Page 2 - Contents
1 PISTON COMPRESSOR MANUAL REV022621 Contents Safety Information 2-3 Breathable Air 3 Pressurized Components 3 Personal Protective Equipment 3 Nomenclature 4 Features and Extras 5-7 Pump Riser 5 Belt Tensioner 5 Continuous Run 6 Automatic Tank Drain 7 Installation 8-16 Area 8 Lifting and Movement 9 ...
Page 3 - accidents and injuries.
2 PISTON COMPRESSOR MANUAL REV022621 SAFTEY INFORMATION This manual contains very important information to know and understand. This is to provide for SAFTEY and to PREVENT EQUIPMENT PROBLEMS. To help understand this information, observe the following: DANGER: Danger indicates and imminently hazardo...
Page 4 - read and understand this manual should operate the compressor.
3 PISTON COMPRESSOR MANUAL REV022621 BREATHABLE AIR 1. NEVER use air from this compressor for breathable air except in full compliance with OSHA Standards 29 CFR 1910 and any other Federal, State or Local codes or regulations . 2. DO NOT use airline anti-icer systems in air lines supplying respirato...
Page 5 - Nomenclature
Page 6 - Features and Extras; Risers
5 PISTON COMPRESSOR MANUAL REV022621 Features and Extras Compressors come in many shapes and sizes. Our units have several features that may or may not be present on your unit. These features may be purchased after the fact in kit form. This guide will explain the use and benefit of these features. ...
Page 7 - Air flow is marked with an arrow.
6 PISTON COMPRESSOR MANUAL REV022621 Continuous Run Continuous run allows the pump to turn continuously, hence the name. In this mode the unit pumps up to 140 PSI and then the valves are held close. This allows the pump to enter a free spin state where the unit is pulling in cold air and the simply ...
Page 8 - MUST be cleaned weekly to prevent drain blockage.; complete correct install.
7 PISTON COMPRESSOR MANUAL REV022621 Auto Drain Auto drains are preset timer valves that allow tank moisture to be vented as long as they are powered. The enemy of every compressor/air system is moisture. The auto drain removes some of the hassle of this by allowing the user to set a timer and walk ...
Page 10 - Lifting and Movement/Forklift; Make sure lift operator stays aware while moving the compressor.; NEVER lift with under sized or damaged equipment.; A sling; DO NOT allow persons under the compressor; while it is being lifted.; vertical units, are exceptionally top
9 PISTON COMPRESSOR MANUAL REV022621 Lifting and Movement/Forklift 1. Make sure lift operator stays aware while moving the compressor. 2. Be sure to uncrate the compressor prior to movement. This will allow a visual reference for the balance of the unit. 3. Be sure the load is secure and well balanc...
Page 12 - Electrical Safety; Ensure incoming service has adequate ampere rating.; DO NOT connect ground to air or cooling lines.; installation may void your warranty.
11 PISTON COMPRESSOR MANUAL REV022621 Electrical Safety 1. Follow all NEC and local codes for electrical wiring. Allow only authorized service personnel or certified electricians to install electrical components. 2. Put unit on a dedicated circuit and make sure no other electrical equipment is wired...
Page 14 - Single phase unit WITH magnetic starter:
13 PISTON COMPRESSOR MANUAL REV022621 5. Single phase unit WITH magnetic starter:
Page 16 - CFM; – 1⁄2; DANGER: NEVER install a shut off valve such as a glove or gate valve
15 PISTON COMPRESSOR MANUAL REV022621 Piping (Safety steps) 1. Install appropriate flow-limiting valves as necessary according to pipe size(s) used and run lengths. This will reduce pressure in case of hose failure, per OSHA Standard 29 CFR 1926.302(b)(7). 2. Flow-limiting valve are listed by pipe s...
Page 22 - Troubleshooting; Issue; CONSTANT CFM rating,
21 PISTON COMPRESSOR MANUAL REV022621 Troubleshooting Some unit issues can be fixed simply by verifying the following guide. It is advised to go through the guide prior to calling technical support to help expedite the assistance process. Issue Action Compressor does not run Check unit power supply....
Page 23 - Required maintenance schedule to maintain warranty status.; SMART OILTM extended auto ship
22 PISTON COMPRESSOR MANUAL REV022621 Warranty Statement • Standard Warranty: That each compressor unit is free from defects in material, workmanship, and parts for 1 year from the date of delivery. This Standard Warranty includes 1 year of warranty labor from an authorized technician. Manufacturer ...
Page 24 - Limited Lifetime Warranty is not prorated and has no hour limits.
23 PISTON COMPRESSOR MANUAL REV022621 Limited Lifetime Warranty is not prorated and has no hour limits. **Limited Lifetime Warranty, non-prorated, no hour limits. In the case the product has been discontinued at any point the Limited lifetime Pump warranty will last five years past the discontinued ...
Page 25 - FAILURE TO PROVIDE; instructions will void this warranty.
24 PISTON COMPRESSOR MANUAL REV022621 Warranty shall be voided under the following conditions: Exposing electrical components to rain or water or installing the unit in a hostile environment such as acid vapors or any caustic or abrasive matter that may be ingested into the pump or installing the un...