EMAX HSP10V080V3-230 - Manuals

Page 2 - Contents; Electronic Auto Drain (if

EMAX Electric Operated, Piston Compressors 2 Contents Page No. Page No. Model Specification Charts ............................... 2-3 Description ............................................................ 3 Safety Information ................................................ 4 Tag Definitions .......

Page 3 - Description; Unit configuration and appearance varies by model.

Operating Instructions 3 EMAX Electric Operated, Two-Stage, 15-25 Hp Piston Air Compressors Model EP15V120Y3 EP15H120Y3 EP20H120V3 EP25H120V3 Description 15 Hp Three Phase 15 Hp Three Phase 20 Hp Three Phase 25 Hp Three Phase SCFM @ 175 psi 52.0 52.0 68.0 89.0 Max PSI 175 175 175 175 Motor HP 15 Hp ...

Page 4 - Safety; will; Basic Guidelines; This product or its power cord may; Breathable Air; Death or serious injury can result; Pressurized Components; before each use; Personal Protective Equipment; Inspection; Be careful of moving parts; age to delivery carrier immediately.; Make sure pallet-mounted

EMAX Electric Operated, Piston Compressors 4 Safety This manual contains very important information to know and understand. This is provided for SAFETY and to PREVENT EQUIPMENT PROBLEMS. To help un- derstand this information, observe the following: Danger indicates an imminently hazardous situation ...

Page 5 - Forklift Safety; Lifting Safety; Do not operate unit if damaged; Installation; Area; If ambient temperature drops; Piping

Operating Instructions 5 Forklift Safety 1. Make sure lift operator stays aware while moving compressor. 2. Be sure load is secure and well balanced before moving the compressor. 3. Make sure forks are fully engaged and level before lifting or moving compressor. 4. Keep load as low as possible and o...

Page 6 - Piping / Tank Installation; Use a flexible connector between compressor; Minimum Pipe Size For Compressed Air Lines; SCFM; Test entire piping system; Electronic Auto Drain

EMAX Electric Operated, Piston Compressors 6 Piping / Tank Installation 1. Place tank feet on 1/4” thick rubber pads. Thicker padding will increase vibration and the possibility of cracking the tank or other unit damage. Do not place unit on dirt floor or uneven surface. 2. Fasten anchor bolts snugl...

Page 7 - Improperly grounded electrical; Wiring Installation; Install power leads into terminals opposite motor; When wiring unit with magnetic; Electrical Safety; Wire Sizes; Single Phase Motors - No Magnetic Starter; Single Phase Motors - With Magnetic Starter

Operating Instructions 7 Not included on all units Pipe to tank outlet(s) Manual OPEN/ CLOSE valve Drain interval Drain time Filter access Clean regularly, see Fig 13. Improperly grounded electrical components are shock hazards. Make sure all the components are properly grounded to prevent death or ...

Page 8 - Three Phase Motors; turn off power; Operation; Safety Rules; NEVER

EMAX Electric Operated, Piston Compressors 8 Breaker Power Supply 220 V Power Power Common Wire connection from coil to pressure switch Breaker Power Supply 220 V Power Power Power Common Wire connection from coil to pressure switch 1 2 ground wire 1 2 3 ground wire A1 A2 Pressure Switch A1 A2 Press...

Page 9 - Keep all persons away from the; Continuous Run Feature; Maintenance; Safety Steps; Disconnect, tag and lock out power

Operating Instructions 9 Keep all persons away from the discharge opening of hoses or tools or other points of compressed air discharge. If the machine is installed in an enclosed area, be sure to vent the relief valve outside of the structure or to an unoccupied area. 11. DO NOT use air tools that ...

Page 10 - Compressor components can; Belt Adjustment; Changing Oil; DO NOT use automotive type oil.; Safety Valve; NEVER attempt to regulate or; replace immediately.; Tank; Remember to tighten motor bolts after; Not included on all units

EMAX Electric Operated, Piston Compressors 10 5. Keep all body parts and any hand-held tools or other conductive objects away from exposed live parts of the electrical system. When making repairs or adjustments, stand on a dry, insulated surface and DO NOT con- tact any other portion of the compress...

Page 11 - Maintenance Schedule; Air leaks in unloader lines; Troubleshooting Chart

Operating Instructions 11 Maintenance Schedule Daily Check oil level Check for unusual operation. Correct before damage occurs. Check safety valve Drain tank and traps Weekly Clean air filter Change oil (after first 50 hours) General unit cleaning Check for unusual operation. Correct before damage o...

Page 12 - Warranty Statement

EMAX Electric Operated, Piston Compressors 12 Warranty Statement Emax, INC. (also known as EATON-MAX, Inc. and each of its subsidiaries) makes the following Warranties: 1. THAT EACH ROTARY SCREW AIR COMPRESSOR PUMP TO BE FREE FROM DEFECTS IN MATERIAL, WORKMANSHIP, AND PARTS FOR 10 YEARS ON THE ROTAR...