EMAX HI10V080V1 - Manuals - manualsarea.com

Page 2 - Contents; Area

2 EMAX Electric Operated, Piston Compressors Model EP05H080I1 EP07H080V1 EP10H120Y1 EP07H080V3 EP10H120Y3 Tank Type Horizontal Horizontal Horizontal Horizontal Horizontal Dimensions 76 x 30 x 56 76 x 30 x 56 78 x 32 x 50 76 x 30 x 56 78 x 32 x 50 Model EP05V080I1 EP07V080V1 EP10V120Y1 EP07V080V3 EP1...

Page 3 - Description; Unit configuration and appearance varies by model.

3 Operating Instructions Model EP15V120Y3 EP15H120Y3 EP20H120V3 EP25H120V3 Description 15 Hp 15 Hp 20 Hp 25 Hp Three Phase Three Phase Three Phase Three Phase SCFM @ 175 psi 52.0 52.0 68.0 89.0 Max PSI 175 175 175 175 Motor HP 15 Hp 15 Hp 20 Hp 25 Hp Motor RPM 1750 1750 1750 1750 Voltage 208/230/460...

Page 4 - Safety; will; Breathable Air; before each use; Personal Protective Equipment; Inspection; Be careful of moving parts

4 EMAX Electric Operated, Piston Compressors Safety This manual contains very important information to know and understand. This is provided for SAFETY and to PREVENT EQUIPMENT PROBLEMS. To help un-derstand this information, observe the following: Danger indicates an imminently hazardous situation w...

Page 5 - Forklift Safety; Do not operate unit if damaged; Installation; If ambient temperature drops

5 Operating Instructions Forklift Safety 1. Make sure lift operator stays aware while moving compressor. 2. Be sure load is secure and well balanced before moving the compressor. 3. Make sure forks are fully engaged and level before lifting or moving compressor. 4. Keep load as low as possible and o...

Page 6 - Piping / Tank Installation; before; Electronic Auto Drain; Minimum Pipe Size For Compressed Air Lines; SCFM

6 EMAX Electric Operated, Piston Compressors Piping / Tank Installation 1. Place tank feet on 1/4” thick rubber pads. Thicker padding will increase vibration and the possibility of cracking the tank or other unit damage. Do not place unit on dirt floor or uneven surface. 2. Fasten anchor bolts snugl...

Page 7 - Improperly grounded electrical; Wiring Installation; When wiring unit with magnetic; Single Phase Motors - No Magnetic Starter; Be sure to consider; Not included

7 Operating Instructions Improperly grounded electrical components are shock hazards. Make sure all the components are properly grounded to prevent death or serious injury. 9. Make sure proper overload protection for the motor is installed. Wiring Installation Install power leads into terminals oppo...

Page 8 - Three Phase Motors; turn off power; Operation; Safety Rules; NEVER

8 EMAX Electric Operated, Piston Compressors Three Phase Motors (See figure 7) 1. Connect first power lead to 1L1. 2. Connect second power lead to 3L2. 3. Connect third power lead to 5L3. 4. Connect ground wire to existing motor ground wire. 5. Check for proper motor rotation. When facing motor shaf...

Page 9 - Continuous Run Feature; Maintenance; Safety Steps; Disconnect, tag and lock out power

9 Operating Instructions Keep all persons away from the discharge opening of hoses or tools or other points of compressed air discharge. If the machine is installed in an enclosed area, be sure to vent the relief valve outside of the structure or to an unoccupied area. 11. DO NOT use air tools that ...

Page 10 - Compressor components can; Belt Adjustment; Remember to tighten motor bolts after; Not included on all units; Changing Oil; DO NOT use automotive type oil.; Safety Valve; NEVER attempt to regulate or; Tank

10 EMAX Electric Operated, Piston Compressors 1. Close manual valve.2. Remove filter cap and filter. 3. Clean filter.4. Reassemble drain.5. Open manual valve. 5. Keep all body parts and any hand-held tools or other conductive objects away from exposed live parts of the electrical system. When making...

Page 11 - Maintenance Schedule; before damage occurs.; Troubleshooting Chart

11 Operating Instructions Maintenance Schedule Daily Weekly Monthly Every 3 months Check oil levelCheck for unusual operation. Correct before damage occurs. Change oil Clean air filterChange oil (after first 50 hours) Check and tighten all bolts as requiredCheck all connections for air leaksCheck be...

Page 12 - Warranty Statement

12 EMAX Electric Operated, Piston Compressors Warranty Statement Emax, INC. (also known as EATON-MAX, Inc. and each of its subsidiaries) makes the following Warranties:1. THAT EACH ROTARY SCREW AIR COMPRESSOR PUMP TO BE FREE FROM DEFECTS IN MATERIAL, WORKMANSHIP, AND PARTS FOR 10 YEARS ON THE ROTARY...