Champion Power Equipment 70008 - Manuals

Safety Rules Rev 70008-20071026 3 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instructions could result in serious injury or death. WARNING The engine exhaust from this product contains chemicals known to the state of California to cause cancer...

Safety Rules 4 Rev 70008-20071026 DANGER Propane (LPG) is highly flammable and explosive. Fire or explosion can cause severe burns or death if the gas is ignited. Before starting the generator Turn the generator off. Inspect your LPG tank for damage or leaks. Attach only approved tanks that have bee...

Controls and Features Rev 70008-20071026 5 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Generator (1) Fuel Valve – Turn this valve to the “On” p...

Controls and Features 6 Rev 70008-20071026 Power Panel (1) Gas Inlet – Nipple for LPG hose connection. (2) Engine switch – Flip switch to the “On” position to start the generator. Flip to the “Off” position to turn off the generator. (3) Circuit Breakers – Protects the generator against electrical o...

Controls and Features Rev 70008-20071026 7 Parts Included Your Model 70008 Gasoline Powered Generator ships with the following parts: Wheel Kit Axle 1 piece 8” Solid Wheel 2 pieces Support Leg 1 piece Vibration Mounts 2 pieces Bolt Kit Wheel Retaining Pins 2 pieces Flat Washers 2 pieces Cap Screws a...

Assembly 8 Rev 70008-20071026 Assembly Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. If you have any questions regarding the assembly of your generator, call our help line at 1-877-338-0999. Pleas...

Assembly Rev 70008-20071026 9 3. Add 1.16 qt (1.1 L) of oil and replace oil fill cap/dipstick. See “Specifications” for oil recommendations based on operating conditions. 4. Check engine oil level daily and add as needed. CAUTION The engine is equipped with a low-oil-shutoff and the will stop when t...

Operation 10 Rev 70008-20071026 Operation Generator Location Please consult your local authority. In some areas, generators must be registered with the local utility. Generators used at construction sites may be subject to additional rules and regulations. This generator must have at least five feet...

Operation Rev 70008-20071026 11 2. Let the generator run at no-load for several minutes to stabilize internal temperatures of the engine and generator. 3. Turn the engine switch to the “Off” position. 4. Turn the fuel valve to the “Off” position. 5. Close the OPD valve on the LPG cylinder. Do Not Ov...

Operation 12 Rev 70008-20071026 Wattage Reference Chart Use the chart to determine approximate wattage requirements for your equipment. NOTE Starting watts can exceed three times the running watts. The values in the following table are approximate. Refer to your tool or appliance for actual wattage ...

Maintenance 14 Rev 70008-20071026 Spark Arrester 1. Allow the engine to cool completely before servicing the spark arrester. 2. Remove the two screws holding the cover plate which retains the end of the spark arrester to the muffler. 3. Remove the spark arrester screen. 4. Carefully remove the carbo...

Storage Rev 70008-20071026 15 Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. For longer term storage, please follow these guidelines. Engine Storage 1. Allow the engine to cool completely before storage. 2. Clean the engine according t...

Specifications 16 Rev 70008-20071026 Specifications Engine Specifications Engine 338 cc OHV CPE CARB and EPA certified Generator Specifications Running Wattage 3500 Watts Starting Wattage 4200 Watts AC Load 120 V Phase Single Frequency 60 Hz Fuel Capacity Liquefied Petroleum Gas Weight 174.17 lbs. (...

Specifications 18 Rev 70008-20071026 Parts List No Part Number Description Qty 1 CG500-031604F2 Gas Inlet Combination 1 2 ST02FD-1151205A Engine Switch 1 3 2630 Intelligauge 1 4 2631 Touch Switch 1 5 ST188FD-1710001 Receptacle L5-30R 1 6 ST188FD-1710003 Receptacle 5-20R 2 7 ST05FD-1151208-M Groundin...

Specifications 20 Rev 70008-20071026 Wiring Diagram

Warranty 22 Rev 70008-20071026 Warranty CHAMPION POWER EQUIPMENT 1 YEAR LIMITED WARRANTY Effective September 1, 2006. Replaces all undated warranties and all warranties dated before September 1, 2006. Warranty Qualifications Champion Power Equipment (CPE) will register this warranty upon receipt of ...

Warranty Rev 70008-20071026 23 Champion Power Equipment, Inc (CPE), The California Air Resources Board (CARB) and the United States Environment Protection Agency (U.S. EPA.) Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with both the U.S. EPA and state of Calif...

Warranty 24 Rev 70008-20071026 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System Warranty Coverage. Emission Control System Warranty (ECS Warranty) for 1995 and later model year California small off-road engines (for other states, 1997 an...

Warranty Rev 70008-20071026 25 i. Unapproved add-on or modified parts may not be used to modify or repair a CPE engine. Such use voids this ECS Warranty and shall be sufficient grounds for disallowing an ECS Warranty claim. CPE shall not be liable hereunder for failures of any warranted parts of a C...