Grindmaster 3342 - Manuals

Grindmaster 3342 – Manual in PDF format online.

Manuals:

Manual

Manual Grindmaster 3342

Summary

Page 3 - Table of Contents

Crathco ® Remote Beverage Freezers Page 1 Table of Contents Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Freezer Application & Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

Page 4 - OPERATOR’S SAFETY PRECAUTIONS; operate this machine.; FREEZER APPLICATION AND SPECIFICATIONS; Remote Freezers; There are four variations of the remote unit:

Page 2 Crathco ® Remote Beverage Freezers OPERATOR’S SAFETY PRECAUTIONS IMPORTANT: Failure to comply with the following safety precautions may result in severe personal injury or damage to the machine. 1. Read and understand the operating instructions in this manual thoroughly. Only allow properly t...

Page 5 - Product Tips; Most applications only require the standard carb tube.; Figure A; Thick product carb tube

Crathco ® Remote Beverage Freezers Page 3 Remote Freezers (cont.) The autofill system on the 3341A and 3352 models is designed to keep the product hopper full to a predeterminedlevel. This assembly eliminates the necessity of pre-mixing concentrate and water and the possibility of manual mixing erro...

Page 6 - Freezer Specifications

Page 4 Crathco ® Remote Beverage Freezers Freezer Specifications Models 3341/3341A Models 3342/3352 Dimensions (HxWxD) 26 1/2”H x 13”W x 29”D67cm x 33cm x 73cm(includes header box) 26 1/2”H x 18 1/2”W x 29” D67cm x 47cm x 73cm (includes header box) Electrical 115 volt, 60 Hz, 1 PhaseDedicated 20 Amp...

Page 7 - INSTALLATION; Shipment Transit; A Tip (N) Tell warning device is placed on each shipping carton at the; Installing your Freezer; NOTE; machine up and place in appropriate area.

Crathco ® Remote Beverage Freezers Page 5 INSTALLATION Shipment Transit The freezer has been operated and tested at the factory. Upon arrival the complete freezer must be thoroughly checked for any damage which may have occurred in transit. NOTE : A Tip (N) Tell warning device is placed on each ship...

Page 9 - OPERATION AND ADJUSTMENTS; How to Operate; Consistency Adjustment; Disconnect electrical power.

Crathco ® Remote Beverage Freezers Page 7 OPERATION AND ADJUSTMENTS How to Operate 1. Sanitize unit following the cleaning instructions starting on page 10. 2. Fill the mix storage hopper following the instructions on page 10. Allow barrel to fill with product to proper level, then insert carb tube ...

Page 10 - CARE AND CLEANING; Drain and Rinse; Turn the freezer panel switch to “CLEAN” for 5 minutes.; Disassembly and Cleaning; from parts bag first.

Page 8 Crathco ® Remote Beverage Freezers CARE AND CLEANING Cleaning and sanitizing frequency must be followed according to state and local health department regulations. NOTE: Each time the freezer is disassembled, all internal components must be thoroughly washed and sanitized using procedures rec...

Page 11 - Reassembly; Do not use tools

Crathco ® Remote Beverage Freezers Page 9 Disassembly and Cleaning (cont.) 5. Slide the rotary half of the seal off the dasher shaft. Inspect both seal components carefully for nicks or cracks. Replace seal if defective. NOTE: To prevent leakage, the surfaces of the rotary seal and stationary seal m...

Page 12 - Sanitizing and Refilling; Place the carburetor assembly in the bottom of the hopper.; a concentration of 100 parts per million.

Page 10 Crathco ® Remote Beverage Freezers Sanitizing and Refilling 1. Re-assemble carburetor assembly by installing the two “O” Rings at the bottom of the carb tube. 2. Place the carburetor assembly in the bottom of the hopper. 3. Install the “O” Rings on valve plunger and lay plunger assembly on a...

Page 13 - Cleaning/Sanitizing Internal Autofill; Remote Pump Sanitizing; The frequency of; Materials Required

Crathco ® Remote Beverage Freezers Page 11 Clean-In-Place Procedure (Daily Cleaning) This equipment has been approved for a Clean-In-Place procedure that does not require complete disassembly on a daily basis. The unit still requires regular complete disassembly for cleaning and sanitizing. To perfo...

Page 14 - MAINTENANCE; Suggested Daily Maintenance; Clean, lubricate and sanitize the freezer following guidelines.; Parts Replacement Schedule; Sanitizing Procedure; Hypochlorite needed to satisfy NSF sanitizing requirements.; SANITIZE; ” mode. Open the dispenser valve allowing; ALL; the; DISPENSE

Page 12 Crathco ® Remote Beverage Freezers MAINTENANCE WARNING: Disconnect power for maintenance. Do not attempt to perform maintenance on the freezer until electrical power has been disconnected. Suggested Daily Maintenance 1. Clean, lubricate and sanitize the freezer following guidelines. 2. Clean...

