Heat & Glo CF550E-B - Manuals

Heat & Glo CF550E-B – Manual in PDF format online.

Manuals:

Manual

Manual Heat & Glo CF550E-B

Summary

Page 2 - MODEL XXXX

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 2 Read this manual before installing or operating this heater. Please retain this owner’s manual for future reference. Congratulations on selecting a Heat & Glo electric fi replace. The insert you have selected is desi...

Page 3 - Table of Contents

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 3 Note: An arrow ( ¨ ) found in the text signi fi es change in content. Table of Contents 1 Listing and Code Approvals 4 A. Certi fi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Star...

Page 4 - cation; Standards; Listing and Code Approvals

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 4 A. Certi fi cation This heater has been tested in accordance with the UL2021 Standards for fi xed and location-dedicated electric room heaters in the United States, the current CSA C22.2 No. 46 in Canada and has been lis...

Page 5 - A. Important Instructions; fl; Getting Started; Do not; WARNING

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 5 Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner’s information manual provided with this heater. For assistance or additional information consu...

Page 6 - B. Design and Installation Considerations; CAUTION; D. Inspect Heater and Components; Read all the instructions before starting the installation.; C. Tools and Supplies Needed

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 6 B. Design and Installation Considerations Check building codes prior to installation.• Installation MUST comply with local, regional, state and national codes and regulations. • Consult insurance carrier, local building ...

Page 7 - A. Selecting Heater Location

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 7 3 3 Framing and Clearances A. Selecting Heater Location Several options are available to you when choosing a loca-tion for your heater. This heater may be used as a room divider, installed along a wall, across a corner o...

Page 8 - Model

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 8 C. Framing Figure 3.2 shows a typical framing (using 2 x 4 lumber) of the heater, assuming combustible materials are used. All re-quired clearances to combustibles around the heater must be adhered to. A* B* (header heig...

Page 9 - All wiring must be done by a quali; Shock Risk; A. 120VAC Wall Outlet Installation

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 9 Note: This heater must be electrically wired and grounded in accordance with local codes or, in the absence of local codes, with National Electric Code ANSI/NFPA 70-latest edition or the Canadian Electric Code, CSA C2.1 ...

Page 10 - C. 240VAC Hardwire Installation

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 10 B + B A - A LAMP LAMP FLAME M0TOR 120 VAC LAMPS REMOTE HEAT CONTROL REMOTE OR WALL ON/OFF SWITCH 12VDC SUPPLY POWER WHITE HEAT SWITCH OPTIONAL -12VDC SPEED CONTROL R2 D1 DIODE THERMOSTAT RELAY DIMMER PE N L1 L2 120 V 12...

Page 11 - Heater Preparation; A. Secure and Level the Heater; Fire Risk; Nailing Flanges

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 11 5 5 Heater Preparation A. Secure and Level the Heater Shock Risk Improperly grounded outlets could cause electrical shock.• Always use properly grounded, fused and polarized outlets. • Always use ground fault protection...

Page 12 - Finishing; A. Finishing Material; • Combustible; Material; B. Finishing Checklist; may

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 12 6 6 Finishing A. Finishing Material • Combustible Material Material which is made of or surfaced with wood, compressed paper, plant fi bers, plastics, or any material capable of igniting and burning, whether fl ame proo...

Page 13 - temperature rise and

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 13 C. Mantel Mantel height listed is measured from the BASE of the heater. 3/4 in. - 12 in. (19 mm - 305 mm) A (CEILING) 30 in. min. (762 mm) Figure 6.4 Mantel Speci fi cations Fire Risk Do NOT obstruct air inlet or outlet...

Page 14 - A. Remove Shipping Materials; DO NOT; Heater Setup

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 14 A. Remove Shipping Materials • Cut and discard the ties bundling the fi rescreen. • Remove screws holding ember bed shipping tabs in place. • Remove the tabs and discard. Replace the screws.• Remove the grate from the s...

Page 15 - Access Controls; Operating Instructions

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 15 Fire Risk • Do not operate heater before reading and understanding operating instructions. Failure to operate heater properly may cause fi re. WARNING A. Manual Controls Access Controls • Controls are located behind the...

