914 m) 1 48 in. (1.22 m) U...

Page 13 - Power Switch; SECTION 3. OPERATION

Model CMC/CMR-103,104,105,106,107 3-1. INTRODUCTION This section provides explanations of all controls, alongwith operating procedures and daily maintenance. Read theIntroduction, Installation and Opeation Sections beforeoperating the unit. Wait at least 4 hours before plugging the unit into anelect...

Page 20 - DIAGRAM FOR CMC MODEL

Model CMC/CMR-103,104,105,106,107 1002 3-8 DIAGRAM FOR CMC MODEL

Page 21 - DIAGRAM FOR CMR MODEL

Model CMC/CMR-103,104,105,106,107 DIAGRAM FOR CMR MODEL 3-9 1002

Page 23 - SECTION 4. PARTS INFORMATION

Model CMC/CMR-103,104,105,106,107 4-1. INTRODUCTION This section identifies and lists the replaceable parts of theHenny Penny Cold Top. 4-2. GENUINE PARTS Use only genuine Henny Penny parts in your cabinet. Using apart of lesser quality or substitute design may result in cabinetdamage or personal in...

Page 26 - Gas Shock Tool; See chart on page 4-3

Model CMC/CMR-103,104,105,106,107 1 2 Item Part Quantity N o . N o . Description 1 0 3 1 0 4 1 0 5 1 0 6 1 0 7 √√√√√ 1 56878 Gas Shock Tool - - - - - 2 56343-001 Gas Ram - 100N See chart on page 4-3 2 56343-002 Gas Ram - 200N See chart on page 4-3 2 56343-003 Gas Ram - 300N See chart on page 4-3 2 5...

Page 27 - Fluorescent; RECOMMENDED PARTS LIST

Model CMC/CMR-103,104,105,106,107 Item Part Quantity N o . N o . Description 1 0 3 1 0 4 1 0 5 1 0 6 1 0 7 1 23967 Refrigeration unit 1/4 HP - CMC-103/104 1 1 - - - 1 23969 Refrigeration unit 1/3 HP - CMC-105/106 - - 1 1 - 1 23968 Refrigeration unit 1/2 HP - CMC-107 - - - - 1 2 23973 Evaporator-152-...