Page 15 - How to Adjust Belt; Unplug the machine and remove both side and rear panels.; How to Change Back Lit Sign Merchandiser Bulb; Remove the two screws, located on the top of either side of the sign.

Crathco ® Remote Beverage Freezers Page 13 Figure BB How to Adjust Belt CAUTION: Unplug the machine before performing any adjustments. This procedure must be done by a qualified technician. Check the belt tension. The proper belt deflection is 1/2" over all. If the deflectionis more than 1/2"...

Page 16 - Preventative Maintenance Procedure (Every 6 to 12 Months)

Page 14 Crathco ® Remote Beverage Freezers Preventative Maintenance Procedure (Every 6 to 12 Months) A preventative maintenance visit should be performed every 6 to 12 months depending on the usage and environ-ment where the unit is placed. (Ex. seasonal machines – once before season, year round mac...

Page 17 - TROUBLESHOOTING GUIDE

Crathco ® Remote Beverage Freezers Page 15 TROUBLESHOOTING GUIDE Freezer problems can originate from three sources: improper operation, mix problems ormechanical malfunction. Always check first for improper operation and mix problems beforecalling a service technician. Caution: Always disconnect pow...

Page 19 - Exploded View Model 3341 Final Assembly

Crathco ® Remote Beverage Freezers Page 17 Exploded View Model 3341 Final Assembly Exploded View Model 3341A Final Assembly 123456789 10111213141516 W0150570W0600224W0600005W0660060W0600121W0600073W0631903W0600159W0800120W0800121W0800122W0800124W0890218W0520094W0890187W0890220 Stock AssemblyOwners M...

Page 20 - Exploded View Model 3341 Stock Assembly

Page 18 Crathco ® Remote Beverage Freezers Exploded View Model 3341 Stock Assembly Item Part Number Description 1 W0110013 Valve Stud (New Style) 3 W0201263 Evaporator Foam Assy. 4 W0340022 #213 O-Ring 5 W0340055 Square Cut O-Ring 6 W0340058 Barrel Gasket 7 W0380025 Flange Bearing 8 W0430024 Blind F...

Page 21 - Exploded View Model 3341A Base Assembly

Crathco ® Remote Beverage Freezers Page 19 Exploded View Model 3341A Base Assembly Item Part Number Description 1 W0110013 Valve Stud (New Style) 3 W0201342 Evaporator Foam Assy. 4 W0340022 #213 O-Ring 5 W0340055 Square Cut O-Ring 6 W0340058 Barrel Gasket 7 W0380025 Flange Bearing 8 W0430024 Blind F...

Page 22 - Exploded View Models 3341/3341A Base Assembly Refrigeration

Page 20 Crathco ® Remote Beverage Freezers Exploded View Models 3341/3341A Base Assembly Refrigeration Exploded View Models 3341/3341A Motor Assembly 123456789 101112131415161718 W0210169W0210143W0321022W0321013W0380009W0451000W0610110W0610264W0321025W0611055W0611074W0611082W0611235W0611246W0671022W...

Page 28 - Exploded View Model 3342 Final Assembly

Page 26 Crathco ® Remote Beverage Freezers Exploded View Model 3342 Final Assembly Exploded View Model 3352 Final Assembly Item Part Number Description 1 W0151013 Stock Assy. 3352 2 W0600005 Serial Plate 3 W0600224 Owners Manual 4 W0660060 Plastic Bag 5 W0600121 Instr. Sheet, Install Header 6 W06000...

Page 29 - Exploded View Model 3342 Stock Assembly

Crathco ® Remote Beverage Freezers Page 27 Exploded View Model 3342 Stock Assembly Item Part Number Description 1 W0110013 Valve Studs 3 W0201338 Evaporator Foam Assy. 4 W0211112 Drain Tube Fitting 5 W0211210 Frame Assembly 6 W0340022 213 O-Ring 7 W0340055 O-Ring for Valve Body 8 W0340058 Barrel Gas...

Page 30 - Exploded View Model 3352 Stock Assembly

Page 28 Crathco ® Remote Beverage Freezers Exploded View Model 3352 Stock Assembly Item Part Number Description 1 W0110013 Valve Studs 3 W0201348 Evaporator Foam Assy. 4 W0211112 Drain Tube Fitting 5 W0211210 Frame Assembly 6 W0340022 213 O-Ring 7 W0340055 O-Ring for Valve Body 8 W0340058 Barrel Gas...

Page 34 - Model 3342 Wiring Ladder Diagram

Page 32 Crathco ® Remote Beverage Freezers Model 3342 Wiring Ladder Diagram