Page 17 - C. Wall Switch Control; Canadian Equipment Requirements

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 17 • Remote Transmitter Function - The hand held remote transmitter is only an ON/OFF control. When the transmitter is active, the remote LED light will be RED. Upon initial use, there may be a delay of three seconds befor...

Page 18 - Troubleshooting; A. Troubleshooting Guide; Issues

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 18 9 9 Troubleshooting A. Troubleshooting Guide Issues Possible Causes Solutions Heater doesn’t turn on with the main switch or remote transmitter. 1. Power switch is off. 1. Turn the power switch to the “ON” position. 2. ...

Page 19 - Bulbs; When cleaning glass door:; C. Replacing the Light Bulbs; Burn Risk

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 19 10 10 Maintenance and Service Shock RiskBurn Risk Cleaning, performing maintenance or moving this electric heater without disconnecting power and allowing the heater to cool could create a shock or burn hazard.• Turn co...

Page 20 - E. Maintenance Task List; Inspect

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 20 E. Maintenance Task List D. Heater/Blower Assembly Maintenance • Turn off the circuit breaker/unplug the heater before servicing the heater/blower assembly. • Allow heater to cool before removing.• Open the lower grille...

Page 21 - Reference Materials

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 21 11 11 Reference Materials A. Heater Dimensions 16-7/8 in. (429 mm) 36 in. (914 mm) 14 in. (356 mm) 31 in. (787 mm) 30 in. (762 mm) 17-1/4 in. (438 mm) 31-1/8 in. (791 mm) 3-1/8 in. (79 mm) 6-1/2 in. (165 mm) CF550E-B/CF...

Page 22 - B. Optional Components

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 22 B. Optional Components ON OFF 12V BATTERY COMPARTMENT FRONT BACK SIGNAL LIGHT ON/OFF BUTTONS RCE-HNG-B Remote Control DM1031 DM1036DM1031B DM1036BDM1031S DM1036S Bi-fold Glass Doors WSK-21 WSK-21-W Wall Switch Kit (left...

Page 23 - Cabinet Trim

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 23 Fronts Trim Kits PBT = Polished Brass Finish BKT = Black Finish PBT-550 (CF550E-B Series) BKT-550 (CF750E-B Series) PBT-6 (CF750E-B Series) BKT-6 (CF750E-B Series) Cabinet Trim RP31E (CF550E-B Series)RP36E (CF750E-B Ser...

Page 24 - Marble Lux; Quick Tile Black and Brass Surrounds; Surrounds; no suf; = Polished Brass Finish; BK; Flush Surrounds

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 24 Marble Lux VTS-550 (CF550E-B Series) VTS-550-BK (CF550E-B Series) VTS-36 (CF750E-B Series) VTS-36-BK (CF750E-B Series) Quick Tile Black and Brass Surrounds Surrounds no suf fi x = Polished Brass Finish BK = Black Finish...

Page 25 - Service Parts; CRESTFIRE; Beginning Manufacturing Date: Apr 2005; - Light Tray Assembly

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 25 C. Service Parts Exploded Parts DiagramCF550EV-B Series & CF750EV-B Series Service Parts CRESTFIRE Beginning Manufacturing Date: Apr 2005 Ending Manufacturing Date: Active 1 7 14 2 12 8 3 13 9 15 10 11 3 - Light Tra...

Page 26 - # Description of Part

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 26 Service Parts ListCF550E-B Series & CF750E-B Series Service Parts CRESTFIRE Beginning Manufacturing Date: Apr 2005 Ending Manufacturing Date: Active # Description of Part CF550E-B Series CF750E-B Series Qty. req. 1 ...

Page 27 - WARRANTY; How to Obtain Service; ADDITIONAL INFORMATION:

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 27 D. Limited Warranty Hearth & Home Technologies Inc. 800 W. Jefferson Lake City, MN 55041 WARRANTY Hearth & Home Technologies Inc. (HHT) Electric Fireplaces are tested and inspected prior to shipment and are guar...

Page 28 - – NOTES –; E. Contact Information; DO NOT DISCARD THIS MANUAL; • I m p o r t a n t; DO

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-781 Rev F • 10/06 28 Hearth & Home Technologies Inc. 800 W. Jefferson Lake City, MN 55041 Please contact your Heat & Glo dealer with any questions or concerns. For the number of your nearest Heat & Glo dealer, please visit www.h...